Kenwood-SW-505-D-Service-Manual电路原理图.pdf

《Kenwood-SW-505-D-Service-Manual电路原理图.pdf》由会员分享，可在线阅读，更多相关《Kenwood-SW-505-D-Service-Manual电路原理图.pdf（8页珍藏版）》请在收音机爱好者资料库上搜索。

1、Type .Subwoofer system with built-in amplifier(Magnetically shielded)AmplifierRated Output Power .150 W RMS, 30 Hz 200 Hz, 4 Phase Switching .NORMAL, REVERSEInput Sensitivity & Input ImpedanceRCA-type pin-plug jack .100 mV /12 k200 mV /12 k(MONO Input)Push-type terminals .1.7 V (15 k)SpeakerEnclosur

2、e .Bass-Reflex, Floor Standing TypeSpeaker Unit .250 mm (10“) Cone typeNominal Impedance .4 GeneralRated Power Consumption .50 WDimensions .Width: 294 mm (11-9/16“)Height: 457 mm (18“)Depth:415 mm (16-5/16“)Net Weight .15.2 kg (33.5 lb)70%POWER SUBWOOFERSW-505D-S/505D-WSERVICE MANUAL2000-10/B51-5676

3、-00 (K/K) 1907LINE(MONO)FROM AMPLIFIERINPUTOUTPUTTO SPEAKERS+ R - L + R - L +LRL LR RLRVOLUME CONTROLPOWERON/STANDBYPEAK INDICATORMODEPHASEMUSICNORMALCINEMAMIN-ON OFFSLOPECROSSOVER12dB24dB60Hz200Hz MAXREVERSE0*Refer to parts list on page 9. Grille assy(B06-1497-08): B(B06-1498-08): WAC power cord *(

4、E30-)Button(POWER)(K29-0585-08): B(K29-0589-08): WSensor lens(B19-1289-08)Knob(VOLUME)(K29-0586-08): B(K29-0591-08): WControl panel(A21-3341-08): B(A21-3343-08): WB : BlackW: WhiteLens(B19-1290-08)Lens (B19-1291-08)Knob(CONTROL)(K23-0542-08): B(K23-0546-08): WButton(CONTROL)(K29-0587-08): B(K29-0588

5、-08): WSPECIFICATIONSKENWOOD follows a policy of continuous advancements indevelopment. For this reason specifications may bechanged without notice.Sufficient performance may not be exhibited at extremelycold locations (where water freezes).NotesSW-505D-S/505D-W2CONTENTS / ACCESSORIESSPECIFICATIONS.

6、Front coverCONTENTS / ACCESSORIES.2ADJUSTMENT.2PC BOARD.3SCHEMATIC DIAGRAM.5EXPLODED VIEW.8PARTS LIST.9ContentsADJUSTMENTNo.ITEMINPUTSETTINGSOUTPUTSETTINGSAMPLIFIERSETTINGSALIGNMENTPOINTALIGN FORFIG.1OFF SETConnect a DC volt-meter to speaker ter-minal.VOLUME: 0VR2010 mVPOWERVOLUMEPHASEMUSI C/CI NEMA

7、REMOTE CONTROL UNIT RC-W0502Pin-plug cord (1)(E30-5860-08)Remote control unit (1)(A70-0409-08)Batteries (R03/ AAA)AC plug adaptor (1)(E03-0115-05)* Use to adapt the plug on thepower cord to the shape ofthe wall outlet.(Accessory only for regionswhere use is necessary)AccessoriesACEGIBDFHJ2 1357 46Re

8、fer to the schematic diagram for the value of resistors and capacitors. PC BOARD (Component side view)34R102R243R244R240R242R228R227R210R205R246R223R215R211R214R213R212R222R207R206R203R202R201R204R217R208R224R230R225R216VR201R219C232C233R241R247C218C225C225-1L207J222J221L206C224C224-1C226C228C229C23

9、1C214I311341GOC221C237C219C227C217C208C206C238C205J206J209J208J214C202C213C236R231R221R232R233R234R235R236R226C230C220R245C212C211C216C215L205L204R105R104 C156C155C105C106C107C103C40491C320X301C303C334C405C331C305C332C371C313C330C154C153C125C126C127C150C152C151R103R106R109C102C101C104C138C109C134C13

10、7C100C133EBC135C209C235C204C203C207C210C20113C406R406R410R411VR402VR401R404 R403C402R402R401C401R405C403C501C5021421411315C316C319C312C318C370C311C3091112115142132IGO111 3322121EK41C317C314C315C302C310ACACC304C120R107R316R315R331R321R323R301R307R306R370R371R322R313R312R311R310R309R308R314R330R326R31

