HarmanKardon-HD980.230-cd-sm维修电路原理图.pdf

《HarmanKardon-HD980.230-cd-sm维修电路原理图.pdf》由会员分享，可在线阅读，更多相关《HarmanKardon-HD980.230-cd-sm维修电路原理图.pdf（47页珍藏版）》请在收音机爱好者资料库上搜索。

1、HD 980/230 CD Player Released EU2009 Harman International Rev1, 05/2012 8500 Balboa Boulevard Northridge, California 91329 SEMICONDUCTOR PINOUTS 16 PCB DRAWINGS 30 BLOCK DIAGRAM 35 VERSION HISTORY 36 SCHEMATIC DIAGRAMS 37 SERVICE BULLETIN, RATTLE NOISE 47 BASIC SPECIFICATIONS 2 TROUBLESHOOTING GUIDE

2、 3 PACKAGE LIST AND PARTS 4 EXPLODED VIEW 5 PARTS LIST 6 CONTENTS RadioFans.CN Signal Format Sampling Frequency32 kHz to 96 kHz D/A ConversionMultibit Sigma-Delta modulator Oversampling24-bit/176.4 kHz Sample Rate Convertor or 24-bit/96 kHz with HRS-Link, internal DAC. Discrete Analog Output Section

3、 Error CorrectionCIRC System Frequency Response20 Hz 20 kHz +0/-0.5 dB Total Harmonic Distortion (THD) 100 dB Signal-to-Noise Ratio 110 dB Channel Separation 100 dB Line-Output Level2.0 V General Power Requirement100-240 V 50/60 Hz Power Consumption20 Watts (On) 2 Watts (Standby) Dimensions Height63

4、mm Width440mm Depth332mm Weight3.8 kg Depth measurement includes knobs, buttons and connection jacks. Height measurement includes feet and chassis. All features and specifications are subject to change without notice. Harman Kardon is a registered trademark of Harman International Industries, Incorp

5、orated. Technical Specifications 250 Crossways Park Drive, Woodbury, New York 11797 Harman Consumer Group, Inc.: 2, route de Tours, 72500 Chteau-du-Loir, France 2008 Harman Kardon, Incorporated Part 01.00.YS.SM1.E1798 RadioFans.CN Troubleshooting Guide ENGLISH TROUBLE SHOOTING GUIDE SYMPTOM No light

6、s on Front Panel Remote does not appear to operate Front panel lights, but CD does not play Play indicator lights, but no sound is heard Sound skips or stutters during play Sound is continually distorted ERRORlights up continuously in the display CAUSE No AC power Power Switch turned off Weak batter

7、ies Blocked sensor Disc upside down Poor connections Wrong source connected Disc may be damaged Surface vibrations Incorrect input Various SOLUTION Make certain AC power cord is plugged into a live outlet. Turn on Power Switch. Install fresh batteries, observing polarity indications. Remove obstruct

8、ions from the front panel sensor or connect a remote sensor to the Remote Injack on the rear panel. Reload disc with label side facing up. Make certain connections are secure and made to the correct (e.g., CD) input. Select CD source on receiver or preamp. Try another disc. Isolate the unit from vib

9、ration by placing it on a firm surface or move it further away from speakers. Make certain that the analog Audio Outputsof the CD player are connected to a line level audio input, NOT to a digital audio or phono input. Turn the unit off and on again. If the problem persists, turn the AC power to the

10、 CD player off and on. RadioFans.CN harman/kardonHD 980/230 Service Manual Page 4 of 46 harman/kardonHD 980/230 Service Manual Page 5 of 46 HD980 Component List Serial No.: WA0034-0100103440 01.00.SJ.HD980E003plastic partHD980-Front panelHD980-RE01 01.00.SJ.HD980E004plastic partHD980-Button IHD980-R

11、E02 01.00.SJ.HD980E005plastic partHD980-Button IIHD980-RE03 01.00.SJ.HD980E006plastic part HD980-Pedestal underlay HD980-RE04 01.00.SJ.HD980E007plastic partHD980-LensHD980-RE05 01.00.SJ.HD980E008VFD filterHD980-VFD filterHD980-RE06 01.00.SJ.HD980E009plastic partHD980-Disc tray door HD980-RE07 01.00.

