Akai-QXD3305-cs-sm维修电路原理图.pdf

《Akai-QXD3305-cs-sm维修电路原理图.pdf》由会员分享，可在线阅读，更多相关《Akai-QXD3305-cs-sm维修电路原理图.pdf（26页珍藏版）》请在收音机爱好者资料库上搜索。

1、Page CD MICRO SYSTEM QX-D3305 PRODUCT SAFETY NOTICE Performance Specifications . 1 Electrical Parts List . 4 Printed Circuit Boards . 13 Wiring Diagram . 21 Schematic Diagrams . 23 Alignment Set-up Procedurecs . 29 Equipment Connection Diagrams . 30 Voltage Chart . 32 IC Lead Identification and Inte

2、rnal Diagrams . 35 Block Diagrams . 39 Exploded Drawing Parts List . 42 Exploded Drawings . 46 Many electrical and mechanical parts in this chassis have special safety characteristics. These safety characteristics often pass unnoticed and the protection afforded by them cannot necessarily be obtaine

3、d by using replacement components rated for higher voltage, wattage, etc. Replacement parts that have these special safety characteristics are identified in this manual and its supplements; electrical components having such features are identified by in the schematic diagram and the parts list. Befo

4、re replacing any of these components, read the parts list in this manual carefully. The use of substitute replacement parts that do not have the same safety characteristics as specified in the parts list may create shock, fire or other hazards. CONTENTS RadioFans.CN 收音机爱 好者资料库 Power Supply: AC 230V

5、50Hz Output Load: 4 ohm non-reactive Reference Output: 500 mW, 4 ohm Input Signal Source: External AM Loop Antenna 75 ohm Dummy for FM Modulation: 30% 400Hz for AM 80% for Power 75kHz Deviation 1000Hz for FM 1kHz, 750mV Aux Input Remarks: 7.5kHz Pilot Tone 40kHz L+R 1000Hz GENERAL TEST CONDITION CD

6、SECTION UNIT NOMINALLIMIT 1. 10% Dis. Output Power (1kHz, 0dB)W54.5 2. Frequency Response (100Hz-20kHz/1kHz, 0dB)dB16 3. De-emphasis Response (1kHz, 0dB/5K, -5dB/16kHz, -9dB)dB24 4. Channel Balance (1kHz, 0dB)dB12 *5. Channel Separation (1kHz, 0dB)dB4540 *6. T.H.D. + Noise (1kHz, 0dB)%0.31.0 *7. S/N

7、 Ratio (1HF-A) (1kHz, 0dB)dB6055 8. CD Speed (1000Hz)Hz-1 *9. Dynamic RangedB8070 10. Wedge m-600 11. Black Dot m800600 12. Fringer PrintTrack-No. 18 13. Eccentricity TCD-712 ABEXm-150 14. Vertical Deviation TCD-731R ABEXmm-0.8 15. Seaching Time TN01-TN024Sec.58 TN024-TN01Sec.58 16. Minimum Operatio

8、n Voltage%8590 17. CD Max. Vol. HummV510 *with external A CURE L.P.F. ITEM 1 - 9 Test Disc CBD SONY YEDS7 ITEM 10 - 12 Test Disc PHILIPS 444A ITEM 15 Test Disc PHILIPS 444 Level Matching Aux 750 mV AM 55% 5mVdB3 FM 40kHz 1mVdB3 CD -10dBdB-63 MTT-112NdB3 TEST ITEMS AM SECTION, AMPLITUDE MODULATION UN

9、ITNOMINALLIMIT 1. Tuning RangekHz522-1620- 2. I. F.kHz4503 3. S/N 10mV/m0.999MHzdB3630 4. Sens. (at S/N 20dB)0.603MHzV/m9971995 0.999MHzV/m9971995 1.404MHzV/m9971995 5. I. F. Rejection 0.603MHzdB5046 6. Image Rejection 1.404MHzdB3024 7. Spurious RejectiondB3525 8. Bandwidth, -6 dB, at0.999MHzkHz64 -

10、 9 (Max. Sens. +6 dB) 9. ACA (9 kHz) Input 0.999MHzdB2015 10. AGC Figure Merit100mV/mdB4540 11. Distortion, 5mV/m, 30%13 80%36 12. 10% THD Power ACW54.5 13. a. Tweet (2nd 900kHz & 3rd 1350kHz)dB1510 at 75 dB I/P 14. Audio Fidelity, Centre (6) dBHz60/2200120/2000 15. Low Voltage AC%8085 16. a. Mod. H

