Akai-AM2200-int-sm维修电路原理图.pdf

上传人：cc518

文档编号：98924

上传时间：2020-11-01

格式：PDF

页数：23

大小：2.28MB

《Akai-AM2200-int-sm维修电路原理图.pdf》由会员分享，可在线阅读，更多相关《Akai-AM2200-int-sm维修电路原理图.pdf（23页珍藏版）》请在收音机爱好者资料库上搜索。

1、RadioFans.CN 收音机爱好者资料库 SECTION 1 SERVICE MANUAL TABLE OF CONTENTS I. TECHNICAL DATA 2 II. DISMANTLING OF UNIT 3 III. CONTROLS 4 IV. PRINCIPAL PARTS LOCATION 4 V. LEVEL DIAGRAM 5 VI. MAIN AMP ADJUSTMENT . 5 VII. CLASSIFICATION OF VARIOUS P.C BOARDS. 6 1. RELATION OF P.C BOARD TITLE AND IDENTIFICATIO

2、N NUMBER 6 2. COMPOSITION OF VARIOUS P.C BOARD . 7 For basic adjustments measuring methods, and operating principles, refer to GENERAL OPERATING PRINCIPLES AND ADJUSTMENTS. RadioFans.CN 收音机爱好者资料库 I. TECHNICAL DATA 1. Power Amplifier Section Continuous Power Output POWER BANDWIDTH (1HF) SIGNAL TO NO

3、ISE RATIO (1HF) RESIDUAL NOISE CHANNEL SEPARATION (1HF) DAMPING FACTOR OUTPUT 20 watts per channel, minimum RMS, at 8 ohms from 20 to 20,000 Hz with no more than 0.5% total harmonic distortion 10 to 45,000 Hz/8 ohms (Total Harmonic Distortion 0.5%) Phono: Better than 85 dB Aux: Better than 95 dB Les

4、s than 0.8 mV at 8 ohms Phono: Better than 55 dB at 1,000 Hz More than 60 (1 kHz, 8 ohms) Speakers: A,B (4 to 16 ohms)/A+B(8 to 16 ohms) Headphone: 4 to 16 ohms 2. Pre Amplifier Section INPUT SENSITIVITY AND IMPEDANCE OUTPUT LEVEL AND IMPEDANCE FREQUENCY RESPONSE TONE CONTROL LOUDNESS CONTROL Phono:

5、 3 mV/47 k ohms AUX: 150 m V/ 100 k ohms Tuner: 150 mV/100 k ohms Tape Monitor: PIN; 150 mV/100 k ohms DIN; 150 mV/100 k ohms TapeREC: PIN; 150 mV/100 k ohms DIN; 150 mV/100 k ohms Phono (RIAA equalization) 30 to 15,000 Hz +-1 dB BASS: 9 dB at 100 Hz, TREBLE: 7 dB at 10 kHz +10 dB at 100 Hz, +5 dB a

6、t 10 kHz (Volume Control set at -30 dB position) FILTER HIGH: -6 dB at 10 kHz, LOW: -6 dB at 50 Hz 3. Others SEMICONDUCTORSTransistors: 18, Diodes: 5, IC: 1 POWER REQUIREMENTSU.S.A. and Canada model: 120V, 60 Hz CEE models: 220V, 50 Hz Other models: 110/220/240V, 50/60 Hz switchable DIMENSIONS380(W)

7、 x 125(H) x 263(D) mm (15x4.9x 10.3) inches WEIGHT5.5 kg (12.1 IDS.) NOTE: For improvement purposes, specifications and design are subject to change without notice. II. DISMANTLING OF UNIT In case of trouble, etc. necessitating disassembly, please disassemble in the order shown in photograph. Reasse

8、mble in reverse order. 1 SCREWS SCREWS CABINET SCREWS SCREWS ADJUSTMENT t A cL) SCREWS 6 5 2 7 BOTTOM PLATE 3 4 FRONT PANEL micro VII. CLASSIFICATION OF VARIOUS P. C BOARDS 1. RELATION OF P.C BOARD TITLE AND IDENTIFICATION NUMBER P.C Board Number of P.C Board Main Amp P.C Board MFC P.C Board LED P.C

9、 Board VR P.C Board Headphone P.C Board M2-5018/A M2-5019 M2-5019A M2-5019B M2-5019C Tone Control P.C Board M2-5022 2. COMPOSITION OF VARIOUS P.C BOARD 1) MAIN AMP P.C BOARD M2-5018/A, LED P.C BOARD M2-5019A 3) VR P.C BOARD M2-5019B WHT/CROSS BLK M2-50.9 M2-5022 4) HEADPHONE P.C BOARDM2-5019C ISPBl

