Akai-A1211-dvd-sm维修电路原理图.pdf

上传人：cc518

文档编号：155767

上传时间：2024-07-22

格式：PDF

页数：27

大小：5.41MB

《Akai-A1211-dvd-sm维修电路原理图.pdf》由会员分享，可在线阅读，更多相关《Akai-A1211-dvd-sm维修电路原理图.pdf（27页珍藏版）》请在收音机爱好者资料库上搜索。

1、SERVICE MANUALModel:A1211www.akai.ruDVD PLAYERRadioFans.CN 收音机爱好者资料库D V D S e r v i c e Ma n u a l11. CONTENTSTitle2. BLOCK DIAGRAM (CABLE CONNECTIONS)1. CONTERTS21344141516181921222324252326183. POWER SUPPLY4. FUNCTIONAL DESCRITPIONS4.1 DVD MPEG board4.2 Front Panel4.3 SMPS4.4 DVD Driver5.1 SWPS T

2、RANSFORMER5.2 SWPS CONTROLLER IC (TEA1523P)5.3 SWPS PROGAMMABLE SHUNT RE GULATOR (FAIRCHILD TL 431) 5.4 LINE FILTER(2 x 25mH)6.1 POWER SUPPLY6.2 FRONT PANEL6.3 MPEG BOARD6. FAULT TRACING FLOW CHART7. COMPONENT LIST5. DESCRIPTION OF THE INTEGRATED CIRCUITSPageRadioFans.CN 收音机爱好者资料库D V D S e r v i c

3、e Ma n u a l22. BLOCK DIAGRAM (CABLE CONNECTIONS)RadioFans.CN 收音机爱好者资料库33. POWER SUPPLYD V D S e r v i c e Ma n u a l1234ABCD4321DCBATitleNumberRevisionSizeA4Date:Sheet ofFile:Drawn By:12CN1FUSET630mA220VACC10.22/275vC20.22/275VACC3471/275VACC4471/275VACIN4007IN4007IN4007IN4007CE447u/400VR40.47R82.

4、2KC510n/630VR247KC22104/50VC24104D2 ER102R1233R16270R201KD8SB360D1HER157D6FR102D4FR102D5FR102D7HER207D99.1VIC2PC817L3 20uHL420uHL520uHL620uH1 58915181516141314121011T11234L1FB1CE14470u/10VCE910u/50VCE8100u/25VCE710u/50VCE11220u/25VCE3470u/10VCE6100u/50VCE101000u/25VCE222u/50VR10470R172.2KR212.2KR186

5、80R191KR1522R112.2kR9470R76.8KC62.2n/AC400VC10470p/1KVC130.1u/50VC7NCC23104PIC3TL431CC150.1u/50VC17471/1KVC180.1u/50VC14470p/1KVC19102/1KVCE132200u/10VC200.1u/50VC210.1u/50VF1F2- 21V- 12V+12VD5V1.8A100mA3.8V/0.2A 123456Jp4 12345JP2 F2F1- 21VD5VD5VD5V- 12V+12VSW1 RT1 NTC10D- 11V1.10.1A1.2AR141KCE1510

6、u/25VVR1S07K2751/1220VACR64.7KR575KC16680PHGNDHGNDHGNDVCC1GND2RC3REG4AUX5SOURCE6NC7DRAN8IC1TEA1523R33330RadioFans.CN 收音机爱好者资料库4.1 DVD MPEG boardThis board implements the back- end circuitry of a DVD player. It is composed of the following subsystems:* Microcontroller which does main control to all

7、other sub- blocks of the system including user interface, driver interface, audio/video output.* Vaddis A/V Decoder IC decodes the bitstream coming from the DVD front- end drive, and Optionally performs audio and video effects.* Audio CodecSPCA8200AAUD2AUD1AUD0DVD- DSP I/FCD- DSP I/FSPDIF16MSDRAM2-C

8、HANNELAUDIOCODECCntr/LFECVBSRGBRear L/RRear L/RSERIALEPROM4M FLASH44. FUNCTIONAL DESCRIPTIONSD V D S e r v i c e Ma n u a lRadioFans.CN 收音机爱好者资料库5D V D S e r v i c e Ma n u a lRadioFans.CN 收音机爱好者资料库6D V D S e r v i c e Ma n u a lRadioFans.CN 收音机爱好者资料库7D V D S e r v i c e Ma n u a lRadioFans.CN 收音