11、9R317R318R320R324R332R325R100R114R101R146R143R145R144R113 R112R111R110R152 R149R117R118R119C139C140C111C122C131C132R120R116C110C129C128C141C130C142C121R124R123R126R171R125R108R130R133R132R141R140R138R135R134R164R163R160R161R159R162R142R139R136R137R170R129R127R156R121R122R115R154R151R150R153R147R148R

12、155R128J119J120J224R250J223J302J301J304J305J303J118J122J106J103J105J107J121J125J126J124J123J117J502J501J506J503J509J510J511R503R502R501R504R505GRJ504J505J507J508J306J312J313J314J315J316J310J309J311J323J322J320J319J328J331J330J326J327J318J317J336J321J307J308J324J329J332J333T301TRANS531642CHANGE SWPOW

13、ER SWAC CORDR304R302RELAYF102F101R303J335J116J115J102J101J114J110J109J113J112J111 J10885 41IC20185 41IC20285 41IC2032011 101IC204145 8IC101D102D103D104D101D303D313D314D315D319 D317 D370IC302D311D312D316D225D226D224 D223D221D222D151D154D155D152D215D209D208D207D205D206DZ211DZ202 DZ201DZ212D210D213D214

14、D216D217D218D219D220D501LED504LED503LED505LED502 LED506D371D310D309D308D306D307D304D305D302D153D156145 8IC105TR10411516 30IC301EBTR102IC205EBTR501PT501POWER SWVOLTAGESELECTORPOWERTRANSFORMERSPEAKERAC CORDEBTR308J325OGI1111141131121IC303EBTR311E BTR310E BTR306E BTR307BETR101BETR103IC401BETR302BETR301

15、BETR304BETR305O GIIC304BETR370D301CN7CN12CN5CN4CN2BCN3BCON33 CON32 CON29 CON28CON31CON30BETR309BETR105BETR107BETR106BETR108145 8IC102145 8IC103CN6CN05CN03CN04J216J219J220J217J218J225J211J203J202J212J201J207J210J215J204J213C234R220J205EBQ212EBQ211E BQ202BEQ204B EQ203Q208Q207Q209GDSGDSGDSGDSQ210CN01CN

16、402CN401SW402CN501CN3ASW501SW502CN31CN30145 8IC104ABDFHJCEGI2 1357 46IC205IC401PT501IC301IC302IC303IC304CN04 CN05CN01D221D224 D222D223IC202 (1/2)Q212IC203DZ212 DZ21 1DZ201DZ202IC201IC202D207D208D206D205IC201 (1/2) D210D209Q211Q204IC101 (1/2)IC102 (1/2)TR101TR103TR105IC102 (2/2)TR108IC103 (1/2)IC104

17、(1/2)IC103 (2/2)D105D106IC104 (2/2)TR102(1/2)CN402MCN501/CON33LED506LED505LDE504LDE503LED502LED501SW501SW502PHASEMODETR501D501CN2BTR307TR309TR306D302TR310TR308D303TR302TR301TR304D371D304D305D306D307D310D31 1D312D309D308D317D314 D313D316 D315D370TR104IC105 (2/2)TR106TR107CN30IC101 (2/2)D104 D103D102D

18、101T101J101SW402SLOPEVOLUMEVR401:CROSS OVERCN3B CON32/TR370TR305TR311IC101-104:BA4558NIC105:LM393TR101,103,104,106,107:DTA114ESTR102,105,108:2SC2874D101-106,109,110:1N4148IC302:MC7805IC303:KA7812LIC304:KA7912LTR301,302:DTA114ESTR304,306,308,310:DTC114ESTR305,307,309,311:KTC3198YTR370:KTA1023YIC301KS

19、S57P0504N:LED501-503,505,506 TR501 PT501RPM-6938CBR-LKTC3198YB30-1835-08: :IC401BA6208:D213CN5D110D109LRRLINPUTOUTPUTLINEL R(MONO)B LINE B LINEGND LINE SIGNALLINEPEAKREUERSPOWERMUSICNORMALCINEMAIC105CN6CN31CN401B30-1836-08LED504:(2/2)(2/2)(1/2)1N4148D501:CN3A123 123423 1+C2321000u25C2140.10.01C231OU