12、SJ.HD980E010plastic part HD980-Power indicator lampshade HD980-RE08 01.00.SJ.SK.E008plastic part 1000A-IR receiver support 5.5mm 0100WJTJHD980E001Metals PartHD980-ChassisHD980-PT01 0100WJTJHD980E002Metals PartHD980-Rear panelHD980-PT02 0100WJTJHD980E003Metals PartHD980-Top coverHD980-PT03 0100WJTJHD

13、980E004Metals Part HD980-Front panel bracket HD980-PT04 0100WJTJHD980E005Metals Part HD980-Aluminum veneer HD980-PT05 0100WJTJHD980E006Metals Part HD980-Aluminum ally wrap for disc tray HD980-PT06 01.00.WJ.TJ.E569aluminium fastener3.5*40 01.47.CNT.LJX7E768Connect cable 2.54-3Y-3Y-220mm (Be different

14、 side) Connect Key board and SMPS board 01.47.CNT.ACX.E036Connect cable Power cord with 300mm fixture (EU version) Connect SMPS board and Rear panel 01.47.CNT.LJX3E037Connect cable 2.0-6Y-6Y-130mm (Be different side) (UL20080 28AWG) Connect Loader and Main board 01.47.CNT.LJX3E036Connect cable 2.0-5

15、Y-5Y-240mm (Be same side) (LG UL20080 28AWG) Connect Loader and Main board 01.47.CNT.LJX7E612Connect cable 2.54-2.0-13Y- 240mm(Be same side) Connect SMPS board and Main board 01.47.CNT.LJX5E333Connect cable 70mm(solder one end and grounding piece another end) Connect Key board and SMPS board 01.47.C

16、NT.LJX5E334Connect cable 80mm(solder one end and grounding piece another end) Connect VFD board and Main board 01.47.CNT.LJX2E110Connect cable 1.25-6Y-6Y- 180mm(Be same side) Connect Key board and VFD board 01.48.BPX.1.E189flat cable 1.25*14P*100mmA(4/ 8) Connect Main board and VFD board 01.48.BPX.1

17、.E045flat cable0.5*24P*180mmA Connect Loarder and Main board 01.47.CNT.CTX.E027 Remot control transmission cable 3.5+3.5(single channel), black, 1.2m 01.15.JX.EDV34850LoaderDV34-850 SF-HD850G+DVD- M06B harman/kardonHD 980/230 Service Manual Page 6 of 46 Part numberDescriptionSpecificationLocation.No

18、.Note 01.00.FZ.QT.E409PC pieceHD980-H05 Between Lens and Front panel 02.11HCD08M5563C01 Main Board (semi- manufactured goods) HCD08M-5563C012-layers 02.15HCD08K5575C01 Key Board (semi- manufactured goods) HCD08K-5575C012-layers 02.15HCD08K5576C01 VFD Board (semi- manufactured goods) HCD08K-5576C012-

19、layers 02.19HCD06P1254C01 SMPS Board (semi- manufactured goods) HCD06P-1254C011-layer 02.25.HD980 Remote Control(manufactured goods) HD980 HD980 Component List for Main Board (5563C01) 01.57.R.3.E000JResistor, chip0805-0 5% R8 R9 R14 R26 R54 R57 R60 R64 R71 R74 R79 R80 R85 R186 01.57.R.3.E1R0JResist

20、or, chip0805-15%R67 R68 R69 R70 01.57.R.3.E220JResistor, chip0805-225%R27 R29 R121 01.57.R.3.E330JResistor, chip0805-335%R20 R114 R129 R130 01.57.R.3.E470JResistor, chip0805-475% R103 R104 R105 R107 R110 R111 01.57.R.3.E101JResistor, chip0805-1005% R46 R47 R81 R84 R93 R94 R95 R123 R125 01.57.R.3.E24

21、1JResistor, chip0805-2405%R43 R44 R96 R122 01.57.R.3.E271JResistor, chip0805-2705%R137 01.57.R.3.E391JResistor, chip0805-3905%R142 R97 01.57.R.3.E561JResistor, chip0805-5605%R33 R49 R50 01.57.R.3.E102JResistor, chip0805-1K5%R12 R32 R112 R113 01.57.R.3.E152JResistor, chip0805-1.5K5%R52 R41 01.57.R.3.

