HarmanKardon-HD980_230-cd-sm维修电路原理图.pdf

《HarmanKardon-HD980_230-cd-sm维修电路原理图.pdf》由会员分享，可在线阅读，更多相关《HarmanKardon-HD980_230-cd-sm维修电路原理图.pdf（47页珍藏版）》请在收音机爱好者资料库上搜索。

1、 harman/kardon Service Manual HD 980/230 CD Player Released EU2009 Harman International Rev1, 05/2012 8500 Balboa Boulevard Northridge, California 91329 SEMICONDUCTOR PINOUTS 16 PCB DRAWINGS 30 BLOCK DIAGRAM 35 VERSION HISTORY 36 SCHEMATIC DIAGRAMS 37 SERVICE BULLETIN, RATTLE NOISE 47 BASIC SPECIFIC

2、ATIONS 2 TROUBLESHOOTING GUIDE 3 PACKAGE LIST AND PARTS 4 EXPLODED VIEW 5 PARTS LIST 6 CONTENTS RadioFans.CN 收音机爱 好者资料库Signal FormatSampling Frequency32 kHz to 96 kHzD/A ConversionMultibit Sigma-Delta modulatorOversampling24-bit/176.4 kHz Sample Rate Convertor or 24-bit/96 kHz with HRS-Link, interna

3、l DAC.Discrete Analog Output SectionError CorrectionCIRC SystemFrequency Response20 Hz 20 kHz +0/-0.5 dBTotal Harmonic Distortion (THD) 100 dBSignal-to-Noise Ratio 110 dBChannel Separation 100 dBLine-Output Level2.0 VGeneralPower Requirement100-240 V 50/60 HzPower Consumption20 Watts (On)2 Watts (St

4、andby)DimensionsHeight63mm Width440mm Depth332mm Weight3.8 kgDepth measurement includes knobs, buttons and connection jacks.Height measurement includes feet and chassis.All features and specifications are subject to change without notice.Harman Kardon is a registered trademark of Harman Internationa

5、l Industries, Incorporated.Technical Specifications250 Crossways Park Drive, Woodbury, New York 11797 Harman Consumer Group, Inc.: 2, route de Tours, 72500 Chteau-du-Loir, France 2008 Harman Kardon, Incorporated Part 01.00.YS.SM1.E1798harman/kardonHD 980/230 Service ManualPage 2 of 46RadioFans.CN 收音

6、机爱 好者资料库Troubleshooting GuideENGLISHTROUBLE SHOOTING GUIDESYMPTOMNo lights on Front PanelRemote does not appear to operate Front panel lights, but CD does not playPlay indicator lights, but no sound is heardSound skips or stutters during playSound is continually distortedERRORlights up continuously

7、in the displayCAUSE No AC power Power Switch turned off Weak batteries Blocked sensor Disc upside down Poor connections Wrong source connected Disc may be damaged Surface vibrations Incorrect input VariousSOLUTION Make certain AC power cord is plugged into a live outlet. Turn on Power Switch. Instal

8、l fresh batteries, observing polarity indications. Remove obstructions from the front panel sensor or connect aremote sensor to the Remote Injack on the rear panel. Reload disc with label side facing up. Make certain connections are secure and madeto the correct (e.g., CD) input. Select CD source on

9、 receiver or preamp. Try another disc. Isolate the unit from vibration by placing it on afirm surface or move it further away from speakers. Make certain that the analog Audio Outputsof the CD player are connected to a line level audio input, NOT to a digital audio or phono input. Turn the unit off

10、and on again. If the problem persists, turn the ACpower to the CD player off and on.harman/kardonHD 980/230 Service ManualPage 3 of 46harman/kardonHD 980/230 Service ManualPage 4 of 46harman/kardonHD 980/230 Service ManualPage 5 of 46HD980 Component List Serial No.: WA0034-010010344001.00.SJ.HD980E0

11、03plastic partHD980-Front panelHD980-RE0101.00.SJ.HD980E004plastic partHD980-Button IHD980-RE0201.00.SJ.HD980E005plastic partHD980-Button IIHD980-RE0301.00.SJ.HD980E006plastic partHD980-Pedestal underlayHD980-RE0401.00.SJ.HD980E007plastic partHD980-LensHD980-RE0501.00.SJ.HD980E008VFD filterHD980-VFD

12、 filterHD980-RE0601.00.SJ.HD980E009plastic partHD980-Disc tray door HD980-RE0701.00.SJ.HD980E010plastic partHD980-Power indicator lampshadeHD980-RE0801.00.SJ.SK.E008plastic part1000A-IR receiver support 5.5mm0100WJTJHD980E001Metals PartHD980-ChassisHD980-PT010100WJTJHD980E002Metals PartHD980-Rear pa

13、nelHD980-PT020100WJTJHD980E003Metals PartHD980-Top coverHD980-PT030100WJTJHD980E004Metals PartHD980-Front panel bracketHD980-PT040100WJTJHD980E005Metals PartHD980-Aluminum veneerHD980-PT050100WJTJHD980E006Metals PartHD980-Aluminum ally wrap for disc trayHD980-PT0601.00.WJ.TJ.E569aluminium fastener3.

