Admiral-C322C-Sams-383-1电路原理图.pdf

《Admiral-C322C-Sams-383-1电路原理图.pdf》由会员分享，可在线阅读，更多相关《Admiral-C322C-Sams-383-1电路原理图.pdf（35页珍藏版）》请在收音机爱好者资料库上搜索。

1、PHOTOFACT* Folder ADMIRAL MODELS C322C2, 3, 16, 17, 26, 27, CA322C16, 17, 26, 27, CS322C2, 3, 16, 17, 26, 27, LC322C36, 37, 39, LCS322C36, 37, 39 (Ch. 29AZ1, 29SZ1, B, 29Z1, B) DISASSEMBLY INSTRUCTIONS CHASSIS REMOVAL 1. Remove 4 push-on type knobs from the front . 2. Remove 10 wood screws and 2 met

2、al screws from the rear cover. Remove the rear cover. 3. Remove 2 metal screws holding the side control panel. 4. Remove speaker leads. 5. Remove 6 chassis bolts from the bottom. 6. Remove the chassis. PICTURE TUBE REMOVAL 1. Remove the HV lead from the HV rectifier socket. 2. Remove the picture tub

3、e socket, blue lateral magnet, purity magnet and the convergence yoke assembly. 3. Remove 2 wing nuts and the yoke. 4. Remove 4 hex nuts holding the yoke retainer bracket. 5. Loosen, but do not remove 2 nuts on the sides of the yoke bracket to allow the bracket to tilt upward. 6. Remove the bolt fro

4、m the tube mounting strap. 7. Remove the picture tube and insulating boots. 8. In replacing boots make certain to replace in correct order. MODEL C322C26(CH. 29Z1) TRADE NAMEAdmiralMODELSCHASSIS Chassis Runs 1 thru 17 C322C2, C322C3, C322C16, C322C17, C322C26, C322C27 29Z1 CA322C16, CA322C17, CA322C

5、26, CA322C27 29AZ1 CS322C2, CS322C3, CS322C16, CS322C17, CS322C26, CS322C27 29SZ1 LC322C36, LC322C36, LC322C37, LC322C39 29Z1B LCS322C36, LCS32237, LCS32239 29SZ1B MANUFACTURER Admiral Corp., 3800 W. Cortland St., Chicago 47, Illinois TYPE SET Color Television Receiver TUBES Twenty-nine POWER SUPPLY

6、 110-120 Volts AC ,60 Cycle RATING 370 Watts, 3. 5 Amp. llTVolts AC TUNING RANGE Channels 2 thru 13 VHF, 14 thru 83 UHF, Video IF 45. 75MC, Sound IF 41. 25MC (Intercarrier) INDEX Alignment Instructions 6, 7, 8 Block Diagram 3 Drive Cord Stringing (UHF) 22 Disassembly Instructions 1 Miscellaneous Adj

7、ustments 21, 22 Parts List and Descriptions 23 thru 27 Photographs Cabinet-Rear View 22 Capacitor Identification 12, 13, 16, 17 Chassis-Top View 9 Photographs (Cont) RF Tuner 5 Resistor Identification 14, 15, 20, 29 Trans., Inductor and blue lateral magnets. Set to the center of rotation. Set fully

8、counter clockwise. Adjust so that the screw extends 3/8 from the coil form end. Adjust so that the screw extends 3/8 from the coil form end. Adjust for white dots in the central area of the raster. Switch generator to vertical line pattern. Green and blue grids; red, green and blue screens. Red and

9、green vertical amplitude; and red and green vertical tilt. Red and green DC Blue vertical tilt and blue vertical amplitude Adjust for equal intensity vertical white line pattern. Adjust for straight red and green vertical lines using blue lines as reference). Repeat until correct results are obtaine

10、d. Converge red and green vertical lines over blue lines at the center of the screen. If necessary, repeat step 10. Switch to horizontal line pattern. Adjust blue lines so that they are equally spaced or coin- cident with red and green horizontal lines from top to bottom at center of the screen. If