10、5) TONE CONTROL P.C BOARD M2-5022 WHT/LONG BLU BALANCELOUDNESSVOLUME 2) MFC P.C BOARD M2-5019 TAPE MONITOR R O M SECTION 2 TABLE OF CONTENTS 1. RECOMENDED SPARE PARTS LIST . .17 2. MAIN AMP P.C BOARD (M2-5018) BLOCK. 18 3. MFC P.C BOARD (M2-5019) BLOCK . . 18 4. VOL P.C BOARD (M2-5019B) BLOCK. .18 5

11、. HEADPHONE P.C BOARD (M2-5019C) BLOCK.18 6. TONE CONTROL P.C BOARD (M2-5022) BLOCK .18 7. ASSEMBLY BLOC.19 8. FINAL ASSEMBLY BLOCK. . 21 9. LIST OF JNTERCHANGEABLE SEMICONDUCTORS . 22 INDEX . 23 Resistor and Capacitor which is not listed in this parts list, please refer to COMMON LIST FOR SERVICE P

12、ARTS. PARTS LIST R O M HOW TO USE THIS PARTS LIST 1. This parts list is compiled by various individual blocks based on assembly process. 2. When ordering parts, please describe parts number, serial number, and model number in detail. 3. How to read list. The reference number corresponds with illustr

13、ation or photo number of that particular parts list. This number corresponds with the Figure Number. This number corresponds with the individual parts index number in that figure. A small x indicates the inability to show that particular part in the Photo or Illustration. Schematic Diagram Number of

14、 individual manufactured part. (not required for parts order) Quantity of particular part required. 12-115x Ref. No. Parts No. Description Schematic No Qty FLYWHEEL BLOCK #13 12-ll5x 800425 Flywheel Block Assy. Comp. RDG#13 12-116 244506 Flywheel Only RD 233 12-117x 244754 Felt, Flywheel RD275 12-11

15、8 251324 Main Metal Case RD 236 12-119 253080 Main Metal RD237 4. The symbol numbers shown on the P.C. Board list can be matched with the Composite Views of components of the Schematic Diagram or Service Manual. 5. The indications of Resistors and Capacitors in the photos of P.C. Board are being eli

16、minated. 6. The shape of the parts and parts name, etc. can be confirmed by comparing them with the parts shown on the Electrical Parts Table of P.C. Board. 7. Both the kind of part and installation position can be determined by the Parts Number. To determine where a parts number is listed, utilize

17、Parts Index at end of Parts List. It is necessary first of all to find the Parts Number. This can be accomplished by using the Reference Number listed at right of parts number in the Parts Index, (meaning of ref. no. outlined in Item 3 above). 8. Utilize separate Price List for Parts to determine un

18、it price. The most simple method of finding parts Price is to utilize the reference number. CAUTION: 1. When placing an order for parts, be sure to list the parts no. model no., and description. There are instances in which if any of this information is omitted, parts cannot be shipped or the wrong

19、parts will be delivered. 2. Please be careful not to make a mistake in the parts no. If the parts no. is in error, a part dif- ferent from the one ordered may be delivered. R O M 1. RECOMMENDED SPARE PARTS LIST Parts No. BA211263 BA211252 BA211274 BA211285 BA211432 BC224807 BD211230 BT225178 Parts N

20、omenclature Multi Function P.C Board Comp. M2?5019 Main Amp P.C Board Comp. M2?5018 Volume P.C Board Comp. M2?5019B Headphone P.C Board Comp. M2?5019C Tone Control P.C Board Comp. M2?5022 Cabinet A M2?5013 Front Panel Block Comp. AM?2200(U) Power Transformer AM?2200T?1 BT2 15043 Power Transformer AM

21、?2200T?2 BT215054 Power Transformer AM?2200T?3 BT239591 ED656357 Reference No. CSA CEE Power Transformer AM?2200T?4 BEAB Luminous Diode SEL105R ED551733 Silicon Varistor STV?4H ED656278 ED219903 EI697871 Silicon Diode 1S2472VE Silicon Diode GP15D IC LA3122 EJ650272 Pin Jack 14P JPJ379?1?1 EJ698051 D

22、in Jack Jl (Multi Function P.C Board) J2 (Multi Function P.C Board) EJ225022 EJ240581 E0650823 ES225055 Headphone Jack LJ255?1?12 Jl (Headphone P.C Board) Push Terminal 4P Phase Equalizer Coil 2.2H Rotary Switch SR26N C30K ES225088 Push Switch 2F?0005FF3220 ES224965 Push Switch 1FT?0004AF4920 ES2250

