Sony-STRDE715-rec-sm 维修电路原理图.pdf

《Sony-STRDE715-rec-sm 维修电路原理图.pdf》由会员分享，可在线阅读，更多相关《Sony-STRDE715-rec-sm 维修电路原理图.pdf（260页珍藏版）》请在收音机爱好者资料库上搜索。

1、MICROFILMManufactured under license from Dolby Laboratories LicensingCorporation.“Dolby”, the double-D symbol a and “Pro Logic” are trademarksof Dolby Laboratories Licensing Corporation.FM STEREO/FM-AM RECEIVERPhoto : STR-DE615US ModelSTR-D560Z/D660Z/DE615/DE715Canadian ModelSTR-DE615/DE715Australia

2、n ModelSTR-DE715SERVICE MANUALSTR-D560Z/D660Z/DE615/DE715 Continued on page 2 SPECIFICATIONSRadioFans.CN 收音机爱 好者资料库 2 TABLE OF CONTENTSSpecifications . 11.GENERALLocation and Function of Controls . 42.DIAGRAMS2-1. IC Pin Functions . 62-2. Circuit Boards Locations . 102-3. Printed Wiring Boards AMP S

3、ection . 112-4. Schematic Diagram AMP Section . 152-5. Schematic Diagram Surround Section . 192-6. Printed Wiring Boards Surround Section . 232-7. Schematic Diagram Display Section (STR-D560Z/DE615) . 262-8. Printed Wiring Boards Display Section (STR-D560Z/DE615) . 292-9. Printed Wiring Boards Displ

4、ay Section (STR-D660Z/DE715) . 332-10. Schematic Diagram Display Section (STR-D660Z/DE715) . 373.EXPLODED VIEWS3-1. Front Panel Section. 443-2. Chassis Section . 463-3. Back Panel Section . 474.ELECTRICAL PARTS LIST . 48RadioFans.CN 收音机爱 好者资料库 3 3. Measuring the voltage drop across a resistor by mea

5、ns of a VOMor battery-operated AC voltmeter. The “ limit” indication is0.75V, so analog meters must have an accurate low-voltage scale.The Simpson 250 and Sanwa SH-63Trd are examples of a pas-sive VOM that is suitable. Nearly all battery operated digitalmultimeters that have a 2V AC range are suitab

6、le. (See Fig. A) Fig. A. Using an AC voltmeter to check AC leakage.Earth GroundTo Exposed Metal Parts on Set1.5k0.15FACvoltmeter(0.75V)SAFETY CHECK-OUTAfter correcting the original service problem, perform the follow-ing safety check before releasing the set to the customer :Check the antenna termin

7、als, metal trim, “metallized” knobs, screws,and all other exposed metal parts for AC leakage. Check leakage asdescribed below.LEAKAGE TESTThe AC leakage from any exposed metal part to earth ground andfrom all exposed metal parts to any exposed metal part having areturn to chassis, must not exceed 0.

8、5mA (500 microampers).Leakage current can be measured by any one of three methods.1. A commercial leakage tester, such as the Simpson 229 orRCAWT-540A. Follow the manufacturers instructions to usethese instruments.2. A battery-operated AC milliammeter. The Data Precision 245digital multimeter is sui

9、table for this job.SAFETY-RELATED COMPONENT WARNING!COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITHMARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTSLIST ARE CRITICAL TO SAFE OPERATION.REPLACE THESE COMPONENTS WITH SONY PARTS WHOSEPART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR INSUPPLEMENTS PUBLI

10、SHED BY SONY.ATTENTION AU COMPOSANT AYANT RAPPORT LA SCURIT!LES COMPOSANTS IDENTIFIS PAR UNE MARQUE ! SUR LESDIAGRAMMES SCHMATIQUES ET LA LISTE DES PICES SONTCRITIQUES POUR LA SCURIT DE FONCTIONNEMENT. NEREMPLACER CES COMPOSANTS QUE PAR DES PICES SONYDONT LES NUMROS SONT DONNS DANS CE MANUEL OUDANS

11、LES SUPPLMENTS PUBLIS PAR SONY. 4 SECTION 1GENERALLOCATION AND FUNCTION OF CONTROLSThis section is extracted frominstruction manual. ? !?! ! !?!? ! ! !? 0?91234?5?678FRONT PANEL! AUDIO FUNCTION buttons! VIDEO FUNCTION buttons! DIRECT button! SHIFT button! Numeric buttons PRESET TUNING +, buttons MEM