11、um 10mV/mdB3630 b. Hum at Min. Vol.mV13 17. Auto Stop Sens.dB6470 18. Step FrequencykHz-9 TEST ITEMS CASSETTE SECTION UNITNOMINALLIMIT A(PLAYBACK) 1. Tape Speed (MTT-111N)%13 2. Wow & Flutter JIS WTD (MTT-111N)%0.250.38 3. Take Up Torque (PLAY)g-cm3060 4. F. F. / Rew. Torque g-cm60140 5. Output Powe

12、r (MTT-112BN) 10% THDW54.5 6. S/N Ratio (MTT-112BN)dB4540 7. T. H. Distortion (MTT-112BN)%23 8. Frequency Response (MTT-257H)125HzdB36 6.3kHzdB36 9. Separation (MTT-141N) w/BPFdB4030 10. Cross Talk (X- BASS OFF) w/BPF (MTT-121N)dB5545 11. Hum & Noise VR MAX (w/o Tape)mV3050 VR MIN(w/o Tape)mV13 B(RE

13、CORD) 1. T. H. / Distortion %48 2. Erase Ratio Effect (MTT-112BN) for LeveldB5548 3. Rec. / Playback Level Difference (Radio)dB24 4. Rec. / Play S/N Ratio (with A Filter)dB4035 5. Frequency Response (MTT-257)125HzdB47 (Ref: 1kHz 0dB)6.3kHzdB47 Remarks: All measurement should be done in Bypass mode w

14、ithout X-Bass/Toneeffect. TEST ITEMS 12 PERFORMANCE SPECIFICATIONSPERFORMANCE SPECIFICATIONS - CONTINUED RadioFans.CN 收音机爱 好者资料库 FM SECTION, FREQUENCY MODULATION UNITNOMINALLIMIT 1. Tuning RangeMHz87.5-108- 2. I. F.MHz10.70.3 3. 30dB S/N90MHzV2226 98MHzV2226 106MHzV2226 4. -3dB Limit Sens.dB1630 5.

15、I. F. Reection 98MHzdB6050 6. Image Rejection 106MHzdB3022 7. Spurious Rejection (F + 0.535 MHz)dB4035 (Max. Sens. +6dB) 8. AM Suppression(60dB I/P)dB4530 9. Mod. Hum(60dB I/P)dB4842 10. Distortion at 1mV/m (Mono)%12 100mV/m75kHz% 11. Audio Fidelity, (-3dB) (Pre-emphass) (75S)/(50S)Hz60/9000120/6000

16、 12. Power Out, Max. ACW6.55.5 10% THDW54.5 13. Low Voltage AC%8085 14. S/N Ratio at 1mV/m98MHzdB5546 15. Alternate Channel Selective 400kHzdB2518 16. Stereo SeparationdB2622 17. 19kHz Leak CarrierdB3227 18. Stereo IndicationdB2630 19. Step FrequencykHz-50 20. Auto Stop Sens.dB3035 Remarks: NOTE: Al

17、l measurement should be done in Bypass mode without X-Bass/Tone/effect. TEST ITEMS AMPLIFIER SECTION UNITNOMINALLIMIT 1.Output Power Per Channel (750mV IN)10%1kHzW54.5 2.Frequency Response: +/-6dB(L&R)Hz/kHz-100/20 3.THD (1kHz, Ref O/P)(L&R)%0.51.0 4.Channel UnbalanceL&R1kHzdB13 5.Minimum Vol. Hum (

18、Unwgtd/wgtd)mV13 6.Maximium Vol. Hum (Unwgtd/wgtd)mV510 7.X-Bass100HzdB83 8.S/N (Unwgtd/CCIR-ARM2k)L&R1kHzdB6050 9.Seperation1kHzdB4540 10. Cross Talk for Input (AUX/CD-Ref) w/BPF1kHzdB4540 TEST ITEMS 34 PERFORMANCE SPECIFICATIONS - CONTINUEDELECTRICAL PARTS LIST Ref. No.DescriptionMfrs Part No. Qty

19、. PCB TUNER PCBPCB CD6606-01-01 (94V0)033-006606-6001 CASSETTE & CD PCBPCB CD6606-01-02 (94V0)033-006606-6001 POWER PCBPCB CD6606-01-03 (94V0)033-006606-6001 DOOR SW. PCBPCB CD6606-01-04 (94V0)033-006606-6001 CONNECT PCBPCB CD6606-01-05 (94V0)033-006606-6001 MOTOR & LEAF SW. CONNECT PCB PCB CD6606-0