23、44 Push Switch 2F?0002FF1620 ES219846 Push Switch 3FT?0001FF6820 ES224436 Power Switch JP01 ES239218 ES242346 ET219870 Power Switch JP01 (TV?4) Power Switch JP? 17 Transsistor 2SD586 (Q)(R) L1 (Main Amp P.C Board) SW1 (Multi Function P.C Board) SW2 (Multi Function P.C Board) SW1 (Volume P.C Board) S

24、W1 (Headphone P.C Board) SW1 (Power Switch) CSA CEE ET2 19881 Transistor 2SB616 (Q)(R) ET223446 Transistor 2SC1571NP (G)(H) ET219868 ET219857 ET539987 Transistor 2SB560 (E)(F) Transistor 2SD438 (E)(F) Transistor 2SC1312R (F)(G) EV573366 Semi?fixed Volume V10K8?4?2 200 ohmsB EV224943 EV224954 EV21983

25、5 SK224886 SK646817 SK634410 SK225090 SP224662 SZ645243 Single axial 2?throw Volume V24L5G 3BM 250kx2 Single axial 2?throw Volume V16L4G 31Z 250kx2 Single axial 2?throw Volume V16L4 I5A 100kx2 Power Knob M2?5021 Single Knob AA?5250 Push Button Knob J 91?5051 Volume Knob M2?5015 Rear PanelA M2?5010 C

26、ircular Foot A CA?6014 VR1 (Main Amp P.C Board) VR1 (Volume P.C Board) VR2 (Volume P.C Board) VR1 ,2 (Tone Control P.C Board) R O M 2. MAIN AMP P.C BOARD (M2?5018) BLOCK Symbol Parts No. No. 2?1 BA211252 2?2 BA270764 2?3 BA27077S 2?TR1.2 ET245790 2?TR3 ET219868 2?TR4 ET219857 2?TRS ET219868 2?TR6 ET

27、219857 2?TR7 ET219868 2?D1 ED656278 2?D2 to 5 ED219903 2?VR1 EV245823 2?L1 E0650823 2?4 EA233932 2?5 EA233943 2?6 EJ514822 2?7 EJ592503 2?R18.19 ER219914 2?C10 EC557155 2?C13 EC474671 Description Qty Main Amp P.C Board Comp. (M2?5018) 1 Main Amp P.C Board Comp. (M2?S018XCEE) 1 Main Amp P.C Board Com

28、p. (MS?S018)(CSA) 1 Transistor 2SC1570NP (G)(H) 4 Transistor 2SB560 (E)(F) 2 Transistor 2SD438 (E)(F) 1 Transistor 2SB560 (E)(F) 1 Transistor 2SD438 (E)(F) 2 Transistor 2SB560 (E)(F) 2 Silicon Diode 1S2472 1 Silicon Diode GP15D 4 Semi?fixed/Vol. V10K8?1?2 200 ohmsB 2 Phase Equalizer Coil 2.2 H(K) 2

29、Transistor P.C Board (M2?5018A) 1 Transistor P.C Board A (M2?5018A)(CSA) 1 Fuse Holder, P.C Board S?N5051 8 Fuse Clip, P.C Board H0426 (CEE) 8 Metal Oxide Film/R. 2W 0.47 ohms (K) 4 Solid Aluminum/C. 1F(M) 10WV(Vert. Type) 2 FM/C. 10PF(K) 500WV 2 3. MFC P.C BOARD (M2?5019) BLOCK Symbol No. Parts No.

30、 3?1 BA211263 3?IC1 E1697871 3?SW2 ES225088 3?J1 EJ650272 3?J2 EJ698051 Description Qty Multi Function P.C Board Comp. (M2?5019) 1 1C LA?3122 1 Push SW. 2F?0005FF3220 1 Pin Jack 14P JPJ379?1?1 1 Din Jack 1 4. VOL P.C BOARD (M2?5019B) BLOCK Symbol Parts No. No. 4?1 BA211274 4?TR1 ETS39987 4?VR1 EV224

31、943 4?VR2 EV224954 4?SW1 ES224965 4?C4 EC5S7155 4?C7 EC223413 Description Qty Vol P.C Board Comp. (M2?S019B) 1 Transistor 2SC1312R(F)(G) 2 Single axial 2 throw Vol. V24L5G 3BM 250kx2 1 Single axial 2 throw Vol. V16L4G 31Z 250kx2 1 Push SW. 1FT?0004AF4920 1 Solid Aluminum/C. 1F(M) 10WV (Vert. Type) 2

32、 Solid Aluminum/C. 1F(M) 16WV (Vert. Type) 2 5. HEADPHONE P.C BOARD (M2?5019C) BLOCK Symbol No. 5?1 Parts No.Description Qty BA21128S Headphone P.C Board Comp. (M2?S019C) 1 S?J1 EJ225022 Headphone Jack 1 S?SW1 ES22S044 Push SW. 2F?0002FF1620 1 5?R1.2 ER409814 Metal Oxide Film/R. 2W 220 ohms (K) 2 6.

