Arcam-AVP700-avr-sm维修电路图 手册.pdf

《Arcam-AVP700-avr-sm维修电路图 手册.pdf》由会员分享，可在线阅读，更多相关《Arcam-AVP700-avr-sm维修电路图 手册.pdf（101页珍藏版）》请在收音机爱好者资料库上搜索。

1、SERVICE MANUAL AVP700 SURROUND SOUND PROCESSOR CONTENTS Page DISASSEMBLY INSTRUCTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 ADJUSTMENT POINTS DIAGRAM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 INSTRUMENT SETUP

2、 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 ALIGNMENT PROCEDURES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-6 IMPORTANT NOTES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

3、. . . . . . . . . . . . . . . . . 7-9 WIRING DIAGRAM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 PCB LAYOUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11-27 SCHEMATIC DIA

4、GRAM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28-39 IC BLOCK DIAGRAM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40-55 ELECTRICAL PARTS LIST . . . . . . . . . . . . . . . . . . . . . . . . . . . .

5、. . . . . . . . . . . . . . . . 56-95 EXPLODED VIEW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 96 EXPLODED VIEW PARTS LIST . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 97-100 RadioFans.CN AVP700 SURROUN

6、D SOUND PROCESSOR - 2 - 3 - AVP700 SURROUND SOUND PROCESSOR DISASSEMBLY INSTRUCTIONS 7 6 5 1 3 2 4 9 8 8 2. Pull both sides of the TOP COVER slightly outwards 8 and tilt approx. 35 and then remove in the direction as indicated by the arrow 9 . Refer to Figure No.2. 1. Remove machine screws M 4.0 x 6

7、.0 ( 1 to 6 ) from the side panels. Remove tapping screw 3.0 x 8.5 ( 7 )from the back panel. Refer to Figure No.1. Figure No.1 Figure No.2 RadioFans.CN AVP700 SURROUND SOUND PROCESSOR - 2 - 3 - AVP700 SURROUND SOUND PROCESSOR ADJUSTMENT POINTS DIAGRAM TUNER board OSCRF VT VIDEO board RadioFans.CN AV

8、P700 SURROUND SOUND PROCESSOR - 4 - 5 - AVP700 SURROUND SOUND PROCESSOR INSTRUMENT SETUP 1. FM MEASUREMENT Fig. 1 Fig. 2 2. RDS MEASUREMENT Fig. 3 3. AM MEASUREMENT Fig. 4 FM SIGNAL GENERATOR ANTENNA TERMINAL OUTPUT TERMINAL DISTORTION ANALYZER DISTORTION ANALYZER AC VOLTMETER OSCILLOSCOPE AC VOLTME

9、TER OR OSCILLOSCOPE AC VOLTMETER OR OSCILLOSCOPE OUTPUT TERMINAL OUTPUT TERMINAL L R ANTENNA TERMINAL ANTENNA TERMINAL ANTENNA TERMINAL AM LOOP ANTENNA (Accessory) AM LOOP ANTENNA 60cm DIGITAL MILLIVOLT METER VT-J954 FM SIGNAL GENERATOR AM SIGNAL GENERATOR FM SIGNAL GENERATOR RDS GENERATOR FM STEREO

10、 GENERATOR P-901 DC MILLIVOLT METER UNIT UNIT UNIT UNIT RadioFans.CN AVP700 SURROUND SOUND PROCESSOR - 4 - 5 - AVP700 SURROUND SOUND PROCESSOR FM/RDS SECTION - FM mono: 1kHz, 75kHz devi., 60dB/V - FM stereo: 1kHz, 67.5kHz devi., 60dB/V Pilot signal 19kHz 7.5kHz devi. OUTPUTS - Connect the non-induct

11、ive type resistor of 8 ohms to the all speaker terminals unless otherwise noted. ItemStep Connec- tion of instru- ment FM SG output Stereo modula- tor output Tuning frequency Output indicator Adjustment point Adjust forRemarks FM IF/RF 1 Fig.1 99.0MHz 1kHz 75kHz devi. 66dBf (60dB) 99.0MHz DC volt- m

