Sony-STR-DA5300ES-Service-Manual电路原理图.pdf

《Sony-STR-DA5300ES-Service-Manual电路原理图.pdf》由会员分享，可在线阅读，更多相关《Sony-STR-DA5300ES-Service-Manual电路原理图.pdf（260页珍藏版）》请在收音机爱好者资料库上搜索。

1、SERVICE MANUAL AUDIO POWER SPECIFICATIONS (US model) POWER OUTPUT AND TOTAL HARMONIC DISTORTION: With 8 ohm loads, both channels driven, from 20 20,000 Hz; rated 120 watts per channel minimum RMS power, with no more than 0.09% total harmonic distortion from 250 milliwatts to rated output. Amplifier

2、section POWER OUTPUT (US and Canadian models) Rated Power Output at Stereo Mode1) 2) (8 ohms 20 Hz 20 kHz, THD 0.09%): 120 W + 120 W Reference Power Output at Stereo Mode (4 ohms 20 Hz 20 kHz, THD 0.15%): 120 W + 120 W Reference Power Output (8 ohms 1 kHz, THD 0.7%) FRONT2): 130 W + 130 W CENTER2):

3、130 W SURROUND2): 130 W + 130 W SURROUND BACK2): 130 W + 130 W Reference Power Output (4 ohms 1 kHz, THD 0.7%) FRONT2): 120 W + 120 W CENTER2): 120 W SURROUND2): 120 W + 120 W SURROUND BACK2): 120 W + 120 W 1)Depending on the sound field settings and the source, there may be no sound output 2)Measur

4、ed under the following conditions: Power requirements: 120 V AC, 60 Hz (AEP, Russian, Ukrainian and UK models) Rated Power Output at Stereo Mode1) 2) (8 ohms 1 kHz, THD 0.7%): 125 W + 125 W Reference Power Output at Stereo Mode (4 ohms 1 kHz, THD 0.7%): 125 W + 125 W Reference Power Output (8 ohms 2

5、0 Hz 20 kHz, THD 0.09%) FRONT2): 120 W + 120 W CENTER2): 120 W SURROUND2): 120 W + 120 W SURROUND BACK2): 120 W + 120 W Reference Power Output (4 ohms 20 Hz 20 kHz, THD 0.15%) FRONT2): 120 W + 120 W CENTER2): 120 W SURROUND2): 120 W + 120 W SURROUND BACK2): 120 W + 120 W Reference Power Output at St

6、ereo Mode (8 ohms 1 kHz, THD 10%): 150 W + 150 W MULTI CHANNEL AV RECEIVER SPECIFICATIONS Ver. 1.1 2007.10 Continued on next page 9-887-741-02 2007J05-1 2007.10 Sony Corporation Home Audio Division Published by Sony Techno Create Corporation This receiver incorporates Dolby* Digital and Pro Logic Su

7、rround and the DTS* Digital Surround System. *Manufactured under license from Dolby Laboratories. Dolby, Pro Logic, Surround EX, and the double-D symbol are trademarks of Dolby Laboratories. * Manufactured under license from DTS, Inc. “DTS”, “DTS-ES” and “Neo:6” are registered trademarks of DTS, Inc

8、. and “DTS-HD Master Audio”, “DTS-HD High Resolution Audio” and “DTS 96/24” are trademarks of DTS, Inc. STR-DA5300ES US Model Canadian Model AEP Model UK Model RadioFans.CN 收音机爱 好者资料库 2 STR-DA5300ES Frequency response Inputs (Analog) Inputs (Digital) Outputs EQUALIZER FM tuner section Tuning range87

9、.5 108.0 MHz Antenna (aerial)FM wire antenna (aerial) Antenna (aerial) terminals 75 ohms, unbalanced AM tuner section T (US and Canadian models) uning range With 10-kHz tuning scale 530 1,710 kHz3) (AEP, Russian, Ukrainian and UK models) With 9-kHz tuning scale 531 1,602 kHz With 9-kHz tuning scale

10、531 1,710 kHz3) Antenna (aerial)Loop antenna (aerial) 3)You can change the AM tuning scale to either 9 kHz or 10 kHz After tuning in any AM station, turn off the receiver While holding down TUNING MODE, press POWER on the receiver All preset stations will be erased when you change the tuning scale T