11、neces- sary, repeat step 11. Switch to vertical line pattern. The red, green and blue vertical lines at center of screen should be converged forming a white line. If not, repeat steps 10 and 11 . Switch to horizontal line pattern. The red, green and blue horizontal lines should coincide at the cente

12、r of the screen. If not, repeat step 12. Blue horizontal ampli- tude and blue horizon- tal tilt. Blue horizontal ampli- tude. Blue horizontal tilt, Red, green and blue DC Turn fully counter clockwise. Adjust clockwise for downward bow of blue horizontal line SLIGHTLY to the right of the center. Adju

13、st clockwise to make blue center hori- zontal line as straight as possible. Adjust for convergence at center of the screen. ADMIRAL MODELS C322C2, 3, 16, 17, 26, 27, CA322C16, 17, 26, 27, CS322C2, 3, 16, 17, 26, 27, LC322C36, 37, 39, FOLDER 1 LCS322C36, 37, 39 (Ch. 29AZ1, 295Z1, B, 29Z1, B) SET 383

14、FOLDER 1 PAGE 21 RadioFans.CN MISCELLANEOUS ADJUSTMENTS (cont.) CONVERGENCE ADJUSTMENTS (Cont) 19. 20. Repeat steps 15 thru 18 for red and green horizontal lines. NOTE: The bow of the red and green horizontal lines will be SLIGHTLY upward to the right of the center of the screen. Switch generator to

15、 the dot pattern. Observe the overall convergence of the dot pattern. Touch-up the adjustments for clearly defined white dots at the center area of the screen BLACK AND WHITE TRACKING ADJUSTMENT STEP I. 2. 3. 4. 5. 6. ADJUST Contrast control. Green and blue grids. Red, green and blue screens. Bright

16、ness control. Green grid. Blue grid. REMARKS Fully counter clockwise. Fully counter clockwise. One-third from fully counter clockwise. Fully clockwise, then counter clockwise until raster is just extinguished. Fully clockwise, then counter clockwise until raster is just extinguished. Fully clockwise

17、, then counter clockwise until raster is just extinguished. 7. 8. 9. 10. 11. 12. Tune in a black and white signal and check color of picture. The picture should remain black and white throughout the usable range of the contrast and brightness controls. If the picture appears greenish, perform steps

18、8 and 10. If the picture appears bluish, perform steps 9 and 11. If the picture appears reddish, perform step 12. If the picture still is not black and white, repeat the entire procedure. Green screen. Blue screen Green grid. Blue grid . Red screen. Turn very SLIGHTLY clockwise. Turn very SLIGHTLY c

19、lockwise. Very SLIGHTLY counter clockwise until the picture is black and white. Very SLIGHTLY counter clockwise until the picture is black and white. Very SLIGHTLY counter clockwise until the picture is black and white. KNOT 3 TURNS UHF DRIVE CORD STRINGING HORIZ CENTERING VERT CENTERING HORIZ FREQ

20、HORIZ DRIVE CABINET-REAR VIEW PAGE 22 RadioFans.CN PARTS LIST AND DESCRIPTIONS TUBES (GENERAL ELECTRIC, SYLVANIA) ITEM No. VI V2 V3 V4 V5 V6 V7 V8 V9 no Vll V12 V13 V14 V15 V16 USE RF Amplifier Mixer-Oscillator 1st. Video IF Amp. 2nd. Video IF Amp. 3rd. Video IF Amp. 4th. Video IF Amp. Video Output

21、AGC Keying Sound IF Amp. -AF Amp. Ratio Det. Audio Output Sync Sep. Sync Amp. -Vert. Mult. Vert. Mult. -Vert. Output Horiz. Mult. Horiz. Output TYPE 6BN4 6CG8 6BZ6 8BZ6 6BZ6 6CB6 12BY7 6AU6 6U8 6AL5 6V6GT 6CS6 6CG7 6AQ5 6CG7 8CB5A NOTES Notel Note 2 ITEM No. V17 V18 V19 V20 V21 V22 V23 V24 V25 V26 V