14、5*4001.47.CNT.LJX7E768Connect cable2.54-3Y-3Y-220mm (Be different side)Connect Key board and SMPS board01.47.CNT.ACX.E036Connect cablePower cord with 300mm fixture (EU version)Connect SMPS board and Rear panel01.47.CNT.LJX3E037Connect cable2.0-6Y-6Y-130mm (Be different side) (UL20080 28AWG)Connect L

15、oader and Main board01.47.CNT.LJX3E036Connect cable2.0-5Y-5Y-240mm (Be same side) (LG UL20080 28AWG)Connect Loader and Main board01.47.CNT.LJX7E612Connect cable2.54-2.0-13Y-240mm(Be same side)Connect SMPS board and Main board01.47.CNT.LJX5E333Connect cable70mm(solder one end and grounding piece anot

16、her end)Connect Key board and SMPS board01.47.CNT.LJX5E334Connect cable80mm(solder one end and grounding piece another end)Connect VFD board and Main board01.47.CNT.LJX2E110Connect cable1.25-6Y-6Y-180mm(Be same side)Connect Key board and VFD board01.48.BPX.1.E189flat cable1.25*14P*100mmA(4/8)Connect

17、 Main board and VFD board01.48.BPX.1.E045flat cable0.5*24P*180mmAConnect Loarder and Main board01.47.CNT.CTX.E027Remot control transmission cable3.5+3.5(single channel), black, 1.2m01.15.JX.EDV34850LoaderDV34-850SF-HD850G+DVD-M06Bharman/kardonHD 980/230 Service ManualPage 6 of 46Part numberDescripti

18、onSpecificationLocation.No.Note01.00.FZ.QT.E409PC pieceHD980-H05Between Lens and Front panel02.11HCD08M5563C01Main Board (semi-manufactured goods)HCD08M-5563C012-layers02.15HCD08K5575C01Key Board (semi-manufactured goods)HCD08K-5575C012-layers02.15HCD08K5576C01VFD Board (semi-manufactured goods)HCD0

19、8K-5576C012-layers02.19HCD06P1254C01SMPS Board (semi-manufactured goods)HCD06P-1254C011-layer02.25.HD980Remote Control(manufactured goods)HD980HD980 Component List for Main Board (5563C01) 01.57.R.3.E000JResistor, chip0805-0 5%R8 R9 R14 R26 R54 R57 R60 R64 R71 R74 R79 R80 R85 R18601.57.R.3.E1R0JResi

20、stor, chip0805-15%R67 R68 R69 R7001.57.R.3.E220JResistor, chip0805-225%R27 R29 R12101.57.R.3.E330JResistor, chip0805-335%R20 R114 R129 R13001.57.R.3.E470JResistor, chip0805-475%R103 R104 R105 R107 R110 R11101.57.R.3.E101JResistor, chip0805-1005%R46 R47 R81 R84 R93 R94 R95 R123 R12501.57.R.3.E241JRes

21、istor, chip0805-2405%R43 R44 R96 R12201.57.R.3.E271JResistor, chip0805-2705%R13701.57.R.3.E391JResistor, chip0805-3905%R142 R9701.57.R.3.E561JResistor, chip0805-5605%R33 R49 R5001.57.R.3.E102JResistor, chip0805-1K5%R12 R32 R112 R11301.57.R.3.E152JResistor, chip0805-1.5K5%R52 R4101.57.R.3.E202JResist

22、or, chip0805-2K5%R21 R1901.57.R.3.E222JResistor, chip0805-2.2K5%R62 R56 R58 R8801.57.R.3.E472JResistor, chip0805-4.7K5%R17 R37 R42 R53 R115 R138 R14501.57.R.3.E512JResistor, chip0805-5.1K5%R6501.57.R.3.E622FResistor, chip0805-6.2K1%R2201.57.R.3.E822FResistor, chip0805-8.2K1%R66 R6301.57.R.3.E103JRes