11、o reset the scale to 10 kHz (or 9 kHz), repeat the procedure Video section Inputs/Outputs Video:1 Vp-p, 75 ohms COMPONENT VIDEO: Y: 1 Vp-p, 75 ohms PB/CB: 0.7 Vp-p, 75 ohms PR/CR: 0.7 Vp-p, 75 ohms 80 MHz HD Pass Through HDMI Video Input/Output (HDMI Repeater block) 640 480p60Hz 720 480p59.94/60Hz 1

12、440 480p59.94/60Hz (pixel sent 2times) 1280 720p59.94/60Hz 1920 1080i59.94/60Hz 1920 1080p59.94/60Hz 720 576p50Hz 1440 576p50Hz (pixel sent 2times) 1280 720p50Hz 1920 1080i50Hz 1920 1080p50Hz 1920 1080p24Hz PHONORIAA equalization curve 0 5 dB MULTI CHANNEL INPUT, SA-CD/CD, MD/DAT, DVD/BD, T TAPE/CD-

13、R, TAPE/CD-R, V, SAT/CATV, VIDEO 1/2/3 10 Hz 100 kHz 3 dB PHONOSensitivity: 2 5mV Impedance: 50kohms S/N: 90dB (A, 20 kHz LPF) MULTI CHANNEL INPUT, SA-CD/CD, MD/DAT, DVD/BD, TV, SAT/CATV, VIDEO 1/2/3 Sensitivity: 150mV Impedance: 50kohms S/N: 100dB (A, 20 kHz LPF) DVD/BD, VIDEO 2, SA-CD/CD (Coaxial)

14、 Impedance: 75ohms S/N: 96dB (A, 20 kHz LPF) VIDEO 1, TV, SAT/CATV, TAPE/CDR, MD/DAT (Optical) S/N: 96 dB (A, 20 kHz LPF) MD/DAT (REC OUT), VIDEO 1, ZONE 2, ZONE 3 (AUDIO OUT) Voltage:150mV Impedance: 1kohm FRONT L/R, CENTER, SURROUND L/R, SURROUND BACK L/R, SUB WOOFER Voltage: 2V Impedance: 1kohm G

15、ain levels10 dB, 1 dB step Reference Power Output at Stereo Mode (4 ohms 1 kHz, THD 10%): 150 W + 150 W Reference Power Output (8 ohms 1 kHz, THD 10%) FRONT2): 150 W + 150 W CENTER2): 150 W SURROUND2): 150 W + 150 W SURROUND BACK2): 150 W + 150 W Reference Power Output (4 ohms 1 kHz, THD 10%) FRONT2

16、): 150 W + 150 W CENTER2): 150 W SURROUND2): 150 W + 150 W SURROUND BACK2): 150 W + 150 W 1)Depending on the sound field settings and the source, there may be no sound output 2)Measured under the following conditions: Power requirements: 230 V AC, 50/60 Hz (in countries/area in Europe other than the

17、 U K ) 240 V AC, 50/60 Hz (in the U K and general area) General Power requirements 120 V AC, 60 Hz (US and Canadian models) Power output (DIGITAL MEDIA PORT) DC OUT:5 V, 700 mA Power consumption 480 W/580 VA (US/ 480 W (AEP, Russian, Ukrainian and UK models) Canada) Power consumption (during standby

18、 mode) 0.7 W (when “HDMI Control” and “RS-232C Control” is set to “OFF”) Dimensions430 175 430 mm (width/height/depth) including projecting parts and controls Mass (Approx.)16.0 kg Supplied accessories Operating Instructions Quick Setup Guide (1) HDMI CONTROL Guide (1) GUI Menu List (1) Optimizer mi

19、crophone ECM-AC1 (1) FM wire antenna (aerial) (1) AM loop antenna (aerial) (1) AC power cord (mains lead) (1) Remote commander RM-AAL008 (1) (US and Canadian models) Remote commander RM-AAL009 (1) (AEP, Russian, Ukrainian and UK models) Remote commander RM-AAU016 (1) R6 (size-AA) batteries (4) Desig

20、n and specifications are subject to change without notice. 230 V AC, 50/60Hz (in countries/area in Europe other than the U.K.) 230 240V AC, 50/60Hz (in the U.K. and general area) Ver. 1.1 RadioFans.CN 收音机爱 好者资料库 3 STR-DA5300ES Notes on chip component replacement Never reuse a disconnected chip compo