33、 TONE CONTROL P.C BOARD (M2?5022) BLOCK Symbol No. 6?1 Parts No.Description Qty BA211432 Tone Control P.C Board Comp. (M2?5022) 1 6?VR1.2 EV219835 Single axial 2 throw Vol. V16L4 20A 100kx2 2 6?SWl ES219846 Push SW. 3FT?0001FF6820 1 6?C4 EC219813 Solid Aluminum/C. 0.1 F(M) 10WV (Vert. Type) 2 R O M

34、7.) ASSEMBLY BLOCK Ref. No. 7?1 7?2x 7?3x 7?4x 7?Sx 7?6x 7?7x Parts No. HEAT?SINK BZ211241 ET219870 ET219881 ZS379350 ED551733 ZS608332 ZS447840 Description Schematic Qty: No. BLOCK Heat?sink Block Comp. Transistor 2SD586 (Q)(R) Transistor 2SB616 (Q)(R) Screw, pan head 3x6 Varistor STV?4H Screw, pan

35、 head 3x8, w/washer Tapping Screw #2 3x8(BR) 45?1?236 45?1?237 45?10?10 1 2 2 8 2 2 4 REAR PANEL BLOCK 7?8 7?9x 7?10 x 7?11 7?12 7?1 3x 7?14 7?15 7?16 7?17 7?18 7?19 7?20 x 7?2 lx 7?22 7?2 3x 7?24x 7?2 5 x 7?2 6x 7?27 7?28x 7?29 7?30 x 7?31 7?32 7?33x 7?34x 7?3 5 x 7?36x 7?37x 7?38 7?39 7?40 7?41 x

36、7?42 x 7?43x 7?44x 7?45 x 7?46x 7?47x 7?48x 7?49 X 7?5 Ox 7?5 lx 7?5 2 X 7?53x 7?54x EZ224662 EZ224706 EZ224717 EZ225145 EW540123 EW604S85 EZ631945 SK652397 ZW652408 EJ240581 ZS52286S ASSEMBLY ZS32S495 ZS379350 ZW273802 ES224436 ES242346 ES239218 EC684720 ECS65896 ZW698308 ZW239578 ZS447761 EJ214975

37、 ES225055 BT225178 BT215054 BT2 15043 ZW273914 ZW413188 EJ551035 EA224515 ED656357 SP224831 ZS447840 EF277413 EF607550 EF332098 EF690996 EF552846 EF623103 EF563703 TA239567 EJ239580 EJ239477 ZW273881 ZW273892 ZW413188 Rear Panel A Rear Panel B (CSA) Rear Panel C (CEE) 2 throw AC Outlet AC Cord (CUL)

38、 2.5M AC Cord BSI Strain Relief SR?4N?4 Knob OS 12?2 Washer (SPC) D3.2xlOxO.5t 4P Push Terminal Tapping Screw #2 3xl2(BR) BLOCK Tapping Screw #2 3x6 (BR) Screw, pan head 3x6 Toothed Lock Washer M3 Push SW, JP01 Push SW. JP17 (CEE) Push SW. JP01(TV?4) (CSA) Ceramic/C. CLD16YE 0.01F(P) 500WV Ceramic/C

39、. DP6600YM 0.01F(P) 1.4 kWV (CSA) Nylon Rivet (FNPR) 3x5.5 (Black) Nylon Rivet (FNPR) 4x5 (Black) (CEE, CSA) Tapping Screw #2 3x6 (BR) (Black) 3P Fuse Holder (Large) B (Lupping Type) Rotary SW. SR26N C30K Power Trans. AM?2200T?1 Power Trans. AM?2200T?3 (CEE) Power Trans. AM?2200T?2 (CSA) Spring Wash

40、er M4 Nut M4, #1 Wrapping Terminal, 4P T?S251 LED P.C Board LED SEL?105R Bottom Plate A Tapping Screw #2 3x8 (BR) Fuse ST?2 2A Fuse (SEMKO T Type) 1.2SAT 250V (CEE) Fuse ST?1 2A (CSA) Fuse (SEMKO T Type) 4AT (CEE) Fuse ST?1 4A (CSA) Fuse (SEMKO T Type) 1AT (CEE) Fuse 2A250V Wire Band Plate (CEE.CSA)