9、机爱好者资料库8D V D S e r v i c e Ma n u a lRadioFans.CN 收音机爱好者资料库 9D V D S e r v i c e Ma n u a lRadioFans.CN 收音机爱好者资料库1 0D V D S e r v i c e Ma n u a lRadioFans.CN 收音机爱好者资料库1 1D V D S e r v i c e Ma n u a lRadioFans.CN 收音机爱好者资料库1 2D V D S e r v i c e Ma n u a lRadioFans.CN 收音机爱好者资料库1 3D V D S e r

10、v i c e Ma n u a lRadioFans.CN 收音机爱好者资料库The front panel I/O.4.2 Front PanelA.1 4123456ABCD654321DCBATitleNumberRevisionSizeBDate:26- Jun- 2004SheetofFile:DrawnBy:R210KR310KR110KE1220U/10V65432112S112S212S3RGND5VREMOTEREM5VREMCLKSTBDATADATA CLKSTB5VD V D S e r v i c e Ma n u a lRadioFans.CN 收音机爱好者资

11、料库4.3 SMPS6 Pin, Data Connector Pin AssignmentsPIN123456NAMEREMDATACLKSTBGNDVCCI/OIIOOODESCRIPTIONFront Panel Data inputIR sensor interruptFront Panel chip selectFront Panel clockFront Panel Data outputThe mains power(220VAC) fed from N1 is filtered through C1, L1, C2 and L2 then rectified by D1, D2

12、, D3 and D4 and generates an output at 300VDC. This 300VDC fed to T1 (pin2, pin4) which connects to TEA1523P(pin2), then TEA1523P will automatically generate a 50KHz square waveform, this 50KHz square waveform controls the ON/OFF between TEA1523P pin2 and the ground. In normal condition, T1 primary

13、(between pin2 and pin4) will create a 50KHz square waveform which is controlled by TEA1523P, this signal then fed to T1 and generates 2 different potential voltages of 12V and 5V between pin17, pin14 and pin16, pin14 respectively. The 12VDC and 5VDC then rectified by D7, D8, D9 and then filtered by

14、L3, L4, L5, C9, C10 and C11. The feedback voltage is controlled by Ic3 TL431 and IC2 PC817. When the output voltage is higher than 5V, the voltage at TL431(2.5V) is compared with R10 and send out a signal to 5L0380R, the output square waveform then will change to adjust the output voltage, this acts

15、 as a voltage stabilizer.4.2.1 Front Panel Interface1 5D V D S e r v i c e Ma n u a lRadioFans.CN 收音机爱好者资料库1 6D V D S e r v i c e Ma n u a lSONY310 .4.44.4.1 Drive cell:adopt RF- 300CA- 11450 electricity machine 4.2 Electricity machine work voltage is 3V- 5.9V 4.3 General work voltage is 3.3V- 5V 4

16、.4 Unilateralism(com or go) move time:1.5S(add 5V voltage) 4.5 In 5 C- 10 C work current is 120mA4.5 Testing condition 5.1 Position: level placed 5.2 environment: temperature 22+2 C Humidity 50+5% 5.3 Turnover storehouse voltage:5V+0.5V 5.4 Standard DVD lens testing frock 5.5 Standard DVD testing di

17、sh 4.3.1 Adopt small lens: can adopt act lensElectric specification RadioFans.CN 收音机爱好者资料库WINDINGPrimary InductancePIN. NO2- 4INDUCTANCE1.5mH 10%DESCRIPTION0.50W2. ELECTRICAL CHARACTERISTICS2.1 STATIC CHARACTERISTICS2.2 WITHSTANDING VOLTAGE2.3 INSULATION RESISTANCE2.4 ELECTRICAL CHARACTERISTICSMain

18、 Voltage Operations:Main Drop- out Voltage:Mains STart- up Voltage:Operating Frequency:90Vac - 265 VacMax. 90 VacMax. 90 Vac60 KHz1. Primary Leakage inductance (Pin 2- 4) L1.5mHThe transformer shall sithstanding a voltage of 4 Kvms for 1 minute and 1 mA between primary and seconday winding and also

19、2 Kvms for 1 minute and 1 mA between primary winding with core and secondary winding with core.The insulation resistance shall be ore than 500M between primary and seconday windings when the applied voltage 300 Vdc for 1 minute1. Before taking measurement Pp01 will be to give 5.0Vdc on 5.0Vdc line a