22、E202JResistor, chip0805-2K5%R21 R19 01.57.R.3.E222JResistor, chip0805-2.2K5%R62 R56 R58 R88 01.57.R.3.E472JResistor, chip0805-4.7K5% R17 R37 R42 R53 R115 R138 R145 01.57.R.3.E512JResistor, chip0805-5.1K5%R65 01.57.R.3.E622FResistor, chip0805-6.2K1%R22 01.57.R.3.E822FResistor, chip0805-8.2K1%R66 R63

23、01.57.R.3.E103JResistor, chip0805-10K5% (R5) R11 R15 (R16) R18 R34 R35 R36 R38 R39 R48 R72 R75 R77 R83 R86 R87 (R92) R108 R109 R116 R117 R118 R119 R120 R124 R140 R181 R182 R183 R185 01.57.R.3.E1182FResistor, chip0805-11.8K1%R30 R28 01.57.R.3.E223JResistor, chip0805-22K5%R45 R55 R177 R180 01.57.R.3.E

24、333JResistor, chip0805-33K5%R23 R24 01.57.R.3.E473JResistor, chip0805-47K5%R59 R61 R184 01.57.R.3.E104JResistor, chip0805-100K5%R73 R76 R78 R82 01.57.R.3.E105JResistor, chip0805-1M5%R51 R40 01.57.R.4.E101FResistor, chip1206-1001%R154 R155 R170 R171 01.57.R.4.E331FResistor, chip1206-3301% R147 R148 R

25、152 R157 R161 R162 R163 R164 R168 R173 R178 R179 01.57.R.4.E681FResistor, chip1206-6801%R150 R160 R166 R176 01.57.R.4.E202FResistor, chip1206-2K1%R153 R156 R169 R172 harman/kardonHD 980/230 Service Manual Page 7 of 46 HD980 Component List for Main Board (5563C01) P/NDescriptionSpecificationLocation.

26、No.Note 01.57.R.4.E272FResistor, chip1206-2.7K1%R151 R159 R167 R175 01.57.R.4.E153FResistor, chip1206-15K1% R89 R90 R91 R149 R165 01.57.R.4.E473FResistor, chip1206-47K1%R174 R158 01.57.R.4.E475JResistor, chip1206-4.7M5%R141 01.57.R.8.EP3304 Resistor, thick film chip network 0603-33*4 5% RN1 RN2 RN3

27、RN4 RN5 RN6 RN7 01.54.CS.3E100N50V Capacitor, multilayer ceramic, chip 0805-10P NPO5%/50V C85 C86 C87 C89 01.54.CS.3E150N50V Capacitor, multilayer ceramic, chip 0805-15P NPO5%/50V C26 C34 01.54.CS.3E220N50V Capacitor, multilayer ceramic, chip 0805-22P NPO5%/50V C113 C104 01.54.CS.3E470N50V Capacitor

28、, multilayer ceramic, chip 0805-47P NPO5%/50V C20 01.54.CS.3E101N50V Capacitor, multilayer ceramic, chip 0805-100P NPO5%/50V C67 C69 01.54.CS.3E121N50V Capacitor, multilayer ceramic, chip 0805-120P NPO5%/50V C15 01.54.CS.3E201N50V Capacitor, multilayer ceramic, chip 0805-200P NPO5%/50V C21 01.54.CS.

29、3E391N50V Capacitor, multilayer ceramic, chip 0805-390P NPO5%/50V C63 C62 01.54.CS.3E471N50V Capacitor, multilayer ceramic, chip 0805-470P NPO5%/50V C66 C65 01.54.CS.3E681N50V Capacitor, multilayer ceramic, chip 0805-680P NPO5%/50V C71 01.54.CS.3E102X50V Capacitor, multilayer ceramic, chip 0805-102

30、X7R 10%/50V C23 C13 01.54.CS.3E332X50V Capacitor, multilayer ceramic, chip 0805-332 X7R10%/50V C16 C17 (C24) 01.54.CS.3E392X50V Capacitor, multilayer ceramic, chip 0805-392 X7R10%/50V C22 01.54.CS.3E103X50V Capacitor, multilayer ceramic, chip 0805-103 X7R10%/50V C14 C73 C74 C80 01.54.CS.3E273Y50V Ca

31、pacitor, multilayer ceramic, chip 0805-273 Y5V- 20+80%/50V C19 01.54.CS.3E473X50V Capacitor, multilayer ceramic, chip 0805-473 X7R10%/50V C68 01.54.CS.3E104Y50V Capacitor, multilayer ceramic, chip 0805-104 Y5V+80- 20%/50V (C1) (C2) (C3) (C4) (C5) (C6) (C7) C8 (C9) (C10) C11 C12 C18 (C25) C27 C28 C30

32、 C35 C38 C39 C40 C41 C42 C43 C44 C45 (C46) (C47) (C48) (C49) C50 C51 (C52) (C53) (C54) (C55) C56 C57 C58 C59 C60 C61 C64 C70 C72 (C76) C77 C79 C81 C82 (C83) C84 C90 C91 C92 C93 C107 C108 C109 C110 C111 C115 C116 C117 01.54.CS.3E105Y16V Capacitor, multilayer ceramic, chip 0805-105 Y5V- 20+80%/16V C32