12、eter L9410100mVFM MUTE/MODE switch: ON/AUTO Repeat the steps 1 to 3 until no further adjustment is neces- sary. 2 AC volt- meter IFT on the front end Maximum 3 Distortion analyzer L942Minimum Stereo Distor- tion Fig.2 99.0MHz Ext. mod. 66dBf (60dB) Channel L or R 1kHz 99.0MHz Distortion analyzer IFT

13、 on the front end Minimum FM MUTE/MODE switch: ON/AUTO. Dont turn more than +/-180. Stereo Sepa- ration Fig.2 99.0MHz Ext. mod. 66dBf (60dB) Channel L or R 1kHz 99.0MHz Oscillo- scope R956 Maximum Separa- tion Repeat stereo distortion and stereo separation align- ment until THD at minimum and sepa-

14、ration at maximum. Muting Level Fig.199.0MHz 22dB99.0MHz Oscillo- scope R941 Signal output RDSFig.3 99.0MHz Ext. mod. 66dBf (60dB) RDS 4% MOD 99.0MHz Decode the RDS Program Station. AM SECTION AM Modulation: 400Hz, 30% For UL Version StepAM SG outputTuning frequencyOutput indicatorAdjustment pointAd

15、just for 1530kHzDigital DC voltmeterQSC coil on RF block M9711.350.2V 2 600kHz 400Hz 30% mod. 60dB/M 600kHzAC voltmeterRF coil on RF block M971Maximum 3 600kHz 400Hz 30% mod. 60dB/M 990kHzAC voltmeterL972Maximum For CE Version StepAM SG outputTuning frequencyOutput indicatorAdjustment pointAdjust fo

16、r 1522kHz or 531kHzDigital DC voltmeterQSC coil on RF block M9711.350.2V (531kHz) 2 600kHz 400Hz 30% mod. 60dB/M 603kHzAC voltmeterRF coil on RF block M971Maximum 3 600kHz 400Hz 30% mod. 60dB/M 999kHzAC voltmeterL972Maximum ALIGNMENT PROCEDURES RadioFans.CN AVP700 SURROUND SOUND PROCESSOR - 6 - 7 -

17、AVP700 SURROUND SOUND PROCESSOR VIDEO BOARD SECTION 1 Required measurement equipment : 100KHz Scope, DVD player DVD test disc : TDV-540A 2 Connect the DVD Player into AVP700 composite Video IN; connect the component Video to TV (or connect 75 ohm loading resistor). 3 Play TDV-540A T2-C1 (75% colour-

18、bar UL NTSC / CE PAL). 4 Turn RV803 to adjust the component video Y voltage to 100075mV. 5 Turn RV804 to adjust the component video Cb voltage to 550mV30mV. 6 Turn RV805 to adjust the component video Cr voltage to 600mV30mV. RadioFans.CN AVP700 SURROUND SOUND PROCESSOR - 6 - 7 - AVP700 SURROUND SOUN

19、D PROCESSOR IMPORTANT NOTES 1. Show the software version Press “DVD” and “SAT” at the same time. 2. Light up all the icon on the VFL Press “CD” and “TAPE” at the same time. 3. Reset Press “FM MUTE” and “PRESET/TUNE” at the same time. When VFL shows “Resetl1 REQ?”, press “OK” button. For CE version,

20、the 9K/10KHz switch should be set to 9KHz and the voltage should be 230V AC. For UL version, the 9K/10KHz switch should be set to 10KHz and the voltage should be 115V AC. The 4/8 ohm switch should be set in 4ohm position in all version. Ground-SW: GROUND. 4. Upgrade MCU software The software of main

21、 CPU P89C669 can be upgraded via RS232. The programming steps are as follows: Connect the AVP700 to the computer. On AVP700, press the buttons RDS INFO and STORE at the same time. Then the front panel should display Program Req.:. Then press OK button. Or you can press RDS INFO and STORE for 3 secon

22、ds. Front panel will then display Program. The AVP700 is ready to be programmed. Note: when the program process is stopped unexpectedly, the program in IC may be erased. You can press these two buttons for 3 seconds for programming. Run the AVP700test.exe and click the button Program to CPU. Select

23、the appropriate COM Port and click the “Browse” to load the hex file. Then click the button Program. Upon the upgrade process is completed, a pop window will be shown. Note: Please try it again if there is error response. RadioFans.CN AVP700 SURROUND SOUND PROCESSOR - 8 - 9 - AVP700 SURROUND SOUND P