22、27 V28 USE Damper Focus Rectifier HV Rectifier HVRegulator let. Chroma Bandpass Amp. -Color Killer Chroma Output Pulse Shaper- Burst Amp. Chroma Sync Phase Det. Chroma Ref. Osc. Control- Chroma Ref. Osc. R-Y Demodulator - B-Y Demodulator LV Rectifier LV Rectifier TYPE 6AU4GTA 1V2 3A3 6BK4 6AW8 6CL6

23、6BH8 6AL5 6U8 12BH7 5U4GB 5U4GB NOTES Note 1. Chassis 29Z1B, 29SZ1B use a 6BV8 in this application Note 2. Chassis 29Z1B, 29SZ1B use a 6L6GB in this application. PICTURE TUBE ITEM No. V29 REPLACEMENT DATA ADMIRAL PART No. 21AXP22A GENERAL ELECTRIC PART No. 21AXP22A SYLVANIA PART No. 21AXP22A NOTES E

24、LECTROLYTIC CAPACITORS ITEM No. CIA B C C2A B C3 C4A B C D C5 C6 RATING CAP. .80 .10 ilO .100 ISO 4 .20 20 50 16 4 4 VOLT. 450 350 450 450 450 150 450 25 350 450 50 150 REPLACEMENT DATA ADMIRAL PART No. 67D15-137 67D15-136 67A4-2 67D15-138 67A4-9 67A4-2 AEROVOX PART No. AFH4-18-10 AFH2-64-25 PRS150V

25、4 AFH4-75 PRS150V4 PRS150V4 CORNELL- DUBILIER PART No. D0179 rB0483 LJBR1045 BBR4-150 BBR4-50 BBR4-150 MALLORY PART No. FP450 rFP247 LTC72 TC40 rFP345.3 LTC70 TC30 TC40 PYRAMID PART No. TMQ-122 rTMS-61 l-TD-50-450 TD-4-150 TD-4-50 TD-4-150 SANGAMO PART No. rQ-067 LMT-3512 rS-285 LMT-4550 MT-1504 pQ-

26、380 -MT-4504 MT-0504 MT-1504 SPRAGUE PART No. R2467 R2468 * TVA-1303 R2469 * TVA-1303 TVA-1303 * Non-catalog item. FIXED CAPACITORS Capacity values given in the rating column are in mfd. for Paper Capacitors, and in mmfd. for Mica and Ceramic Capacitors. ITEM No. C7 C8 C9 CIO Cll C12 C13 014 CIS C16

27、 C17 CIS C19 C20 C21 C22 C23 C24 C25 C26 C27 C28 C29 C30 C31 C32 C33- C34 C35 C36 C37 C38 C39 C40 C41 C42 C43 C44 C45 C46 C47 C48 C49 C50 C51 C52 C53 C54 C55 RATING CAP. 120 30 28 12 1000 1-4.5 5 1000 1000 1-4.5 1000 1000 1-4.5 47 30 1000 1000 2.0 6.8 3.0 1000 24 10 820 820 820 20000 1.0 820 820 820

28、 5000 820 5000 820 820 820 820 5000 100 82 4.7 6.8 150 .0015 10000 6.8 3.3 2200 VOLT 100 600 REPLACEMENT DATA ADMIRAL PART No. 94D131-79 94D131-80 94D131-81 94D131-95 94D131-82 94D131-83 94D131-84 94D131-85 94D131-82 94D131-83 94D131-82 94D131-82 94D131-83 94D131-87 94D131-88 94D131-89 94D131-90 94D

29、131-93 94D131-92 94D131-91 94D131-82 65D6-112 65D6-115 65D10-91 65D10-91 65D10-91 65D10-28 64A10-3 65D10-91 65D10-91 65D10-91 65D10-5 65D10-91 65D10-5 65D10-91 65D10-91 65D10-91 65D10-91 65D10-5 65D6-19 65D10-98 65D10-101 65D10-102 65B20-151 64B8-18 65DIO-3 65D6-82 65D6-89 65D10- 89 AEROVOX PART No.