20、1-06 (94V0)033-006606-6001 RECTIFIER PCBPCB CD6606-01-09 150 x100 x1.6mm/2 (94V0)033-006606-1011 KEY & DISPLAY PCBPCB CD6606-01-08 224x124x1.6mm/2 (94HB)033-006606-1001 REMOTE CONTROL SECTION REMOTE CONTROL HANDSET, w/BATTERY,043-R11817-0101 L.GR COLOR (CD330 x/CD66xx/CD6821/RV2003) AUX SECTION RESI

21、STORS All are +-5% 1/16W (1/8W) tape & wheel resistors unless otherwise specified R501,502*CdF RESISTOR 47 Kohm001-047351-0162 R503,504RESISTOR 8.2 Kohm 001-082251-0162 CAPACITORS C501,502ELECT CAP 4.7 MFD/50V +-20% (5x11)006-004000-50D2 MISCELLANEOUS JK501PIN JACK #HSP-212V-06 WHITE/RED118-020212-0

22、011 CD SECTION RESISTORS All are +-5% 1/16W (1/8W) tape & wheel resistors unless otherwise specified R51,56*CdF RESISTOR 33 Kohm 001-033351-0162 R42,58RESISTOR 56 Kohm 001-056351-0162 R60*CdF RESISTOR 10 ohm001-010051-0161 R5,6,7,9,13,28,29,30,38,40,43,57,*CdF RESISTOR 1 Kohm 001-010251-01613 LM-CL1

23、 R1,16,20,25,26,27,31,37,39,47,48,49,*CdF RESISTOR 10 Kohm001-010351-01616 50,59,61,88 R11,17*CdF RESISTOR 100 Kohm 001-010451-0162 R34*CdF RESISTOR 15 Kohm 001-015351-0161 R41*CdF RESISTOR 220 ohm 001-022151-0161 R45*CdF RESISTOR 2.2 Kohm 001-022251-0161 R23,24,44*CdF RESISTOR 22 Kohm001-022351-016

24、3 R33RESISTOR 220 Kohm001-022451-0161 R21,22RESISTOR 270 ohm 001-027151-0162 R36*CdF RESISTOR 3.3 Kohm 001-033251-0161 R15RESISTOR 39 Kohm001-039351-0161 R10,14*CdF RESISTOR 4.7 Kohm 001-047251-0162 R32,46,52,53,54,55,86*CdF RESISTOR 47 Kohm 001-047351-0167 R35RESISTOR 5.6 Kohm 001-056251-0161 R12RE

25、SISTOR 680 ohm001-068151-0161 R4RESISTOR 91 ohm 001-091051-0161 CAPACITORS C5,6,17,22,39,40,41,42,47(F003-010380-025) CERAMIC CAP 0.01 uF/003-010380-0509 50V +80%-20% C4,23,25,26,27,29,30,53,54CERAMIC CAP 0.1 uF/16V +80%-20%003-010480-0169 C8,12CERAMIC CAP 0.002 uF/50V +80%-20%003-020280-0502 C43CER

26、AMIC CAP 47 pF/50V +-10%003-047010-0501 C35,36CERAMIC CAP 470 pF/50V +-10% TAPING003-047110-0512 (B TYPE/4mm) C31,32,33,34,50CERAMIC CAP 0.047 uF/50V +80%-20%003-047380-0505 C61CERAMIC CAP 0.0047 uF/16V +80%-20%003-247280-0161 (EP050YF472Z) (AXIAL TAPED 52mm) 5 6 ELECTRICAL PARTS LIST - CONTINUEDELE

27、CTRICAL PARTS LIST - CONTINUED Ref. No.DescriptionMfrs Part No. Qty. C56CERAMIC CAP 56 pF/50V +-10%003-056010-0501 C7CERAMIC CAP 100 pF/50V +-5% (NPO)003-410150-0501 (CC45-CH1H101J/RBU04CH101J-L) C55CERAMIC CAP 1 pF/50V +-0.25pF (NPO)003-410830-0501 (CC45-CH1H010CY) C19,20CERAMIC CAP 15 pF/50V +-5%

28、(NPO)003-415050-0502 (CC45-CH1H150J/RBU04CH150J-L) C15,16CERAMIC CAP 27 pF/50V +-5% (NPO)003-427050-0502 (CC45-CH1H270J/RBU04CH270J-L) C45 MYLAR CAP 0.015 uF/100V +-5%004-015350-1001 C51,52 MYLAR CAP 0.22 uF/100V +-10%004-022410-1002 C38 MYLAR CAP 0.0027 uF/100V +-10%004-027210-1001 C37 MYLAR CAP 0.