24、ROCESSOR 5. Upgrade DSP software DSP code in Flash Rom AT29LV040A can be upgraded via RS232. Connect the AVP700 to the computer. On AVP700, press the buttons RDS INFO and FM Mute/Mono at the same time. Then the front panel should display Program Req.:. Then press OK button. Or you can press RDS INFO

25、 and FM Mute/Mono for 3 sec- onds. Front panel will then display Program. The AVP700 is ready to be programmed. Note: when the program process is stopped unexpectedly, the program in IC may be erased. You can press these two buttons for 3 seconds for programming. Run the AVP700test.exe and click the

26、 button Program to DSP. Select the appropriate COM Port and click the “Browse” to load the s28 file. Then click the button Program. Upon the upgrade process is completed, a pop window will be shown. Finally, use Dolby, DTS, PCM test discs to see if all decodings are ok. This ensure the DSP has been

27、upgraded successfully. 6. HDMI check AVP700 contains two HDMI inputs (DVD, SAT) and one HDMI output. It functions as a 2 x 1 HDMI switch. Equipment used: 2 sets of DVD player (Arcam DV79) with HDMI output. (Support 720p/1080i) One HDTV support HDMI input (option 1) or C9993i demo board with another

28、YUV supported TV (option 2) 3 15m-HDMI cables RadioFans.CN AVP700 SURROUND SOUND PROCESSOR - 8 - 9 - AVP700 SURROUND SOUND PROCESSOR Test set up: Procedures: 1) Make sure all of equipments are OFF. Connect all grounds of equipments. 2) Connect the system as above. 3) Power on all units and set the D

29、VD1 with 720p HDMI output (If Samsung DVD is used ), DVD2 with 1080i HDMI output (If Samsung DVD is used). make sure that both DVD players have two copy protected DVDs inside. Note: If DVD79 is uses, please use below settings: Force DVI: No Output priority: HDMI/DVI Digital Video: RGB Progressive: O

30、ff Audio: PCM/2ch 4) On AVP700, switch to DVD source, the output signal on TV should not have any noise or snow. Both speakers should have output. 5) Repeat the same for SAT source. 6) Switch to other sources, there should be not both audio and video output. 7) Select to different sources, observe b

31、oth video and audio output. They should run properly. HDMI OUT HDMI OUT DVD SAT OUTHDMI IN 15m cable 15m cable 15m cable HDTV DVD1 DVD2 Audio FLAudio FR C9993i Board YUV video output YUV TV Audio FLAudio FR Option 1 Option 2 RadioFans.CN AVP700 SURROUND SOUND PROCESSOR - 10 - WIRING DIAGRAM DP802 P1

32、002B P120 PCB-LED P205B P1001A PCB-KEY P801A RE KEY-P101A 7012-6687-0 MAIN-P101B P101A 7012-6675-0 PCB-VOL PCB-PHO PHO-P807A 7012-7030-0 AUDIO-P807A TRANS 12PIN WIRE MAIN-P120 P105B P205A 7012-6688-0 PD102 PCB-VIDEO PHO-P807A 7012-7030-0 AUDIO-P807A SW-P870B-B 7012-6690-1 PSU-DP801 P103 PCB-PSU PCB-

33、SW P122A DSP-P122A 7012-6758-0 RS232-P122B MUTI-SP402 7012-6825-1 TUNE-ANTENAA PCB-AUDIO HDMI-P803 7012-AVP700-10 VIDEO-P801A PMAIN-P803A 7012-6844-0 MAIN-P803A PCB-DSP SW-P870B-A 7012-6691-0 PSU-DP802 P801 PCB-PMAIN P805A P100 P122B PD103 P1001B PCB-MULTI HDMI-P802 7012-AVP700-11 VIDEO-P803B PMAIN-

34、P802A 7012-6679-0 MUTI-P105B PMAIN-P801A 7012-7028-0 MUTI-P101B PSU P873 7012-6737-0 PWR-PD101 P807A P806A DSP-P103 7012-6747-0 VIDEO-P801 PCB-HDMI P805B P804B P102A P802A HDMI-P802 7012-7032-0 VIDEO-P803B DP801 HDMI-P802 7012-AVP700-10 VIDEO-P803B PSU P873 7012-6738-0 PWR-PD103 P1002A HDMI-P803 701