33、 C33 C36 C37 C78 01.54.CS.3E475Y16V Capacitor, multilayer ceramic, chip 0805-475 Y5V+80- 20%/16V C29 C31 harman/kardonHD 980/230 Service Manual Page 8 of 46 HD980 Component List for Main Board (5563C01) P/NDescriptionSpecificationLocation.No.Note 01.54.CS.4E681N50V Capacitor, multilayer ceramic, chi

34、p 1206-680P NPO5%/50V C102 C103 C112 C114 01.54.CS.4E222X50V Capacitor, multilayer ceramic, chip 1206-222 X7R10%/50V C105 C106 01.34.CL.DE10U16VC Capacitor, AL.electrolytic CD110-10UF/16V 5*11 CE1 01.34.CLDE47U25VC1 Capacitor, AL.electrolytic CD110-47UF/25V 5*11 CE16 CE17 CE18 CE19 CE20 CE34 CE36 CE

35、37 CE38 CE43 CE45 CE49 01.34.CLDE47U50VCD Capacitor, AL.electrolytic CD110-47UF/50V 6.3*12 CE23 CE24 CE25 CE26 CE27 CE28 CE29 CE30 CE31 CE32 CE33 01.34.CLDE100U10VD Capacitor, AL.electrolytic CD110-100UF/10V 5*12 CE3 CE4 CE5 CE6 CE7 CE8 CE10 CE11 CE13 CE14 CE21 CE22 CE39 CE40 CE41 CE42 CE44 CE46 CE4

36、7 CE48 CE50 CE51 CE52 CE53 CE54 CE55 CE56 CE57 01.34.CLDE220U10VD Capacitor, AL.electrolytic CD110-220UF/10V 5*12 CE2 CE9 CE12 CE15 01.13.L.L.S.E007 Inductor, multilayer ceramic, chip 0805-10UH SMDL1 L2 01.13.L.L.S.E362Inductor,WeifengdaWBR453232-220K-R L3 01.13.L.L.D.E081InductorWB1010-1T1DIP6 Coil

37、craft 01.13.L.Z.ESC100Bead, chip,1206-100 FB1 FB2 FB3 FB4 FB5 FB6 FB7 FB8 FB9 FB10 FB11 01.41.D.PS.ELL4148DiodeLL4148 SMD D1 D3 D4 D5 D6 D7 D8 D9 D10 D11 D12 D13 D14 DO-213AA 01.41.D.PSE30BQ040Diode30BQ040 SMDD2 SMC Schottky diode 3A International Rectifier 01.41.D.WS.E6V2Zener diodeZENER 6.2V 0.4WD

38、Z1 01.42.Q.S.E123MOSFET,DIODESBSS123 SMDMQ31SOT-23 01.42.Q.S.E1035Transistor,Panasonic2SA1035 SMD Q11 Q12 Q13 Q15 Q18 Q21 Q22 Q24 Q27 Q30 Q32 SOT-23 01.42.Q.S.EDTC343Transistor,ROHM DTC343TKT146 SMD Q17 Q26SOT-23 01.42.Q.S.E2406Transistor,Panasonic2SC2406 SMD Q14 Q16 Q19 Q20 Q23 Q25 Q28 Q29 SOT-23 0

39、1.42.Q.S.E1132Transistor,ROHM2SB1132 SMDQ1 Q2MPT3 01.42.Q.S.E1664TTransistor,ROHM 2SD1664T100R SMD Q10 Q8MPT3 01.42.Q.S.E3018MOSFET,ROHM2SK3018T106 SMDMQ9 MQ7UMT3 01.42.Q.D.E8050TransistorKTC8050-C/P DIPQ6 Q5TO-92 01.42.Q.D.E8550TransistorKTC8550-C/P DIPQ3 Q4TO-92 01.00.JZ.E33868Quartyz Crystal Unit

40、 33.8688MHZ-49S- 20P X1 01.00.JZ.E225792Crystal Oscillator22.5792MHz/3.3VY1 harman/kardonHD 980/230 Service Manual Page 9 of 46 HD980 Component List for Main Board (5563C01) P/NDescriptionSpecificationLocation.No.Note 01.44.IC.S.EBF532SIC, ADI, Blackin DSP ADSP- BF532SBSTZ400,LQ FP176 U6 01.46.IC.E7