23、istor, chip0805-10K5%(R5) R11 R15 (R16) R18 R34 R35 R36 R38 R39 R48 R72 R75 R77 R83 R86 R87 (R92) R108 R109 R116 R117 R118 R119 R120 R124 R140 R181 R182 R183 R18501.57.R.3.E1182FResistor, chip0805-11.8K1%R30 R2801.57.R.3.E223JResistor, chip0805-22K5%R45 R55 R177 R18001.57.R.3.E333JResistor, chip0805

24、-33K5%R23 R2401.57.R.3.E473JResistor, chip0805-47K5%R59 R61 R18401.57.R.3.E104JResistor, chip0805-100K5%R73 R76 R78 R8201.57.R.3.E105JResistor, chip0805-1M5%R51 R4001.57.R.4.E101FResistor, chip1206-1001%R154 R155 R170 R17101.57.R.4.E331FResistor, chip1206-3301%R147 R148 R152 R157 R161 R162 R163 R164

25、 R168 R173 R178 R17901.57.R.4.E681FResistor, chip1206-6801%R150 R160 R166 R17601.57.R.4.E202FResistor, chip1206-2K1%R153 R156 R169 R172harman/kardonHD 980/230 Service ManualPage 7 of 46HD980 Component List for Main Board (5563C01) P/NDescriptionSpecificationLocation.No.Note01.57.R.4.E272FResistor, c

26、hip1206-2.7K1%R151 R159 R167 R17501.57.R.4.E153FResistor, chip1206-15K1%R89 R90 R91 R149 R16501.57.R.4.E473FResistor, chip1206-47K1%R174 R15801.57.R.4.E475JResistor, chip1206-4.7M5%R14101.57.R.8.EP3304Resistor, thick film chip network0603-33*4 5%RN1 RN2 RN3 RN4 RN5 RN6 RN701.54.CS.3E100N50VCapacitor

27、, multilayer ceramic, chip0805-10P NPO5%/50VC85 C86 C87 C8901.54.CS.3E150N50VCapacitor, multilayer ceramic, chip0805-15P NPO5%/50VC26 C3401.54.CS.3E220N50VCapacitor, multilayer ceramic, chip0805-22P NPO5%/50VC113 C10401.54.CS.3E470N50VCapacitor, multilayer ceramic, chip0805-47P NPO5%/50VC2001.54.CS.

28、3E101N50VCapacitor, multilayer ceramic, chip0805-100P NPO5%/50VC67 C6901.54.CS.3E121N50VCapacitor, multilayer ceramic, chip0805-120P NPO5%/50VC1501.54.CS.3E201N50VCapacitor, multilayer ceramic, chip0805-200P NPO5%/50VC2101.54.CS.3E391N50VCapacitor, multilayer ceramic, chip0805-390P NPO5%/50VC63 C620

29、1.54.CS.3E471N50VCapacitor, multilayer ceramic, chip0805-470P NPO5%/50VC66 C6501.54.CS.3E681N50VCapacitor, multilayer ceramic, chip0805-680P NPO5%/50VC7101.54.CS.3E102X50VCapacitor, multilayer ceramic, chip0805-102 X7R 10%/50VC23 C1301.54.CS.3E332X50VCapacitor, multilayer ceramic, chip0805-332 X7R10

30、%/50VC16 C17 (C24)01.54.CS.3E392X50VCapacitor, multilayer ceramic, chip0805-392 X7R10%/50VC2201.54.CS.3E103X50VCapacitor, multilayer ceramic, chip0805-103 X7R10%/50VC14 C73 C74 C8001.54.CS.3E273Y50VCapacitor, multilayer ceramic, chip0805-273 Y5V-20+80%/50VC1901.54.CS.3E473X50VCapacitor, multilayer c

31、eramic, chip0805-473 X7R10%/50VC6801.54.CS.3E104Y50VCapacitor, multilayer ceramic, chip0805-104 Y5V+80-20%/50V(C1) (C2) (C3) (C4) (C5) (C6) (C7) C8 (C9) (C10) C11 C12 C18 (C25) C27 C28 C30 C35 C38 C39 C40 C41 C42 C43 C44 C45 (C46) (C47) (C48) (C49) C50 C51 (C52) (C53) (C54) (C55) C56 C57 C58 C59 C60

32、 C61 C64 C70 C72 (C76) C77 C79 C81 C82 (C83) C84 C90 C91 C92 C93 C107 C108 C109 C110 C111 C115 C116 C11701.54.CS.3E105Y16VCapacitor, multilayer ceramic, chip0805-105 Y5V-20+80%/16VC32 C33 C36 C37 C7801.54.CS.3E475Y16VCapacitor, multilayer ceramic, chip0805-475 Y5V+80-20%/16VC29 C31harman/kardonHD 98