30、 NPO-SI 120 EF-001 BPD-001 EF-001 EF-001 EF-001 EF-001 EF-001 NPO-SI 10 SI 820 SI 820 SI 820 BPD-02 P288N-1.0 SI 820 SI 820 SI 820 BPD-005 SI 820 BPD-005 SI 820 SI 820 SI 820 SI 820 BPD-005 N750-SI 100 NPO-SI 4. 7 NPO-SI 6. 8 1469-00015 BPD-0015 BPD-01 NPO-SI 6. 8 NPO-SI 3. 3 BPD-0022 C6NTRALAB PART

31、 No. D6-121 MFT-luOO 829-6 DD-102 MFT-1000 829-6 MFT-1000 MFT-1000 829-6 MFT-1000 MFT-1000 TCZ-24 TCZ-10 DD-821 DD-821 DD-821 DD-203 DD-821 DD-821 DD-821 DD-502 DD-821 DD-502 DD-821 DD-821 DD-821 DD-821 DD-502 TCN-100 TCZ-82 TCZ-4R7 TCZ-6R8 D6-152 DD-103 TCZ-6R8 TCZ-3R3 DD-222 CORNELL- DUBILIER PART

32、 No. L10T12 BYA6D1 CTA6Q24C CTA6Q1C L10T82 L10T82 L10T82 BYB6S2 CUB2W1 UOT82 L10T82 L10T82 BYA10D5 L10T82 BYA10D5 L10T82 L10T82 L10T82 L10T82 BYB10D5 CTA6T1U C10Q82C C10V47C C10V68C 22R5T15 CUB6D15 BYA6S1 C10V68C C10V33C BYA10D22 ERIE PART No. ED-120 532-B ED-1000 532-B 532-B TCO-24 TCO-10 ED-820 ED

33、-820 ED-820 ED-02 ED-820 ED-820 ED-820 ED-005 ED-820 ED-005 ED-820 ED-820 ED-820 ED-820 ED-005 TC7-100 TCO-82 TCO-4. 7 TCO-6.8 GP-1500 ED-01 TCO-6. 8 TCO-3.3 ED-0022 MALLORY PART No. DC521 ZT-541 GEM-21 t DCS 25 DC525 DCS 25 NT-531 ZT-5547 ZT-5568 GEM-6215 DC5U ZT-5568 ZT-5533 UC-5222 SPRAGUE PART N

34、o. 5TCC-T12 503C-D1 5HK-D1 503C-D1 503C-D1 503C-D1 503C-D1 503C-D1 5TCC-Q1 5GA-T82 5GA-T82 5GA-T82 5HK-S2 2TM-M1 5GA-T82 5GA-T82 5GA-T82 5HK-D5 5GA-T82 5HK-D5 5GA-T82 5GA-T82 5GA-T82 5GA-T82 5HK-D5 5TCU-T1 5TCCB-V47 5TCCB-V6! MS -315 6TM-D15 5HK-S1 5TCCB-V68 5TCCB-V33 5GA-D22 NOTES 10% 5% 10% 10% N9

35、00 10% 20% N750 5% N550 10% N330 10% NPO 5% NPO 5% NPO 10% N750 5% NPO 5% NPO 5% NPO 5% 10% 5% NPO r- TO n M in N r- w - 10 _ 2 M 2 n n J2 O u K 0 , n O s N - _ r K N 2 * KJ n O 5 3 SET 383 FOLDER 1 PAGE 23 RadioFans.CN CAPACITORS (cont) PARTS LIST AND Dl coi ITEM No. C56 C57 C58 C59 C60 C91 C62 C63

36、 C64 C65 C66 C67 C68 C69 C70 C71 C72 C73 C74 C75 C76 C77 C78 C79 C80 C81 C82 C83 C84 C85 C86 C87 CSS C89 C90 C91 C92 C93 C94 C95 C96 C97 C98 C99 C100 C101 002 C103 CUM C105 C106 C107 C108 C109 C110 cm C112 C113 C114 C115 C116 CUT C118 C119 C120 C121 C122 C123 C124 C125 C126 C127 C128 C129 C130 C131