20、TGNDIN+C234100u25R24210K10KR20410u16C201+321+C21010u1610KR20310u16+C203C2130.068100KR244R2406.8K 2.2K R243328411KR205C202470PR2021KR201 4.7MR207 10KR2081K5684745 6872.2K R2124.7K R215R21 12.2K+C20410u163.9KR213R21410K220PC2052 3470R2463.3KR210+C2351u503.3KR247+C2331000u80R23010KR2203.3KC2270.115R221

21、470KR225100K R1032200PC1534.7KR101100K R10410u16+C101100KC1552200P4.7KR102R106100K R10510u16+C1022200PC1542200PC156100PC1033281100P C10512KR10712KR100C1514700PC1524700PR1 10100KR 111100KR11310KR11210K10u16+C104R17010032110KR1 18470R1 1747KR12233KR1201KR1 196.8KR1211KR1241.5K R12356847R1 1647K1KR1151

22、0u16+C11047u16+C111R1252.2K6.8KR1268.2KR10810KR1291u50+C1221u50+ C1211KR1273241R1301K32176 5827KR13227KR133C1270.150.18C1251KR142C1260.082100KR14110u16+ C1301KR14010u16+C14210KR13810KR13410KR135470KR137+C1291u506.8K R139564710u16+C12847KR13632841100R147+C13547u16+C12047u1610KR14810KR1464.7K R12810KR

23、14547R143+C13310u1610KR14412345678910111234567891234100u16+C4060.01C4051324123456789101112131415R504220R503150150R501220R502R5051K+C50210u16132+C501100u6.3123456789101112131415302928272625242322212019181716C32033PC30333PX3014MHzR31410K47KR316R31510K0.01C333100R33110KR321R31310K10KR31210KR311TP20110K

24、R310TP202R30910KR30810K123456789101112100R332C3310.0112KR32082KR31810 111u50+C304R31710K45192221100R324100R32326 27R32218025R301180242221201918+C3702.2u5010KR37021192.2K R3263.3KR307+C3192.2u50100R3300.01C33422KR306INOUTGNDOUTINGND270R303+C3101000u16+C31 110u16270R304+C312100u16100u16+C30910u16C316+

25、470u25C314+C317+470u25C315+10u16GNDOUTINC3130.01SUB TRANST30198589 53 2 1C1500.1R15310K10KR1511.5K R15010KR15247K610u16C139+85R15410071u50C140R16347KR161R16033KR155220R159+R1621KR16447K33K 1KR14910u16+ C13412 1151089 67 34 1271211712 11C107100PC106100P33KR11446 57SLOPE GNDCROSS OVER GND11VR402A10u16

26、84.3KR40510910K(C)VR401A4.3K0.27C404R406756+10u16+C40210u16+C403C401423-24dB-12dB147K10K(C)VR401B47KR403R40447KR40247KFLATR401321456879101114131215192425201827262112 1310131112R3022254R3251K+C31810u163214R224470K3 11W0.1C332+C3050.047F5.5 10R3195VOUTGND10u16+ C138+C14122u1620KR10947u16C108+C10947u16

27、47u16C132+C13147u16B+B10u16+ C137VR402B0.1C236B+B+B +BB+B+B+BB+B+B+B+B+B+B+BB+BBB+BBB+BB+BB+BB+BB+B+B+B+B+B+BB+B+B+B+B+BB+BB+B+B+12V+12V+12V+12V+12V+12V+12V+12V0V0V-5.1V0V-12.4V11.8V0V0V0V0V0V0V0V0V-12.4V5.6V10.2V11.8V5.0V0V5.6V5.0V-5.1V5.6V10.2V11.2V-11.8V-12.4V5.6V5.6V-12.4V11.9V18.9V11.7V 14.6V10

28、.2V5.6V13.1V0.6V-10.0V-5.5V-11.9V11.8V20.0V-12.4V-21.0V-12.4V11.8V5.6V-12.4V0.6V4.9V0V10.2V2.4V2.4V0V4.6V4.9V5.0V4.9V4.9V4.9V4.9V0V0V4.9V4.9V5.0V0.2V 4.9V 0.2V 5.0V4.9V 5.0V0V 0V 0V4.9V5.6V4.9V4.8V5.5V0.6V0VKMOLNIC204SW-505DCN03D215D217D216D218D220D219D225D226Q207Q208Q210Q209D214Q203Q202IC203 (2/2)W

29、OOFEROFFSETPOWERD319CN4D301CN7IC201:LM393IC203:uPC4570CIC204:HIP4080AIC205:KA7812Q202:KTC3198YQ203:KTA1023YQ204:DTA124ESQ207-210:IRF540Q211:DTC114ESQ212:2SC2874DZ201,202,211,212:MTZJ3.3BD205-210:1N4148D213-220,225,226:EL1ZD221-224:1N4001D301:KBL10D302,310,317,319,370,371:1N4148D303-309,313-3161N4001