41、208GIC, Via, Servo chipVT7208, LQFP216U1 01.46.ICEKH29LV040IC, KH,Flash Memory KH29LV040CQC- 70G, PLCC32 U16 firmware burn-in; (Can be replaced by ATEML AT49BV040B- 70JU) 01.46.IC.E290011 IC, AMIC, Flash memory AMIC A290011TL-70, PLCC32 U2firmware burn-in 0146ICHY57V641620EIC, Hynix, SDRAM HY57V6416

42、20ETP- 7,TSOP54 U30 0146ICEM11B416256IC, EliteMT, DRAM M11B416256A- 25J,SOJ40 U3 01.44.IC.S.E5888 IC, Rohm, Actuator driver BA5888FP, HSOP-28 U12 01.46.IC.E7414 IC, Philips, Hex inverting Schmitt trigger 74HCT14D,SOIC14U31; 01.46.IC.E74HCT245IC,TI,TTL input buffer SN74HCT245PWR,T SSOP20 U14 01.44.IC

43、.D.EPC817C IC,Sharp, Photoelectric Coupler PC817,DIP4 U23 01.44.IC.S.E1117HIC, AAC, LDO AZ1117H-5.0, SOT- 223 U29 01.44.IC.S.E1117IC, AAC, LDO AZ1117H-ADJ, SOT- 223 U7 U9 01.44.ICSEA11173V3IC, AAC, LDO AZ1117H-3.3, SOT- 223 U4 01.44.IC.S.ELM393IC, ST, ComparatorLM393, SOP8U11 01.44.IC.D.E7912 IC, Fa

44、irchild, Voltage Regulator L7912,TO-220U10 01.44.IC.D.E7812 IC, Fairchild, Voltage Regulator L7812,TO-220U8 01.46.IC.NJM5534 IC, JRC, Operational amplifier NJM5534M,DMP8U26 U28 01.44.IC.S.E8740 IC, Wolfsonw, DA converter WM8740SEDS, SSOP-28 U27 01.44.IC.S.E9022 IC, NS, Vacuum Fluorescent Display Fil

45、ament Driver LM9022, 8P, SO8U13 01.44.IC.S.E3522 IC, AAT, Reset monitor AAT3522IGY-3.08- 200-T1, SOT-23 U5 01.43.E009 Jack,Sharp,Fiber optic ouput jack with shutter GP1FAV51TK0FJP1 01.40.CON.DCZ.E121Jack, IR in/out jack SCJ351P00XS0B00 (BLACK), In-line Package JP4 01.40.CON.DCZ.E125 Jack, Coaxial ou

46、tput jack AV1-8.4-6GJP2 Antiflaming,Oran ge, Gold-plated jack harman/kardonHD 980/230 Service Manual Page 10 of 46 HD980 Component List for Main Board (5563C01) P/NDescriptionSpecificationLocation.No.Note 01.40.CON.DCZ.E046 Jack,Audiooutput jack AV2-8.4-1GJP5 Antiflaming,Dow n red 2.Connected PIN38

47、and PIN69 of U6; 3.Add net mame ATA_CS1#、ATA_CS0#、ATA_RDY、ATA_RST#、D0.15 and A1.19、VFD_STB、DATA/SDA、CLOCK/SCL、IR. 3.Change Q3,Q4,Q5,Q6 into TO-92 Footprint; 4.Add TR1; 5.Change R56,R88 from 22K to 2.2K. 6.Change JP5. REV 1.2: 1.remove U15, U18, U19, U21, U22, U25; 2.R98, R99, R100, R101, R102, R128,

48、 R133, R136, R144, R132, R135, R143, R146, R126, R106, R127, R131, R134; 3.remove C95, C99, C100, C101; 4.connect MCLK_8740 to the oscillator at R129; 5.delete Isolation Transformer. 6.remove RJ45 connector. 7.Replace U15C with 74HCT14D. 8.Add C118, C119, C120, C121, C122, C123, and all Valued NA. 9

49、.Deleted C96, C97, C98, CE35, U24, and connected net +3.3V to L3. 1.Add C124C154; 2.Add D15 REV 1.3: HD980 HD980 History Harman Kardon A3 19Friday, September 19, 2008 Title SizeDocument NumberRev Date:Sheetof drawn by ABC PCB S鄏l Ch. du Saux 17 CH-1131 Tolochenaz harman/kardonHD 980/230 Service Manual Page 36 of 46 5 5 4 4 3 3 2 2 1 1 EE DD CC BB AA 1% 1% 1% 1% 1% NPO 5% 1% 1% 1% 1% 1% NPO 5% 1% 1% 1% 1% 1% NPO