20、t Minimum setting of controls and a mains voltage 220 Vac.2. Before taking a measurement, DVD set should be working at least 5 minutes on Normal condition1 85.1 SMPS TRANSFORMER5. DESCRIPTION OF THE INTEGRATED CIRCUITS1. GENERAL INFORMATIOND V D S e r v i c e Ma n u a lRadioFans.CN 收音机爱好者资料库1 9D V

21、D S e r v i c e Ma n u a l5.3 SWPS CONTROLLER IC (TEP1523A)RadioFans.CN 收音机爱好者资料库D V D S e r v i c e Ma n u a l2 05.3 SWPS CONTROLLER IC (TEP1523A)RadioFans.CN 收音机爱好者资料库* Programmable output voltage to 36volts* Low dynamic output impedance 0.20 typical* Sink current capability of 1.0 to 100mA* Equ

22、ivalent full- range temperature coefficient of 50 ppm typical* Temperature compensated for operation over full rated operating temperature range* Low output noise voltage* Fast turn- on responseThe TL 431/TL 431A are three- terminal adjustable regulator series with a guaranteed thermal stability ove

23、r applicable temperature ranges. The output voltage may be set to any value between VREF (approximately 2.5 volts) and 36 volts with two external resistors. These devices have a gypical dynamic output impedanceof 2.0W Active oupput circuity provides a very sharp turn- on characteristic making these

24、devices excel lent replacement for zener diodes in many applicationsFeaturesDescriptionAbsolute maximum ratingsRecommended Operating conditionsParameterCathode voltageCathode CurrentValueValueValueVKAIKASymbolVMAUnit-36VREF-1001.0ParameterCathode voltageCathode current Range (Continuous)Reference In

25、put Current RangeOperating Temperature RangeStorage Temperature RangePower dissipationD,Z Sffix PackageN Suffix PackageValueVKAIKAIREFPDTOPRTSTGSymbolVMAIMAMWMWUnit37- 100 +1500.05 +107701000- 25 +85- 65 +150TO- 9211. Ref 2. Arode 3. Cathode2.5 VrefANODECATHODE(K)ANODE(A)CATHODEREFERENCEREFERENCE(R)

26、2 15.4 SMPS PROGRAMMABLE SHUNT REGULATOR (FAIRCHILD TL 431)D V D S e r v i c e Ma n u a lRadioFans.CN 收音机爱好者资料库Inductance: L1- 2=L3- 4- 30mH - 15% - +20%Resistance: R 1- 2 = R 3- 4 = 1.0 ohm (max)Rated current: Irms = 0.50 A (F= 1 Khz V= 1 Vms)L 1- 2 = L 3- 4 100+/- 20%uH NOTESELECTRICAL DATACIRCUI

27、T DIAGRAMLEAKAGE INDUCTANCE14232 25.5 LINE FILTER (2 X 25mH)D V D S e r v i c e Ma n u a lRadioFans.CN 收音机爱好者资料库NO PICTURECHECK JP4ConnectorCHECKVoltages Present?REPLACE Ip02,FUSECHECKMPEG BOARDCHECK MPEG BOARDREPLACE CONNECT CABLEREPLACE POWER PCBYESYESNONOOKNOOKVoltages Present?FUSEDp02REPLACE2 3

28、6.1 POWER SUPPLY6. FAULT TRACING FLOW CHARTD V D S e r v i c e Ma n u a lRadioFans.CN 收音机爱好者资料库2 46.2 FRONT PANELNO PICTURENO FRONTPANEL DISPPOWERBOARDCHECKCHECKREPLACEMAINBOARDCN VOLTAGEIR(5V)RECEIVERCn4 PIN2: RCPRESSNONO SIGNALYESSIGNALDATAPRESS ANY KEYON RC ANDOBSERVEOPEN/CLOSEON RCMPEG2REPLACEM

29、AINBOARDD V D S e r v i c e Ma n u a lRadioFans.CN 收音机爱好者资料库NO PICTURENO AUDIOPOWERBOARDCHECKINSERT A CD FORAUDIO TEST ANDPRESS PLAYREPLACEMPEGBOARDCHECKJP4CHECK CN6LOADERAUDIO OUTPUTRUNING? J3(RGB&CVBS RUNING?)NONONONOYESYES2 5VOLTAGE(5V,12V)?6.3 MPEG BOARD D V D S e r v i c e Ma n u a lRadioFans.