29、0047 uF/100V +-10%004-047210-1001 C10,11ELECT CAP 3.3 MFD/50V +-20% (5x11)006-003000-50D2 C63*CdF (F006-010000-16C) ELECT CAP006-010000-50C1 10 MFD/50V +-20% (VX/5x11) C1,18,21,60,62*CdF ELECT CAP 100 MFD/10V +-20%006-010100-10C5 (VX/5x11) C9,24*CdF ELECT CAP 1000 MFD/10V +-20% 006-010200-10C2 (VX/1

30、0 x12) C3,13,14ELECT CAP 22 MFD/25V +-20% (VX/5x11)006-022000-25C3 C2,28,44,46,48,57,58,59*CdF ELECT CAP 47 MFD/16V +-20% 006-047000-16C8 (VX SERIES/5x11) TRANSISTORS Q2,3TRLPNPSST-TAP&TO-092 3CG1015/008-610150-0002 2SA1015 Q4,5,7TRLNPNSST-TAP&TO-092 3DG1815008-618150-0003 Q1,6TRLPNPPWR-TAP&TO-092 3

31、CA8550 008-685500-0002 CRYSTAL X2CRYSTAL 75.0 KHz +-20ppm TF26-75009-375000-0031 INTEGRATED CIRCUITS IC3ICMOTORDRIVER-04CH TA2092N 010-832092-0001 (TOSHIBA) (87-A20-157-01J/AIWA) IC2ICCDP-153CDSP+ASP TA2153FN010-832153-0001 IC1ICMCU-09K-LCD TC94A09F-202010-849409-0001 DIODES D2,3,4,5,6,8,10,11DIODE

32、IN-4148 ROHM/TELEFUNKEN TAP*50011-004148-0008 KEL(NS)(TAP:52mm)/NS(FAIRCHILD)/SEMTECH D7ZENER IN-5228B, 3.9V, 1/2W011-010039-1201 D1,9RECTIFIER IN-4001B/IN-4001 (DC)011-024001-0002 INDUCTOR L1INDUCTOR 10 uH CEC-100K/ZHFAI03-100KT018-010016-0001 +-10% (CdF) RESONATOR X1CERAMIC RESONATOR 16.93 MHz ZTA

33、16.93MX020-001693-0051 (ZHEJIANG JIAKANG) MISCELLANEOUS CD&-TLB-01-SAMG-N CD MECHANISM153-000316-0001 CMS-B31BG6U SEN1REMOTE/CONTROL PHOTO RECEIVER111-007138-0001 ROHM/RPM7138-V4 CD DOOR SECTION RESISTORS All are +-5% 1/16W (1/8W) tape & wheel resistors unless otherwise specified R95,96*CdF RESISTOR

34、 1 Kohm 001-010251-0162 Ref. No.DescriptionMfrs Part No. Qty. R97,98*CdF RESISTOR 10 Kohm 001-010351-0162 R91,92*CdF RESISTOR 220 ohm 001-022151-0162 R90RESISTOR 5.6 ohm +-5% 1/4W001-056850-0141 CAPACITORS C94CERAMIC CAP 0.1 uF/16V +80%-20%003-010480-0161 C91,92,93ELECT CAP 470 MFD/10V +-20% (8x11.5

35、)006-047100-10D3 C95,96ELECT CAP 220 MFD/10V +-20% 006-122100-10D2 (SMALL SIZE) (6.3x7) TRANSISTORS Q93,94TRLNPNPWR-TAP&TO-092 3DA8050008-680500-0002 Q91,92TRLPNPPWR-TAP&TO-092 3CA8550008-685500-0002 RESONATORS SW91LEAF SWITCH LSA-1120Y2/LS35 (CdF)022-001120-0021 SW92MICRO SWITCH MQS-2023-000002-000

36、1 MISCELLANEOUS MOT1MOTOR-DC-012V-NORMAL 12V #WRF-370C-15370151-121537-0011 CONTROL & DISPLAY SECTION RESISTORS All are +-5% 1/16W (1/8W) tape & wheel resistors unless otherwise specified R72*CdF RESISTOR 10 Kohm 001-010351-0161 R78,81*CdF RESISTOR 1.5K001-015251-0162 R77,80RESISTOR 2 Kohm 001-02025