35、2-7033-0 VIDEO-P801A PCB-RS232 DSP-P122A 7012-6758-0 RS232-P122B HDMI-P100 7012-7029-0 MAIN-P804B P803A RS232-P805A 7012-7033-0 MAIN-P805B PD101 P801A PCB-TUNE P803A P802 P101A BLUE P806B P807A TRANS GRAND-WIRE PWR-PD102 PHO-P807A 7012-7030-0 AUDIO-P807A PCB-PWR PCB-MAIN PHO-P806B 7012-7031-0 PMAIN-

36、P806A KEY-P205B 7012-6750-0 RS232-P205A P803 SP402 P101B 7012-6688-0 P101B P803B RadioFans.CN - 11 - AVP700 SURROUND SOUND PROCESSOR TUNE board PCB LAYOUT RadioFans.CN AVP700 SURROUND SOUND PROCESSOR - 12 - 13 - AVP700 SURROUND SOUND PROCESSOR HDMI board top side RadioFans.CN AVP700 SURROUND SOUND P

37、ROCESSOR - 12 - 13 - AVP700 SURROUND SOUND PROCESSOR HDMI board bottom side RadioFans.CN AVP700 SURROUND SOUND PROCESSOR - 14 - 15 - AVP700 SURROUND SOUND PROCESSOR bottom sidetop side AUDIO board top side CONN board bottom side SW board top side RadioFans.CN AVP700 SURROUND SOUND PROCESSOR - 14 - 1

38、5 - AVP700 SURROUND SOUND PROCESSOR AUDIO board bottom side VOL boardLED board bottom sidetop side RadioFans.CN AVP700 SURROUND SOUND PROCESSOR - 16 - 17 - AVP700 SURROUND SOUND PROCESSOR POWER board PSU board PHONE board bottom sidetop side bottom sidetop side RadioFans.CN AVP700 SURROUND SOUND PRO

39、CESSOR - 16 - 17 - AVP700 SURROUND SOUND PROCESSOR KEY board RadioFans.CN AVP700 SURROUND SOUND PROCESSOR - 18 - 19 - AVP700 SURROUND SOUND PROCESSOR DSP board top side RadioFans.CN AVP700 SURROUND SOUND PROCESSOR - 18 - 19 - AVP700 SURROUND SOUND PROCESSOR DSP board bottom side RadioFans.CN AVP700

40、SURROUND SOUND PROCESSOR - 20 - 21 - AVP700 SURROUND SOUND PROCESSOR PMAIN board top side RadioFans.CN AVP700 SURROUND SOUND PROCESSOR - 20 - 21 - AVP700 SURROUND SOUND PROCESSOR PMAIN board bottom side RadioFans.CN AVP700 SURROUND SOUND PROCESSOR - 22 - MAIN board RadioFans.CN AVP700 SURROUND SOUND

41、 PROCESSOR - 23 - RS232 board top side RS232 board bottom side RadioFans.CN AVP700 SURROUND SOUND PROCESSOR - 24 - AVP700 SURROUND SOUND PROCESSOR - 25 - MULTI board top side RadioFans.CN AVP700 SURROUND SOUND PROCESSOR - 24 - AVP700 SURROUND SOUND PROCESSOR - 25 - MULTI board bottom side RadioFans.

42、CN AVP700 SURROUND SOUND PROCESSOR - 26 - AVP700 SURROUND SOUND PROCESSOR - 27 - VIDEO board top side RadioFans.CN AVP700 SURROUND SOUND PROCESSOR - 26 - AVP700 SURROUND SOUND PROCESSOR - 27 - VIDEO board bottom side RadioFans.CN AVP700 SURROUND SOUND PROCESSOR - 28 - AVP700 SURROUND SOUND PROCESSOR

43、 - 29 - KEY SCHEMATIC DIAGRAM 1234 A B C D 4321 D C B A GPE International Ltd. DWN.BY: SZ Lin APP.BY: MODEL: AVP700 DATE: 28/DEC 2004 DATE: ISSUE:A2 KEY SCH SHEET 1 OF 12 SG5 1 SG6 2 SG7 3 SG8 4 SG9 5 SG10 6 SG11 7 SG12 8 SG13 9 SG14 10 SG15 11 SG16 12 SG17 13 SG18 14 SG19 15 SG20 16 SG21 17 SG22 18