41、 Fuse Holder, w/sticker AM?2S (CEE) Fuse Holder, w/sticker AM?2L(CSA) Earth Lug M4 (CEE) Toothed Lock Washer M4 (CEE) Nut M4 #l(CEE) M2?5010 M2?5010 M2?5010 31?1?166 26?3?20 26?3?37 2?7?49 34?1?4 32?1?72 25?5?221 25?5?224 25?5?222 24?5?61 24?5?58 2?7?54 2?7?58 40?1?104 25?6?95 38?4?433 38?4?447 38?4

42、?446 32?1?36 M2?5019A 45?15?11 M2?5014 39?1?26 39?1?53 39?1?25 39?1?53 39?1?25 39?1?53 39?1?50 M2?5024 40?1?141 40?1?119 1 1 1 1 1 1 1 1 1 2 4 9 11 1 1 1 1 1 1 4 1 1 1 1 1 1 1 4 4 2 1 1 1 5 4 1 1 2 2 4 1 1 1 1 1 1 Symbol No Parts No. Description 7?S6x MZ229138 Wire Bundle Holder N?108 (CEE, CSA) 2?3

43、5?1 2 7?S7x ZS447840 Tapping Screw #2 3x8 (BR) (CEE, CSA) 1 Schemati When ordering parts,please describe Parts Number, Descriptor, and Model Number in detail 8. PHOTO OF FINAL ASSEMBLY BLOCK 8.) FINAL ASSEMBLY BLOCK Ref. No. Parts No.Description FRONT PANEL BLOCK 8-lx BD211230 Front Panel Block Comp

44、. 8-2 MZ224627 Push Button Bush A 8-3 SE613888 Button Escutcheon A Schematic Qty No. M2-5004 1 CW-6021 8 ASSEMBLY BLOCK 8-4x SZ64S243 Circular Foot A CA-6014 4 8-5x ZS214997 Tapping Screw, #2 4x6 pan 4 8-6 BC224807 Cabinet A M2-5013 1 8-7x BC266782 Cabinet C (CSA) M2-50I3 1 8-8 ZW548010 Spot Facing

45、Washer MU-6028 4 8-9 ZS510344 Screw, binding head 4x12 4 8-10 SK224886 Power Knob M2-5021 1 8-11 SK634410 Push Button Knob J 91-5051 8 8-12 SK22S090 Vol. Knob M2-5015 1 8-13 SK646817 Single Knob AA-5250 4 R O M 9. LIST OF INTERCHANGEABLE SEMICONDUCTORS As far as service is concerned, in case the ori

46、ginal parts cannot be obtained, the interchangeable parts listed below can be substituted. Original Parts Description 2SB560(E)(F) 2SB616(Q)(R) 2SC1312(F)(G) 2SC1517NP(G)(H) 2SD438(E)(F) 2SD586(Q)(R) LA3122 1S2472VE GP15D SEL105R STV-4H Parts No. ET2 19868 ET2 19881 ET539987 ET223446 ET2 19857 ET2 1

47、9870 EI697871 ED656278 ED2 19903 ED656357 ED551733 Utilizing P.C Board M2-5018 M2-8018A M2-5019B M2-5018 M2-5018 M2-5018A M2-5019 M2-5018 M2-5018 M2-5019A Interchangeable Parts Description 2SA815(O)(Y) 2SC1571NP(G)(H) 2SC1312(F)(G) 2SC1625(O)(Y) Parte No. ET649078 j ET223446 ET539987 ET649067 1S2472

48、 ED656278 1R5BZ61 ED650621 R O M INDEX Ref. No. & Parts No. Symbol No. BA211252 2-1 BA211263 3-1 BA211274 4-1 BA211285 5-1 BA211432 6-1 BA270764 2-2 BA27077S 2-3 BC224807 8-6 BC266782 8-7x BD211230 8-lx BT215043 7-34x BT21S054 7-33x BT225178 7-32 BZ211241 7-1 EA224515 7-38 EA233932 2-4 EA233943 2-5 Ref. No. & Parts No. Symbol No. SK224886 8-10 SK225090 8-12 SK634410 8-11 SK646817 8-13 SK652397 7-15 SP224831 7-40 SZ645243 8-4x TA239567 7-49x ZS214997 8-5x ZS32549S 7-19 ZS379350 7-4x ZS37935