37、1-0162 R76,79RESISTOR 2.7 Kohm001-027251-0162 R74RESISTOR 3.9K001-039251-0161 R75RESISTOR 6.2 Kohm 001-062251-0161 R71,73*CdF RESISTOR 6.8 Kohm 001-068251-0162 CAPACITOR C399(F003-010380-025) CERAMIC CAP 0.01uF/50V003-010380-0501 SWITCHES SW1,2,3,4,5,6,7,8,9,10,11,12*CdF TACT SWITCH 4P 4.3mm 100G 02

38、1-110200-00112 #1102-4 (=021-008300-000) MISCELLANEOUS D303LED-G-3MM&-S-&-& W03304PGSC-KL 3mm110-033041-0131 PURE GREEN WATER CLEAR SUPER BRIGHT LCD1LCD-P-&D-80 x25SM022P JT4-01600112-001600-0001 80 x25x2.8mm TRANSMISSIVE/POSITIVE GENERAL SECTION WIRES SW7,8JP WIRE AWG26#1007 3x3mm 80mm YELLOW051-67

39、3080-0102 W6JP WIRE AWG26#1007 3x3mm 100mm ORANGE051-673100-0031 W5JP WIRE AWG26#1007 3x3mm 100mm BLACK051-673100-0091 W3JP WIRE AWG26#1007 3x3mm 200mm RED (CdF)051-673200-0061 W4JP WIRE AWG26#1007 3x3mm 200mm BLACK (CdF)051-673200-0091 CN1FFC CABLE 16 PINS L=65mm P:1mm KLW9586-1A040-160065-1021 (01

40、-0735C-3F16-057S04N08-08NN) (CdF) CN4,5FFC CABLE 16 PINS L=220mm PITCH:1mm040-160220-1002 RHW0276-1B (02-0735C-3F16-212S04N08-08NN) CN6CONN PIN 2 PINS (3.5+193+3.5) PITCH 2mm050-020200-2001 AWG26#UL2651 GREY COLOR CN18,19CONN PIN 4 PINS (3.5+33+3.5) PITCH 2mm050-040040-2002 AWG26#UL2651 FLAT CABLE G

41、REY COLOR CN17CONN PIN 5 PINS (3.5+43+3.5) PITCH 2mm050-050050-2001 AWG26#UL2651 CN13CONN PIN 5 PINS (3.5+203+3.5) PITCH 2mm050-050210-2001 AWG26#2651 FLAT CABLE GREY COLOR 7 8 ELECTRICAL PARTS LIST - CONTINUEDELECTRICAL PARTS LIST - CONTINUED Ref. No.DescriptionMfrs Part No. Qty. CN16CONN PIN 8 PIN

42、S (3.5+53+3.5) PITCH:2mm050-080060-2001 AWG26#UL2651 FLAT CABLE GREY COLOR CN15CONN PIN 8 PINS (3.5+203+3.5) PITCH 2mm050-080210-2001 AWG26#UL2651 FLAT CABLE GREY COLOR CONN PIN 11 PINS (3.5+33+3.5) PITCH 2mm050-110040-2001 AWG26#UL2651 GREY CN21HSG CD138-4B(C) PEC 2507-H-4 w/160mm136-040138-C001 BL

43、K,RED,VIO,BLUE AWG26#UL1007 SLDG 4mm CN11HSG CD368-4B(C) PEC 2507-H-4 w/234mm BLK136-040368-C011 SHIELD WIRE AWG30#UL2547/3C SLDG.2mm LSW PCB TO CD PCBHSG VCD30D-4A JST PHR-04 w/150mm136-04V30D-2001 BLK,BRN,RED,ORG AWG28#UL1007 SLDG 3mm CN3HSG CDR931-5 JST-PHR/2 w/150mm BLK,RD, 136-050931-2001 OR,YE

44、LL,GN AWG28#1095 JP 3mm HSG CD769C-6(C) PEC 2001H-6 TO PEC136-06769C-B001 2003H-6 w/180mm RED,BLKx5 AWG28#UL1571 MISCELLANEOUS AM LOOP ANT .388-88 & 388-89 MOLD BK (ABS)132-020388-8821 5264-2 2.54mm w/5750mm BK AWG26#UL1007 CN101HEADER MOLEX 2 PINS 5268-02A PITCH 2.5mm135-005268-0201 HORIZONTAL TYPE HR4FFC CONN SOCKET 16P P:1 TAIKO DENKI 135-006116-1601 6116-0101/CFF7816-01-01/TOC-B16X-G2) (CdF) HR11,21HEADER 4PINS PEC #2507-WS-4 P:2.5mm135-2507WS-0402 VERTICAL REPLACE:135-005267-040 HR04FFC/FPC CONNECTOR 16 PINS PIT