37、C132 C133 C134 CIS 5 C136 C137 C138 C139 C140 C141 C142 C143 C144 C145 C146 C147 CMS C149 C150 C151 C152 C153 C154 C155 C156 C157 C158 C159 C160 C161 C162 RATING CAP. 5000 2200 5000 5000 180 20000 20000 47 .033 .047 .0047 .001 1.0 5000 .22 5000 1000 .0047 .0047 .033 .33 .056 .0027 .12 .0015 .001 .00

38、1 .0047 .001 5000 .047 22 3900 .1 220 .1 470 .01 .1 .22 250 250 82 .47 .47 .1 .15 56 .0033 .047 .1 .1 470 .001 .0047 5000 100 82 6.8 43 10000 1200 20000 5000 2400 10000 5000 1.0 22 18 20000 10000 10000 20000 20000 5000 .1 2200 3.5- 28 2200 20000 2200 10000 4700 .22 2.0 220 20000 .047 220 82 22 18 20

39、00( 47 10000 .1 .01 .01 .01 .39 .39 47 .47 .047 .047 .047 VOLT 400 400 600 1600 100 600 600 600 600 200 400 1600 600 600 400 400 600 600 200 600 200 600 600 600 3000 3000 4000 200 200 600 400 5000 600 600 600 600 400 600 100 200 400 400 600 1000 1000 1000 200 200 200 200 600 600 600 REPLACEMENT DATA

40、 ADMIRAL PART No. 65D10-5 65010-89 65D10-5 65D10-5 65D10-52 65D10-28 65D10-28 65D10-80 8486-29 64B8-28 64B8-15 64B2-28 64A10-3 65D10-5 64B8-5 65010-5 64B8-19 64B8-15 64B8-15 84B22-10 64B22-36 64B 22-44 64B2-37 64B22-43 64B8-18 64B2-24 64B2-24 64B8-15 S4B8-19 65D10-5 64B8-41 65B21-220 65B21-392 64B8-

41、7 65B20-221 64B6-39 65B20-471 64B8-13 64B8-7 64B8-5 65D10-114 65D10-114 65D10-98 64B22-35 64B22-35 64B6-7 64B8-25 65D10-126 64C25-17 64B8-9 64B8-7 64B8-7 65D10-70 64A2-24 64B8-15 65D10-5 65D6-82 65D10-95 65D10-3 65D10-28 64BS-15 65B20-242 85D10-3 65D10-5 64A10-3 65D6-30 65D10-104 65D10-28 65D10-3 65

42、D10-3 65D10-28 65010-28 65D10-5 64B8-39 65D10-89 66B40-5 65010-89 66D10-28 85D10-89 65D10-3 64BB-15 64B8-24 65D6-58 65B21-221 65010-28 64B8-28 65D10-83 65D10-98 65D6-30 65D10-104 65D10-28 6906-84 65D10-3 64B8-7 64B2-13 64B2-13 64B2-13 64B 22-42 64B22-42 64B22-35 64B22-35 64B8-9 64B8-9 64B2-36 AEROVO

43、X PART No. BPD-005 BPD-0022 BPD-005 BPD-005 BPD-02 BPD-02 BPD-000047 BPD-03 BPD-05 BP 0-0047 P288N-1. 0 BPD-005 P688N-22 BPD-005 BPD-001 BPD-0047 BPD-0047 BPD-0015 BPD-0047 BPD-001 BPD-005 BPD-05 1469-000022 1464-0039 P688N-1 1469-00022 P288N-1 1464-00047 BPD-01 P688N-1 P688N-22 P688N-1 P488N-15 BPD