21、nent. Notice that the minus side of a tantalum capacitor may be damaged by heat. SAFETY-RELATED COMPONENT WARNING! COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE

22、 PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. ATTENTION AU COMPOSANT AYANT RAPPORT LA SCURIT! LES COMPOSANTS IDENTIFIS PAR UNE MARQUE 0 SUR LES DIAGRAMMES SCHMATIQUES ET LA LISTE DES PICES SONT CRITIQUES POUR LA SCURIT DE FONCTIONNEMENT. NE REMPLACER CES COM- POSA

23、NTS QUE PAR DES PICES SONY DONT LES NUMROS SONT DONNS DANS CE MANUEL OU DANS LES SUPPLMENTS PUBLIS PAR SONY. SAFETY CHECK-OUT After correcting the original service problem, perform the following safety check before releasing the set to the customer: Check the antenna terminals, metal trim, “metalliz

24、ed” knobs, screws, and all other exposed metal parts for AC leakage. Check leakage as described below. LEAKAGE TEST The AC leakage from any exposed metal part to earth ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500 microamper

25、es.). Leakage current can be measured by any one of three methods. 1. A commercial leakage tester, such as the Simpson 229 or RCA WT-540A. Follow the manufacturers instructions to use these instruments. 2. A battery-operated AC milliammeter. The Data Precision 245 digital multimeter is suitable for

26、this job. 3. Measuring the voltage drop across a resistor by means of a VOM or battery-operated AC voltmeter. The “limit” indication is 0.75 V, so analog meters must have an accurate low-voltage scale. The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOM that is suitable. Nearly all batt

27、ery operated digital multimeters that have a 2 V AC range are suitable. (See Fig. A) Fig. A.Using an AC voltmeter to check AC leakage. 1.5 k0.15 F AC voltmeter (0.75 V) To Exposed Metal Parts on Set Earth Ground TABLE OF CONTENTS 1.SERVICING NOTES.5 2.GENERAL. 11 3.DISASSEMBLY 3-1.Disassembly Flow .

28、 19 3-2.Case . 20 3-3.SP-TM Board, Tuner (FM/AM) . 20 3-4.D-CONNECT Board, DSP Board, DIGITAL Board, CIS Board and CONTROL Board. 21 3-5.D-VIDEO Board. 21 3-6.Front Panel Section . 22 3-7.S-VIDEO Board and A-VIDEO Board . 22 3-8.FLI-1.8REG Board and ANALOG Board. 23 3-9.Power Transformer (T001), E-V

29、OL Board and MAIN Board. 24 3-10. Heat Sink Section . 25 4.TEST MODE. 26 5.ELECTRICAL ADJUSTMENTS. 30 6.DIAGRAMS 6-1.Block Diagram CONTROL Section . 33 6-2.Block Diagram DSP Section . 34 6-3.Block Diagram DIGITAL AUDIO Section . 35 6-4.Block Diagram HDMI Section (1/2) . 36 6-5.Block Diagram HDMI Sec

30、tion (2/2) . 37 6-6.Block Diagram VIDEO PROCESS Section . 38 6-7.Block Diagram ANALOG AUDIO Section . 39 6-8.Block Diagram POWER AMP Section . 40 6-9.Block Diagram VIDEO Section (1/2) . 41 6-10. Block Diagram VIDEO Section (2/2) . 42 6-11. Block Diagram PANEL, CIS, XM/ SIRIUS RECEIVER, DMPORT Sectio

31、n . 43 6-12. Block Diagram POWER SUPPLY Section . 44 6-13. Printed Wiring Board MAIN Board (Component Side) . 46 6-14. Printed Wiring Board MAIN Board (Conductor Side) . 47 6-15. Schematic Diagram MAIN Board (1/4) . 48 6-16. Schematic Diagram MAIN Board (2/4) . 49 6-17. Schematic Diagram MAIN Board

32、(3/4) . 50 6-18. Schematic Diagram MAIN Board (4/4) . 51 6-19. Printed Wiring Board DIGITAL Board (Component Side) . 52 6-20. Printed Wiring Board DIGITAL Board (Conductor Side) . 53 6-21. Schematic Diagram DIGITAL Board (1/4) . 54 6-22. Schematic Diagram DIGITAL Board (2/4) . 55 6-23. Schematic Dia