30、CN 收音机爱好者资料库2 67. COMPONENT LISTC A B L EP O S N OT E L R A C O D ED E S C R I P T I O N6Pin,2.0mmPitch to 6Pin,2.0mmPitch VH,180mm,UL246826AWG5Pin,2.0mmPitch to 5Pin,2.0mmPitch PH,150mm,UL246826AWG6Pin,2.54mmPitch to 6Pin,2.54mmPitch VH,250mm,UL246826AWG5Pin,2.54mmPitch,VH to MPEG Power Socket,280

31、mm,UL100720AWGPower Cable,180m,VDEAV Cable,1.5mS WP SP O S N OT E L R A C O D ED E S C R I P T I O NC1104K M 275VX2 335 5 MKPC2104K M 275VX2 335 5 MKPC3471K M 275VX1,Y1 335 C4C5Ceramic Cap.,1KV- 101,KC6Ceramic Cap.,1KV 103M 10%C7Cap.,50V 473,10%C8C9Ceramic Cap.,63v 104,10%CA1CE4Elec. Cap.,400V- 47UF

32、,M,18X27mmCE2Elec. Cap.,50V- 22UF,M,5X11.5mmCE6Elec. Cap.,35V- 220UF,M,8X11.5mmCE11Elec. Cap.,35V- 220UF,M,8X11.5mmCE10CE13Elec. Cap.,10V- 2200UF,M,10X20mmCE14Elec. Cap.,16V- 220UF,M,6.3X11mmCE15Elec. Cap.,10V- 100UF,M,5X11mmBR1Rectifier Diode,1N4007,DO- 41BR2Rectifier Diode,1N4007,DO- 41BR3Rectifie

33、r Diode,1N4007,DO- 41BR4Rectifier Diode,1N4007,DO- 41D1Rectifier Diode,HER105,DO- 41D2Switch Fr102,DO- 41D3Rectifier Diode,FR102,DO- 27D4Rectifier Diode,FR104,DO- 27D5Rectifier Diode,FR104,DO- 27D6Rectifier Diode,FR157,DO- 41D7Rectifier Diode,SR360,DO- 41D8Zener Diode,9.1VFHBFB, 3.5mm*4.7mm*0.8mmFUS

34、EFuse,T1AL250V,5*20mm,GlassIC- 1IC,TEA1523P DIP8IC- 2IC,PC817BCeramic Ceramic Cap.,63V 104,10% Elec. Cap.,25V- 1000UF,M,10X20mmIC- 3IC,TL431C,TO- 92J- 1Jumper,Diameter=0.6mm,L=10mmJ- 2Jumper,Diameter=0.6mm,L=5mmJ- 3Jumper,Diameter=0.6mm,L=7.5mmD V D S e r v i c e Ma n u a lCeramic Cap., 471K M 275VX

35、1,Y1 335 Ceramic Cap., 222 M 400VX1,Y1 335 Ceramic Cap., RadioFans.CN 收音机爱好者资料库2 7P O S N OT E L R A C O D ED E S C R I P T I O NL- 1Filter,ET20L- 2Filter,SG01183L- 3Radial Choke Inductor,15uH 10%L- 4Radial Choke Inductor,15uH 10%L- 5Radial Choke Inductor,15uH 10%Cn1Conn.,2Pin,VH,3.96mm,SCn2Conn.,2

36、Pin,VH,3.96mm,SC0N1Conn.,5Pin,2.54mm,SCON2Conn.,6Pin,2.54mm,SN4Conn.,4Pin,2.54mm,SPCBPCB,POW389LR1Carbon Film Res.,2W- 56K,JR2Carbon Film Res.,1/4W- 22E,JR3Carbon Film Res.,1/4W- 330E,JR4Carbon Film Res.,1/4W- 1K,JR5Carbon Film Res.,1/4W- 1M,JR6Carbon Film Res.,1/4W- 10K,JR7Carbon Film Res.,1/4W- 10

37、K,JR8Carbon Film Res.,1/4W- 10K,JR9Carbon Film Res.,1/4W- 1E,JR10TR- 1NTC 10D- 11T1Transformer,KB- 464- 3089 F R O N T P A N E LP O S N OT E L R A C O D ED E S C R I P T I O NCD1Elec. Cap.,220uF- 10V,5*7mm,CD11,MCarbon Film Res.,1/4W- 680E,JRD1RD2Carbon Film Res.,1/8W,10K,JRD3Carbon Film Res.,1/8W,10K,JREM01Remote Receiver,GPIUM271RKSW1Tact Switch,6*6*5mmSW2Tact Switch,6*6*5mmSW3Tact Switch,6*6*5mmD V D S e r v i c e Ma n u a lCarbon Film Res.,1/8W,10K,JRadioFans.CN 收音机爱好者资料库