12、ORY button DISPLAY button FM/AM button FM MODE button TUNING +, buttons PHONES jack SPEAKERS switch1 DPC MODE button2 POWER switch3 SUR, TONE, INDEX indicators4 Digital processing control buttons5 Function indicators6 DIRECT PASS indicator7 5.1 INPUT indicator8 MASTER VOLUME control9 BALANCE control

13、! BASS BOOST button/indicator! SOUND FIELD ON/OFF button! MODE button! GENRE button! DIRECT PASS, SET UP, 5.1/DVD INPUT buttons 5 12345670890)=+rPp(91234567890!SYSTEM CONTROL/FUNCTION buttons!5.1/INPUT button!TV/VIDEO button!Direct TUNING button!CH/PRESET button!TEST TONE button!CENTER LEVEL +, butt

14、onsREAR LEVEL +, buttonsMASTER VOL buttonsMUTING buttonBASS BOOST button1LEARN button/indicator2SLEEP button3TV CONTROL ON button4Numeric, ENTER buttons5BACKGROUND button6VCR/CD/DVD control buttons7SOUND FIELD buttons8DIRECT button9DPC MODE button0DIGITAL PROCESSING CONTROL buttons!VISUAL POWER butt

15、on!SYSTEM OFF buttonREMOTEREAR PANEL 6 SECTION 2DIAGRAMSIC103 MB90673PF-G-196-BND (SYSTEM CONTROL) (STR-D660Z/DE715)Pin No.Pin nameI/ODescription1AC MUTEOAC mute drive.2D. LATOData latch output.3T. LATOTuner function latch output.4S. CLKOSerial clock output.5S. DATAOSerial data output.6S. LATOSerial

16、 latch output.7AUTO STOPOTuner auto stop output.8T. MUTEOTuner mute output.9STEREOIStereo detect signal input.10IF DATA INIIF data input.11VSS (D)Ground.12V-AOVideo switch control output.13V-BOVideo switch control output.14RM INPUTIRemote control signal input.15V-EOVideo switch control output.16V-IN

17、HNot used (Open).17LED DATAOLED data output.18LED CLROLED clock signal output.19S. POWERIPower switch input.20RX (SIN)Not used (Fixed at “ L ” )21TX (SOUT)Not used (Open).22BUSYNot used (Open).23FL CLEAROFL reset signal output.24FL DATAOFL data output.25FL CLKOFL clock output.26FL LATOFL latch signa

18、l output.27Not used (Ground).28VCC(A)Analog power supply (+4.9V).29 + AVRConnect to VDD (+5.1V).30 AVRNot used (Ground).31GND (D)Ground.32AD KEY IN1IKey input.33AD KEY IN2IKey input.34VSS(D)Ground.35AD KEY IN3IKey input.36AD KEY IN4IKey input.37AD KEY IN5IKey input.38AD VERSIONIModel select.39VOL +O

19、Volume up control output.40VOL OVolume down control output.41MODE0Not used (Fixed at “ H ” )42MODE1Not used (Fixed at “ H ” )43MODE2Not used (Ground).44STANDBYConnect to VDD (+5.1V).45STOPOPower ON/OFF control output.2-1. IC PIN FUNCTION 7 Pin No.Pin nameI/ODescription46LERNING LEDNot used (Open).47

20、Not used (Ground).48Not used (Ground).49CTR A INIControl S signal input (DE715 : US, Canadian model).50STANDBY LEDNot used (Open).51VOL LEDOVolume LED drive.52S-OUTOControl S signal output (DE715 : US, Canadian model).53CTR A OUTOControl S signal output (DE715 : US, Canadian model).54VIDEO1 (M-BUS)O

21、VIDEO1 control signal output.55VIDEO2 (M-BUS)OVIDEO2 control signal output.56TV (M-BUS)OTV control signal output.57Not used (Ground).58SP OFF INISpeaker switch input.59SIGNAL INNot used (Ground).60Not used (Ground).61Not used (Ground).62RESETIReset terminal.63VSS(D)Ground.64XOOSystem clock (4.19MHZ)