44、-0033 BPD-05 P688N-1 P688N-1 SI 470 BPD-0047 BPD-005 BPD-0001 1468-000082 NPO-SI 6. 8 BPD-01 BPD-02 BPD-005 1464-0024 BPD-01 BPD-005 P288N-1.0 SI 18 BPD-02 BPD-01 BPD-01 BPD-02 BPD-02 BPD-005 P288N-1 BPD-0022 BPD-0022 BPD-02 BPD-0022 BPD-01 BPD-0047 P488N-22 BPD-02 BPD-05 BPD-00022 BPD-02 NPO-SI 47

45、BPD-01 P688N-1 P1088N-01 P10B8N-01 P1088N-01 P288N-47 BPD-05 BPD-05 BPD-05 CENTRALAB PART No. DD-502 DD-222 DD-502 DD-502 DD-203 DD-203 DD-470 DF-303 DF-503 DD-472 DD-502 00-502 DD-102 DD-472 DD-472 DD-152 DD-472 DD-102 DD-502 DF-503 D6-220 DF-104 DF-104 DD-103 DF-104 DF-104 DD-332 DF-503 DF-104 DF-

46、104 D6-471 DD-472 DD-502 DD-101 TCZ-6R8 DD-103 DD-122 DD-203 DD-502 00-103 DD-502 DF-104 TCZ-22 DD-180 DD-203 DD-103 DD-103 DD-203 DD-203 DD-502 DF-104 DD-222 DD-222 DD-203 DD-222 DD-103 DD-472 D6-221 DO-202 DF-503 DD-221 TCZ-82 TCZ-22 DD-180 DD-203 TCZ-47 DD-103 DF-104 DD-103 DD-103 DD-103 DF-503 D

47、F-503 DF-503 CORNELL- DUBILIER PART No. BYA10D5 BYA10D22 BYA10D5 BYA10D5 BYB6S2 BYB6S2 L10Q47 CUB6S33 CUB4S47 CUB6D47 CUB2W1 BYA10D5 CUB6P22 BYA10D5 BYA6D1 CUB6D47 CUB6D47 CUB6D15 CDB6D47 CUB6D1 BYA10D5 CUB2S47 22R5Q22 1R5D39 CUB6P1 22R5T22 CUB2P1 5R5T47 CUB6S1 CUB6P1 CUB6P22 CUB6P1 CUB6P15 CUB6D33

48、CUB6S47 CUB6P1 CUB6P1 LT6T47 CUB6D47 BYA10D5 L10T1 5W5Q82 CTA6V68C BYA6S1 L10D12 BYB6S2 BYA10D5 1R5D24 BYA6S1 BYA10D5 CUB2W1 L10Q18 BYB6S2 BYA6S1 BYA6S1 BYB6S2 BYB6S2 BYA10D5 CUB2P1 BYA10D22 BYA10D22 BYB6S2 BYA10D22 BYA6S1 BYA10D47 CUB4P22 BYB6S2 CUB4S47 L10T22 C10Q82C L10Q18 BYB6S2 C10Q47C BYA6S1 C

49、UB6P1 CUB10S1 CUB10S1 CUB10S1 CUB2P47 CL1B6S47 CUB6S47 CUB6S47 ERIE PART No. ED-005 ED-0022 ED-005 ED-005 ED-02 ED-02 ED-47 GP-4700 ED-005 ED-005 ED-001 GP-4700 GP-4700 GP-1500 GP-4700 GP-1000 ED-005 GP-10000 GP-3300 GP-470 GP-4700 ED-005 ED-100 TCO-6. 8 ED-01 ED-0012 ED-02 ED-005 ED-01 ED-005 ED-18 ED-02 ED-01 ED-01 ED-02 ED-02 ED-005 ED-0022 ED-0022 ED-02 ED-0022 ED-01 ED-0047 ED-220 ED-02 ED-220 TCO-82 ED-18 ED-02 TCO-47 ED-01 MALLORY PART No. DC525 UC-5222 DC525 DC525 GEM-6133 GEM-4147 GEM-6247 GEM-21 DC525 GEM-6022 DC525 DC521 GEM-6247 GEM-6247 GEM-2033 GEM-6215 GEM-6247 GEM- 621 D