33、0/230 Service ManualPage 8 of 46HD980 Component List for Main Board (5563C01) P/NDescriptionSpecificationLocation.No.Note01.54.CS.4E681N50VCapacitor, multilayer ceramic, chip1206-680P NPO5%/50VC102 C103 C112 C11401.54.CS.4E222X50VCapacitor, multilayer ceramic, chip1206-222 X7R10%/50VC105 C10601.34.C

34、L.DE10U16VCCapacitor, AL.electrolyticCD110-10UF/16V 5*11CE101.34.CLDE47U25VC1Capacitor, AL.electrolyticCD110-47UF/25V 5*11CE16 CE17 CE18 CE19 CE20 CE34 CE36 CE37 CE38 CE43 CE45 CE4901.34.CLDE47U50VCDCapacitor, AL.electrolyticCD110-47UF/50V 6.3*12CE23 CE24 CE25 CE26 CE27 CE28 CE29 CE30 CE31 CE32 CE33

35、01.34.CLDE100U10VDCapacitor, AL.electrolyticCD110-100UF/10V 5*12CE3 CE4 CE5 CE6 CE7 CE8 CE10 CE11 CE13 CE14 CE21 CE22 CE39 CE40 CE41 CE42 CE44 CE46 CE47 CE48 CE50 CE51 CE52 CE53 CE54 CE55 CE56 CE5701.34.CLDE220U10VDCapacitor, AL.electrolyticCD110-220UF/10V 5*12CE2 CE9 CE12 CE1501.13.L.L.S.E007Induct

36、or, multilayer ceramic, chip0805-10UH SMDL1 L201.13.L.L.S.E362Inductor,WeifengdaWBR453232-220K-R L301.13.L.L.D.E081InductorWB1010-1T1DIP6 Coilcraft01.13.L.Z.ESC100Bead, chip,1206-100FB1 FB2 FB3 FB4 FB5 FB6 FB7 FB8 FB9 FB10 FB1101.41.D.PS.ELL4148DiodeLL4148 SMDD1 D3 D4 D5 D6 D7 D8 D9 D10 D11 D12 D13

37、D14DO-213AA01.41.D.PSE30BQ040Diode30BQ040 SMDD2SMC Schottky diode 3A International Rectifier01.41.D.WS.E6V2Zener diodeZENER 6.2V 0.4WDZ101.42.Q.S.E123MOSFET,DIODESBSS123 SMDMQ31SOT-2301.42.Q.S.E1035Transistor,Panasonic2SA1035 SMDQ11 Q12 Q13 Q15 Q18 Q21 Q22 Q24 Q27 Q30 Q32SOT-2301.42.Q.S.EDTC343Trans

38、istor,ROHMDTC343TKT146 SMDQ17 Q26SOT-2301.42.Q.S.E2406Transistor,Panasonic2SC2406 SMDQ14 Q16 Q19 Q20 Q23 Q25 Q28 Q29SOT-2301.42.Q.S.E1132Transistor,ROHM2SB1132 SMDQ1 Q2MPT301.42.Q.S.E1664TTransistor,ROHM2SD1664T100R SMDQ10 Q8MPT301.42.Q.S.E3018MOSFET,ROHM2SK3018T106 SMDMQ9 MQ7UMT301.42.Q.D.E8050Tran

39、sistorKTC8050-C/P DIPQ6 Q5TO-9201.42.Q.D.E8550TransistorKTC8550-C/P DIPQ3 Q4TO-9201.00.JZ.E33868Quartyz Crystal Unit 33.8688MHZ-49S-20PX101.00.JZ.E225792Crystal Oscillator22.5792MHz/3.3VY1harman/kardonHD 980/230 Service ManualPage 9 of 46HD980 Component List for Main Board (5563C01) P/NDescriptionSp

40、ecificationLocation.No.Note01.44.IC.S.EBF532SIC, ADI, Blackin DSPADSP-BF532SBSTZ400,LQFP176U601.46.IC.E7208GIC, Via, Servo chipVT7208, LQFP216U101.46.ICEKH29LV040IC, KH,Flash MemoryKH29LV040CQC-70G, PLCC32U16firmware burn-in;(Can be replaced by ATEML AT49BV040B-70JU)01.46.IC.E290011IC, AMIC, Flash m

41、emory AMIC A290011TL-70, PLCC32U2firmware burn-in 0146ICHY57V641620EIC, Hynix, SDRAMHY57V641620ETP-7,TSOP54U300146ICEM11B416256IC, EliteMT, DRAMM11B416256A-25J,SOJ40U301.44.IC.S.E5888IC, Rohm, Actuator driverBA5888FP, HSOP-28 U1201.46.IC.E7414IC, Philips, Hex inverting Schmitt trigger74HCT14D,SOIC14