30、:D311,312MTZJ10B:IC202:uPC4570 orLM393CN12TRANSCHANGE_SWPOWER_SWAC_CORD12345678910BHBHENDISVSSOUTIN+IN-HDELLDELAHB20191817161514131211BHOBHSBLOBLSVDDVCCALSALOAHSAHO123R23115R2323.3R2331515R23415R2363.3R235C238 0.110u25+C2070.22C2152200PC217C218 1C216 10.22C2202200PC237R2450.1 3W0.22C2122.2KR2233.9K

31、R228+C2091u502.2KR227L204L205L207 L206470PC2210.22C2291C2241C224-1C219470P1C225-11C2250.22C228C2300.47C22633R2410.222.2KR206C2061000P47KR2174.7K 1/4WR2197652.2K R21610K(B)VR2014.7KR22643KR2221000PC20821 1 2 321: AC230V 50Hz(E): AC110-120V/: AC120V 60Hz50/60Hz(K,P)(Y,M)220-240V110-120V1 32 1 2MAIN TR

32、ANS221 1 2 1 2 3 31 2 1T1.25AL250VF102F101T2.5AL250VRELAY1L2 L1RELAY221213322113 10.1C330+C3024700u80100R371C2110.22BNBL1/2W220-240VEUROPEEDESTINATIONCOUNTRYU.S.A.CANADAGENERALPXABB.M Y P KNOYESYESF101YES F102NONONOL07-3037-08T301SW2L07-3036-08MARKET+12V+12V+12V11.9V12.4VSW2SW1SW-505D-S/505D-WY19-58

33、80-20CAUTION:For continued safety, replace safety critical com-ponents only with manufacturers recommended parts (referto parts list).indicates safety critical components. For con-tinued protection against risk of fire, replace only with sametype and rating fuse(s). To reduce the risk of electric sh

34、ock,leakage-current or resistance measurements shall be carriedout (exposed parts are acceptably insulated from the supplycircuit) before the appliance is returned to the customer.The DC voltage is an actual reading measured with a highimpedance type voltmeter with no signal input. The measure-ment

35、value may vary depending on the measuring instru-ments used or on the product.DTA114ESDTA124ESDTC114ESUPC4570CBA4558NABCDEFGHJKLM:N50-3008-45:N50-3010-45:N50-4018-45:N50-4014-45:N50-4018-45:N30-4012-45:N50-3006-45:N50-2608-45:N11-0040-46:N30-3010-45:N11-0030-45:N50-3012-453x8 (BLK)3x10 (BLK)4x18 (BL

36、K)4x14 (BLK)M4x18 (BLK)4x12 (BLK)3x6 (BLK)2.6x8 (BLK)M4M3x10 (BLK)M33x12(BLK)Hx2HHx2Ax2Ax2Jx2Jx2Gx2Gx2Gx4Gx2Gx2Gx2Gx2Gx2Gx2 Gx2Gx2GDx4Ex12Mx3Fx2Fx2Lx2Kx2Gx2Gx2Gx2Gx2Ax2Bx2Cx2Cx2Cx2Bx2Bx2Bx2Ax2SW-505DM.Y only604613645612SW1611623623601621606620647648646x2610623624774602650SP1605622SW26247707367367367

37、36736736736761737703762x2760739735738771730742735740741760x2775x2773772775x2T30112A CBParts with exploded numbers larger than 700 are not supplied. EXPLODED VIEW (UNIT)SW-505D-S/505D-W8SW-505D-S/505D-W9PARTS LISTRef. NoAdd-ressNewPartsParts No. DescriptionDesti-nationRe-marksC103 CK45FB1H101K CERAMI

38、C 100PF KC104 CE04CW1C100M ELECTRO 10UF 16WVC105-7 CK45FB1H101K CERAMIC 100PF KC108 CE04CW1C470M ELECTRO 47UF 16WVC109 CE04CW1C470M ELECTRO 47UF 16WVC110 CE04CW1C100M ELECTRO 10UF 16WVC111 CE04CW1C470M ELECTRO 47UF 16WVC120 CE04CW1C470M ELECTRO 47UF 16WVC121,2 CE04CW1H010M ELECTRO 1.0UF 50WVC125 C91