22、.65XIISystem clock (4.19MHZ).66VCC(D)Digital power supply (+4.9V).67Not used (Ground).68POWER RYOPower relay drive.69BRIDGE RYPower key input.70SUR RYOSurround relay drive.71CENTER RYOCenter relay drive.72FRONT RY (H,P)OFront (Headphone) relay drive.73MIX/SUB RYOWoofer relay drive.744/8 INNot used (

23、Ground).75PROTECT INIProtector operation input.76DIRECT PASSODirect pass relay drive.77BASS BOOSTOBass boost ON/OFF control.78F/C/W MUTEOFront, Center, Woofer mute drive.79SL MUTEOSurround L-CH mute drive.80SR MUTEOSurround R-CH mute drive. 8 IC103 PD780205GF-027-3BA (SYSTEM CONTROL) (STR-D560Z/DE61

24、5)Pin No.Pin nameI/ODescription1Not used (Connect to VDD).2 4Not used (Connect to ground).5F/C/W. MUTEOFront, Center, Woofer mute drive.6SL MUTEOSurround L-CH mute drive.7SR MUTEOSurround R-CH mute drive.8AC MUTEOAC mute drive.9D LATCHOData latch output.10RESETIReset terminal.11X2OSystem clock (4.19

25、MHZ).12X1ISystem clock (4.19MHZ).13VSSGround.14NPNot used (Open).15Connect to reset terminal.16VDDPower supply (+5V).17T LATCHOTuner function latch output.18S CLOCKOSerial clock output.19S DATAOSerial data output.20S LATCHOSerial latch output.21AUDIO. STOPOTuner auto stop output.22TUNER MUTEOTuner m

26、ute output.23STEREOIStereo detect signal input.24IF DATA INIIF data input.25GND A/DGround.26SIRCSIRemote control signal input.27POWER KEYIPower key input.28VERSIONIModel select input.29KEY 5IKey input.30KEY 4IKey input.31KEY 3IKey input.32KEY 2IKey input.33KEY 1IKey input.34VDD A/DPower supply (+5V)

27、.35VREF A/DIReference voltage input.36V-AOVideo switch control output.37V-BOVideo switch control output.38V-EOVideo switch control output.39STOPOPower ON/OFF control output.40VSSGround.41DIRECT PASSODirect pass relay drive.42SUR RYOSurround relay drive.43CENTER RYOCenter relay drive.44FRONT RYOFront

28、 relay drive.45MIX SUB RYOWoofer relay drive. 9 Pin No.Pin nameI/ODescription46VDDPower supply (+5V).47PROTECTOR INIProtector operation input.48POWER RYOPower relay drive.49BASS BOOSTOBass boost ON/OFF control.50SP OFFISpeaker switch input.51VOL OVolume down control output.52VOL +OVolume up control

29、output.53VOL LEDOVolume LED drive.54STANDBY LEDNot used (Open).55Not used (Open).56BASS BOOST LEDOBASS BOOST LED drive.575.1 INPUT LEDO5.1 INPUT LED drive.58DIRECT PASS LEDODIRECT PASS LED drive.59SUR LEDOSUR LED drive.60TONE LEDOTONE LED drive.61VIDEO 1 LEDOVIDEO 1 LED drive.62INDEX LEDOINDEX LED d

30、rive.63PHONO LEDOPHONO LED drive.64TUNER LEDOTUNER LED drive.65DAT MD LEDODAT/MD LED drive.66CD LEDOCD LED drive.67TAPE LEDOTAPE LED drive.68TV/DBS LEDOTV/DBS LED drive.69VIDEO2 LEDOVIDEO2 LED drive.70 78P1 P9OFL segment drive.79V LOARDFL power supply ( 35V).80 87P10 P17OFL segment drive.88 100G1 G1

31、3OFL segment drive. 10 2-2. CIRCUIT BOARDS LOCATIONS?AUDIO SW board?AUDIO boardAU-VIDEO boardSURR AUDIO boardHP boardDISPLAY boardVOL boardVIDEO boardSP SW boardSW boardBALANCE boardL. B. SW board5.1 IN boardSP boardREAR AMP boardAMP JOINT (B) boardSURR boardCONT (AS-1) boardAMP boardSECONDARY board

32、STANDBY boardS-A-SP boardCTRL-A board (DE715 : US, Canadian model) 41 r IC BLOCK DIAGRAMS (AMP)IC701 uPC2581V12345678V+VSB/SESINVSARESETGNDOUTCVSCCRVREF+QRS123456789101112131415302928272625242322212019181716CONTROLLATCHSHIFT RESISTORLEVEL SHIFTCLDICEVEEOUTINOUTINOUTINVSSSRESETVDDOUTININOUTINOUTINIC9