42、U31;01.46.IC.E74HCT245IC,TI,TTL input bufferSN74HCT245PWR,TSSOP20U1401.44.IC.D.EPC817CIC,Sharp,Photoelectric Coupler PC817,DIP4 U2301.44.IC.S.E1117HIC, AAC, LDOAZ1117H-5.0, SOT-223U2901.44.IC.S.E1117IC, AAC, LDOAZ1117H-ADJ, SOT-223U7 U901.44.ICSEA11173V3IC, AAC, LDOAZ1117H-3.3, SOT-223U401.44.IC.S.E

43、LM393IC, ST, ComparatorLM393, SOP8U1101.44.IC.D.E7912IC, Fairchild, Voltage RegulatorL7912,TO-220U1001.44.IC.D.E7812IC, Fairchild, Voltage RegulatorL7812,TO-220U801.46.IC.NJM5534IC, JRC, Operational amplifierNJM5534M,DMP8U26 U2801.44.IC.S.E8740IC, Wolfsonw, DA converterWM8740SEDS, SSOP-28U2701.44.IC

44、.S.E9022IC, NS, Vacuum Fluorescent Display Filament DriverLM9022, 8P, SO8U1301.44.IC.S.E3522IC, AAT, Reset monitor AAT3522IGY-3.08-200-T1, SOT-23U501.43.E009Jack,Sharp,Fiberoptic ouput jack withshutterGP1FAV51TK0FJP101.40.CON.DCZ.E121Jack, IR in/out jackSCJ351P00XS0B00 (BLACK), In-line PackageJP401.

45、40.CON.DCZ.E125Jack, Coaxial outputjackAV1-8.4-6GJP2Antiflaming,Orange, Gold-plated jackharman/kardonHD 980/230 Service ManualPage 10 of 46HD980 Component List for Main Board (5563C01) P/NDescriptionSpecificationLocation.No.Note01.40.CON.DCZ.E046Jack,AudiooutputjackAV2-8.4-1GJP5Antiflaming,Down red

46、& up white, Gold-plated jack01.40.CON.DPH.E024ConnectorPH-5ACN3Antiflaming01.40.CON.DPH.E028ConnectorPH-6ACN4Antiflaming01.40.CON.DPH.E047ConnectorPH-13A CN1Antiflaming01.40.CON.S05.E007FPC connectorFPC-0.5-24P with upward touchCN5SMD0140CONS13FPC2.E00FPC connector1.25-14PCN6Vertical Type01.37.PCB.2

47、.E5563C5563CMain board2-layersHD980 Component List for Key Board (5575C01) 01.57.R.3.E000JResistor, chip0805-0 5%R414 R41501.57.R.3.E241JResistor, chip0805-2405%R41201.57.R.3.E471JResistor, chip0805-4705%R40401.57.R.3.E821JResistor, chip0805-8205%R41301.57.R.3.E472JResistor, chip0805-4.7K5%R402 R403

48、 R406 R407 R408 R409 R410 R41101.57.R.3.E153JResistor, chip0805-15K5%R40101.54.CS.3E220N50VCapacitor, multilayer ceramic, chip0805-22P NPO5%/50VC402 C40301.54.CS.3E104Y50VCapacitor, multilayer ceramic, chip0805-104 Y5V+80-20%/50VC404 C405 C40601.54.CS.3E225Y16VCapacitor, multilayer ceramic, chip0805

49、-225 Y5V-20+80%/16VC40101.34.CL.DE47U16VBCapacitor, AL.electrolyticCD11X-47UF/16V 5*7CE40201.34.CLDE100U10VBCapacitor, AL.electrolyticCD11X-100UF/10V 5*7CE40101.41.D.PS.ELL4148DiodeLL4148 SMDD40101.41.DFDE1L0392A2LED, color is orange & white,DIP1L0392A2W32CM002LED40101.42.Q.S.E8050TransistorKTC8050

50、SMDQ402SOT-2301.42.Q.S.EC8550TransistorKTC8550 SMDQ401SOT-2301.00.JZ.E04000Quartyz Crystal Unit4.000MHZ-49S-22PY40101.46.IC.E78P156IC, ELAN, MCUEM78P156ELM,SOIC18U401firmware burn-in 01.44.IC.D.E0038BIC, IR receiverHS0038BIR40101.39.SW.QC.ED665ATouch switch 6*6*5(80g)K401 K402 K403 K404 K405 K406 K4