39、-0213-08 FILM 0.18UF 63WVC126 C90-5132-08 FILM 0.082UF 63WVC127 C90-5133-08 FILM 0.15UF 63WVC128 CE04CW1C100M ELECTRO 10UF 16WVC129 CE04CW1H010M ELECTRO 1.0UF 50WVC130 CE04CW1C100M ELECTRO 10UF 16WVC131,2 CE04CW1C470M ELECTRO 47UF 16WVC133,4 CE04CW1C100M ELECTRO 10UF 16WVC135 CE04CW1C470M ELECTRO 47

40、UF 16WVC137-9 CE04CW1C100M ELECTRO 10UF 16WVC140 CE04CW1H010M ELECTRO 1.0UF 50WVC141 CE04CW1C220M ELECTRO 22UF 16WVC142 CE04CW1C100M ELECTRO 10UF 16WVC150 CK45FB1H104K CERAMIC 0.10UF KC151,2 CK45FF1H472Z CERAMIC 4700PF ZC153-6 CK45FB1H222K CERAMIC 2200PF KC201 CE04CW1C100M ELECTRO 10UF 16WVC202 CK45

41、FB1H471K CERAMIC 470PF KC203,4 CE04CW1C100M ELECTRO 10UF 16WVC205 CK45FB1H221K CERAMIC 220PF KC206 CK45FB1H102K CERAMIC 1000PF KC207 CE04CW1E100M ELECTRO 10UF 25WVC208 CK45FB1H102K CERAMIC 1000PF KC209 CE04CW1H010M ELECTRO 1.0UF 50WVC210 CE04CW1C100M ELECTRO 10UF 16WVC211,2 C90-5135-08 FILM 0.22UF 2

42、50WVC213 C90-5136-08 FILM 0.068UF 250WVC214 CK45FB1H104K CERAMIC 0.10UF KC215 C90-5135-08 FILM 0.22UF 250WVC216 C90-5137-08 FILM 1UF 250WVC217 CK45FB1H222K CERAMIC 2200PF KC218 C90-5137-08 FILM 1UF 250WVC219 CK45FB1H471K CERAMIC 470PF KC220 C90-5135-08 FILM 0.22UF 250WVC221 CK45FB1H471K CERAMIC 470P

43、F KC224-1 C90-5137-08 FILM 1UF 250WVC224,5 C90-5137-08 FILM 1UF 250WVC225-1 C90-5137-08 FILM 1UF 250WVC226 C90-5138-08 FILM 0.47UF 250WVC227 CK45FB1H104K CERAMIC 0.10UF KC228,-30 C90-5135-08 FILM 0.22UF 250WVC231 CK45FB1H103K CERAMIC 0.010UF KC232 CE04DW1E102M ELECTRO 1000UF 25WVC233 C90-5139-08 ELE

44、CTRO 1000UF 80WVC234 CE04CW1E101M ELECTRO 100UF 25WVC235 CE04CW1H010M ELECTRO 1.0UF 50WV New PartsParts without Parts No. are not supplied.Les articles non mentionnes dans le Parts No. ne sont pas fournis.Teile ohne Parts No. werden nicht geliefert.2L : Scandinavia K : USA P : Canada R : Mexico C :

45、China I : MalaysiaY : PX(Far East,Hawaii) T : England E : Europe G : Germany V : China(Shanghai) Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components .Ref. NoAdd-ressNewPartsParts No. DescriptionDesti-nationRe-marks601 1A A02-2538-08 CONTROL BOX B

46、DCC-0006-01 B601 1A A02-2541-08 CONTROL BOX BDCC-0007-01 W602 2B A02-2539-08 AMP BOX BDCC-0003-01604 1A A21-3341-08 CONTROL PANEL BDCC-0004-01 B604 1A A21-3343-08 CONTROL PANEL BDCC-0005-01 W605 2C A23-5507-08 CHASSIS/REAR BCCS-0571-01 KP605 2C A23-5508-08 CHASSIS/REAR BCCS-0572-02 Y605 2C A23-5509-

47、08 CHASSIS/REAR BCCS-0572-01 M605 2C A23-5510-08 CHASSIS/REAR BCCS-0571-02 E606 1B A70-0409-08 REMOTE CONTROL610 2A B06-1497-08 GRILLE ASSY B610 2A B06-1498-08 GRILLE ASSY W611 1A B19-1289-08 SENSOR LENS BDDS-0111-01612 1A B19-1290-08 POWER/PEAK LENS,BDDS-0110-01613 1A B19-1291-08 CINEMA/NORM LENS,BDDS-0112-01620 1B E03-0115-05 AC PLUG ADAPTER M621 1B E30-58