33、01 NJM2103D235467981MUTE+ VOUT1 VOUT1COMP1MF1IN1GNDIN2NF2COMP2 VOUT2+ VOUT2VCC1VCC2VEEPROTECTORBIAS CIRCUITREGDRIVEPREDRIVE111012131514DRIVEPREDRIVE123456789TR3R1R2TR4TR6TR7R4R9TR5TR1TR2R6D4 D3R7R8TR8D1 D2R5R3INPUTNF-VEOUT+VEOUTVSSGNDVCCSUBIC301, IC303 LC7822r IC BLOCK DIAGRAMS (SURROUND)+23674581V+

34、VIC405 M5218ALIC502 TC9184P16151413121110912345678S. DATAT. LAT+9V9VGNDS. CLKTONECEBASS +BASS COMTREBLE TREBLE +BASS +BASS COMTREBLE TREBLE +IC601 STK350-230 42 12345678915101112131416DECODERDECODERMONITOR OUTGNDIN5GNDIN4CTL EIN3CTL D6dB6dBIN1CTL AV OUT1VCCIN2CTL BV OUT2CTL CIC201 SN7612001234567891

35、01112131415302928272625242322212019181716CONTROLLATCHSHIFT RESISTORLEVEL SHIFTCLD1CEVEEL1L2L COM1L3L4L COM2L5L6L COM3L7R1R2R COM1R3R4R COM2R5R6R COM3R7L COM4VSSSRESVDDR COM4IC406 LC7823235467981MUTE+ VOUT1 VOUT1COMP1MF1IN1GNDIN2NF2COMP2 VOUT2+ VOUT2VCC1VCC2VEEPROTECTORBIAS CIRCUITREGDRIVEPREDRIVE111

36、012131514DRIVEPREDRIVEIC501 uPC2581V 43 r IC BLOCK DIAGRAMS (DISPLAY )IC102 M66004FP-M6 (STR-D660Z/DE715)123456789NCOUTPUT 2VccGNDNCINPUT 2INPUT 1NCMOTORDRIVEMOTORDRIVEREGSWITCHSWITCHOUTPUT1IC106 BA6208 (STR-D550Z/D660Z/DE615/DE715)IC1102 NJM2129D (STR-D660Z/DE715)+235467981INHIBITGNDREG OUTNCOUT1IN

37、2IN3IN4VCC1VCC2REG-SWIN1INHIBIT1OUT2INHIBIT2REGULATORINHIBIT1110121314SEGMENTOUTPUTCIRCUIT(35BIT x 16)DECODERINDICATIONCODERESISTOR(8BIT x 16)DECODER(35BIT x 16)CODE/COMMANDCONTROLCIRCUITINDICATIONCONTROLRESISTORINDICATIONCONTROLLERDIGIT OUTPUTCIRCUITCODEWRITECODE SELECTSERIALRECEIVECIRCUITOUTPUTPOR

38、T(2BIT)CLOCKGENERATORCIRCUITRAMWRITE2120192213326064 - 6159 - 3323 - 311 - 1217 1814 15 16G13|G16VCC2P1|P27VSSXINXOUTVCC1RSTG12|G1VPCSSCKSDATAP36|P28 44 Les composants identifis par unemarque !sont critiques pour la scurit.Ne les remplacer que par une piceportant le numro spcifi.The components ident

39、ified by mark !or dotted line with mark ! are criticalfor safety.Replace only with part number specified.SECTION 3EXPLODED VIEWSNOTE :r-XX, -X mean standardized parts, so they mayhave some difference from the original one.rItems marked “ * ”are not stocked since they areseldom required for routine s

40、ervice. Some delayshould be anticipated when ordering these items.rThe mechanical parts with no reference numberin the exploded views are not supplied.rHardware (# mark) list and accessories and pack-ing materials are given in the last of this partslist.rAbbreviationCND: CanadianAUS: Australian3-1.