33、gram DIGITAL Board (3/4) . 56 6-24. Schematic Diagram DIGITAL Board (4/4) . 57 6-25. Printed Wiring Board DSP Board (Side A) . 58 6-26. Printed Wiring Board DSP Board (Side B) . 59 6-27. Schematic Diagram DSP Board (1/4) . 60 6-28. Schematic Diagram DSP Board (2/4) . 61 6-29. Schematic Diagram DSP B

34、oard (3/4) . 62 6-30. Schematic Diagram DSP Board (4/4) . 63 6-31. Printed Wiring Board ANALOG Board (Component Side) . 64 6-32. Printed Wiring Board ANALOG Board (Conductor Side) . 65 6-33. Schematic Diagram ANALOG Board (1/3) . 66 6-34. Schematic Diagram ANALOG Board (2/3) . 67 6-35. Schematic Dia

35、gram ANALOG Board (3/3) . 68 4 STR-DA5300ES 6-92. Printed Wiring Board AC Board (TYPE A) . 124 6-93. Printed Wiring Board AC Board (TYPE B) . 124 6-94. Schematic Diagram AC Board . 125 7.EXPLODED VIEWS 7-1.Case Section .173 7-2.DIGITAL Board Section . 174 7-3.D-VIDEO Board Section. 175 7-4.DISPLAY B

36、oard Section. 176 7-5.Front Panel Section . 177 7-6.A-VIDEO Board Section. 178 7-7.ANALOG Board Section . 179 7-8.Heat Sink Section . 180 7-9.MAIN Board Section. 181 8.ELECTRICAL PARTS LIST. 182 6-36. Printed Wiring Board E-VOL Board . 69 6-37. Schematic Diagram E-VOL Board (1/2) . 70 6-38. Schemati

37、c Diagram E-VOL Board (2/2) . 71 6-39. Printed Wiring Boards CONNECTOR Section . 72 6-40. Schematic Diagram CONNECTOR Section . 73 6-41. Printed Wiring Board TEMPERATURE DETECTION Board . 74 6-42. Schematic Diagram TEMPERATURE DETECTION Board . 74 6-43. Printed Wiring Board A-CLASS AMP Board . 75 6-

38、44. Schematic Diagram A-CLASS AMP Board (1/2) . 76 6-45. Schematic Diagram A-CLASS AMP Board (2/2) . 77 6-46. Printed Wiring Board POWER AMPLIFIER Board . 78 6-47. Schematic Diagram POWER AMPLIFIER Board . 79 6-48. Printed Wiring Board PROTECTOR (F-C) Board . 80 6-49. Schematic Diagram PROTECTOR (F-

39、C) Board . 81 6-50. Printed Wiring Boards PROTECTOR (SB/SURR) Section . 82 6-51. Schematic Diagram PROTECTOR (SB/SURR) Section . 83 6-52. Printed Wiring Board BIAS Board . 84 6-53. Schematic Diagram BIAS Board . 85 6-54. Printed Wiring Board SP-TM Board . 86 6-55. Schematic Diagram SP-TM Board . 87

40、6-56. Printed Wiring Board D-VIDEO Board (Component Side) . 88 6-57. Printed Wiring Board D-VIDEO Board (Conductor Side) . 89 6-58. Schematic Diagram D-VIDEO Board (1/12) . 90 6-59. Schematic Diagram D-VIDEO Board (2/12) . 91 6-60. Schematic Diagram D-VIDEO Board (3/12) . 92 6-61. Schematic Diagram

41、D-VIDEO Board (4/12) . 93 6-62. Schematic Diagram D-VIDEO Board (5/12) . 94 6-63. Schematic Diagram D-VIDEO Board (6/12) . 95 6-64. Schematic Diagram D-VIDEO Board (7/12) . 96 6-65. Schematic Diagram D-VIDEO Board (8/12) . 97 6-66. Schematic Diagram D-VIDEO Board (9/12) . 98 6-67. Schematic Diagram D-VIDEO Board (10/12) . 99 6-68. Schematic Diagram D-VIDEO Board (11/12) . 100