44、 SG23 19 SG24 20 SG25 21 SG26 22 SG27 23 SG28 24 SG29 25 SG30 26 SG31 27 SG32 28 SG33 29 SG34 30 SG35 31 GR1 32 GR2 33 GR3 34 GR4 35 GR5 36 GR6 37 GR7 38 GR8 39 GR9 40 GR10 41 GR11 42 GR12 43 GR13 44 GR14 45 GR15 46 GR16 47 VEE 48 VSS 49 OSCI 50 OSCO 51 RSTB 52 CSB 53 CLKB 54 DIN 55 VDD 56 P1 57 P2

45、58 AD2 59 AD1 60 SG1 61 SG2 62 SG3 63 SG4 64 U1001 PT6302 F 1 F 2 P36 3 P35 4 P34 5 P33 6 P32 7 P31 8 P30 9 P29 10 P28 11 P27 12 P26 13 P25 14 P24 15 P23 16 P22 17 P21 18 P20 19 P19 20 P18 21 P17 22 P16 23 P15 24 P14 25 P13 26 P12 27 P11 28 P10 29 P9 30 P8 31 P7 32 P6 33 P5 34 P4 35 P3 36 P2 37 P1 3

46、8 14G 39 13G 40 12G 41 11G 42 10G 43 9G 44 8G 45 7G 46 6G 47 5G 48 4G 49 3G 50 2G 51 1G 52 F 53 F 54 VF101 29-1403F P0.3 40 P0.2 41 P0.1 42 P0.0 43 VCC 44 NC 1 P1.0 2 P1.1 3 P1.2 4 P1.3 5 P1.4 6 P1.5 7 P1.6 8 P1.7 9 RST 10 P3.0 11 NC 12 P3.1 13 P3.2 14 P3.3 15 P3.4 16 P3.5 17 P3.6 18 P3.7 19 X2 20 X

47、1 21 GND 22 NC 23 P2.0 24 P2.1 25 P2.2 26 P2.3 27 P2.4 28 P2.5 29 P2.6 30 P2.7 31 PSEN 32 ALE 33 NC 34 EAVPP 35 P0.7 36 P0.6 37 P0.5 38 P0.4 39 U1002 AT89C52 C1001 20P C1002 20P CR1001 12M SW1024 DIRECT SW1025 DISPLAY SW1026 MUTE SW1006 RDS INFO SW1019 CD SW1020 FM SW1021 AM SW1014 SAT SW1015 AV SW1

48、016 VCR1 SW1009 MODE SW1010 BASS SW1011 MENU SW1003 PRESET SW1004 STORE SW1005 FM MUTE SW1022 EXT7.1 SW1023 ZONE2 SW1017 VCR2 SW1018 TAPE SW1012 OK SW1013 DVD SW1007 TREBLE SW1008 EFFECT SW1001 UP SW1002 DOWN SG1 SG2 SG3 SG4 SG5 SG6 SG7 SG8 SG9 SG10 SG11 SG12 SG13 SG14 SG15 SG16 SG17 SG18 SG19 SG20

49、SG21 SG22 SG23 SG24 SG25 SG26 SG27 SG28 SG29 SG30 SG31 SG32 SG33 SG34 SG35 SG0 SG0 GR1 GR1 GR2 GR3 GR4 GR5 GR6 GR7 GR8 GR9 GR10 GR11 GR12 GR13 GR14 GR2 GR3 GR4 GR5 GR6 GR7 GR8 GR9 GR10 GR11 GR12 GR13 GR14 AC4V1AC4V2 LE1011 LED LE1006 LED LE1001 LED LE1013 LED LE1008 LED LE1003 LED LE1002 LED LE1007 LED LE1012 LED LE1004 LED LE1009 LED LE1014 LED LE1015 LED LE1010 LED R1001 100 R1002 100 R1003 100 R1004 100 R1005 100 R1006 100 R1007 100 R1008 100 R1009 100 R1010 100 R