41、FRONT PANEL SECTION4A : L.B. SW boardSONYSONY123456789101112121213141415161616161718192021(including 4A)2223232425not suppliednot suppliedsupplied withRV401not supplied#1#1#1#1#1#1FL1014ADE715 :US,CNDModel 45 Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark* 171-665-478-11BALANCE B

42、OARD (D660Z/DE715)* 171-665-467-11BALANCE BOARD (D560Z/DE615)* 181-665-477-11VOL BOARD (D660Z/DE715)* 181-665-466-11VOL BOARD (D560Z/DE615)191-773-130-11WIRE (FLAT TYPE) (19 CORE) (100mm)201-769-928-11WIRE (FLAT TYPE) (9 CORE) (DE715:US,CND)* 21A-4392-893-A DISPLAY BOARD, COMPLETE (D560Z/DE615)* 21A

43、-4392-918-A DISPLAY BOARD, COMPLETE (DE715:US,CND)* 21A-4392-919-A DISPLAY BOARD, COMPLETE (DE715:AUS)* 21A-4392-942-A DISPLAY BOARD, COMPLETE (D660Z)221-773-115-11WIRE (FLAT TYPE) (19 CORE) (320mm)* 234-921-941-01CUSHION (FL)* 243-386-245-11HOLDER (FL) (D560Z/DE615)* 244-981-656-01HOLDER (C), FL IN

44、DICATION TUBE(D660Z/DE715)* 25A-4392-908-A SW BOARD, COMPLETEFL1011-517-519-11INDICATOR TUBE, FLUORESCENT(D660Z/DE715)FL1011-517-672-11INDICATOR TUBE, FLUORESCENT(D560Z/DE615)14-980-639-01KNOB (R14)2X-4946-873-1KNOB (R48) ASSY3X-4948-324-1PANEL ASSY, FRONT (DE615)3X-4948-325-1PANEL ASSY, FRONT (D560

45、Z)3X-4948-328-1PANEL ASSY, FRONT (DE715:US,CND)3X-4948-329-1PANEL ASSY, FRONT (D660Z)3X-4948-557-1PANEL ASSY, FRONT (DE715:AUS)44-989-850-01BUTTON (BB)54-989-842-01INDICATOR (BB)64-989-852-01RING (SUR)74-989-846-01BUTTON (12)83-008-600-11EMBLEM (5-AR), SONY94-989-843-01BUTTON (P-T)104-957-383-01KNOB

46、 (F14)* 111-665-481-11SP.SW BOARD (D660Z/DE715)* 111-665-470-11SP.SW BOARD (D560Z/DE615)123-704-366-01SCREW (CASE) (M3X8)* 134-982-682-01CASE (414532)144-985-642-01CUSHION* 154-989-878-01BRACKET (VOL)164-951-620-01SCREW (2.6X8), +BVTP 46 Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRe

47、markThe components identified by mark !or dotted line with mark ! are criticalfor safety.Replace only with part number specified.Les composants identifis par unemarque !sont critiques pour la scurit.Ne les remplacer que par une piceportant le numro spcifi.3-2. BACK PANEL SECTION#1#1CNJ909#1#1#1#1#1#

48、1#1#1#1#1#1#1#1#1#1#25152535455565758596060616263646566not suppliednot suppliedsupplied withJ701AUS Model US,CND Model US,CND Model AUS Model DE715 :US,CND Model* 51A-4392-896-A AUDIO BOARD, COMPLETE (D560Z/DE615)* 51A-4392-923-A AUDIO BOARD, COMPLETE (D660Z/DE715)* 521-665-480-11AU-VIDEO BOARD (D66

49、0Z/DE715)* 521-665-469-11AU-VIDEO BOARD (D560Z/DE615)* 531-665-492-11S-A-SP BOARD* 54A-4392-913-A SP BOARD, COMPLETE(DE615/DE715:US,CND)* 54A-4392-936-A SP BOARD, COMPLETE (DE715:AUS)* 54A-4392-941-A SP BOARD, COMPLETE (D560Z/D660Z)* 551-665-468-11HP BOARD (D560Z/DE615)* 551-665-479-11HP BOARD (D660

50、Z/DE715)* 56A-4392-905-A SURR BOARD, COMPLETE (US,CND)* 56A-4392-931-A SURR BOARD, COMPLETE (AUS)571-773-108-11WIRE (FLAT TYPE) (19 CORE) (160mm)* 58A-4392-917-A SW AUDIO BOARD, COMPLETE* 593-703-244-00BUSHING (2104), CORD!601-696-847-11CORD, POWER (AUS)!601-769-743-11CORD, POWER (US,CND)614-956-370