HarmanKardon-AVR355.230-avr-sm维修电路图 手册.pdf

harman/kardon Service Manual AVR 355/230 7 x 65W 7.1 CHANNEL A/V RECEIVER Released EU2008 harman/kardon, Inc. Rev 0, 09/2008 250 Crossways Park Dr. Woodbury, New York, 11797 ESD WARNING 2 BASIC SPECIFICATIONS 3 TROUBLESHOOTING GUIDE 4 PROCESSOR RESET 4 REMOTE RESET 5 PACKAGE LIST AND PARTS 6 DISASSEMBLY 7 EXPLODED VIEW AND PARTS 8 ELECTRICAL PARTS LIST 9 SEMICONDUCTOR PINOUTS 56 PCB DRAWINGS 101 BLOCK DIAGRAM 109 WIRING DIAGRAM 110 AMP BIAS ADJUSTMENT 111 SCHEMATIC DIAGRAMS 112 CONTENTS harman/kardonAVR 355/230 Service Manual Page 1 of 125 RadioFans.CN Eachprecautioninthismanualshouldbefollowedduringservicing. Components identified with the IEC symbolin the parts list are special significance to safety. When replacing a component identified with , use only the replacement parts designated, or parts with the same ratings or resistance, wattage, or voltage that are designated in the parts list in this manual. Leakage-current or resistance measurements must be made to determine that exposed parts are acceptably insulated from the supply circuit before retuming the product to the customer. Some semiconductor (solid state) devices can be damaged easily by static electricity. Such components commonly are called Electrostatically Sensitive (ES) Devices. Examples of typical ES devices are integrated circuits and some field effect transistors and semiconductor chip components. The following techniques should be used to help reduce the incidence of component damage caused by static electricity. 1. Immediately before handling any semiconductor component or semiconductor-equipped assembly, drain off any electrostatic charge on your body by touching a known earth ground. Alternatively, obtain and wear a commercially available discharging wrist strap device, which should be removed for potential shock reasons prior to applying power to the unit under test. 2. After removing an electrical assembly equipped with ES devices, place the assembly on a conductive surface such as aluminum foil, to prevent electrostatic charge build-up or exposure of the assembly. 3. Use only a grounded-tip soldering iron to solder or unsolder ES devices. 4. Use only an anti-static solder removal device. Some solder removal devices not classified as anti-static can generate electrical charges sufficient to damage ES devices. 5. Do not use freon-propelled chemicals. These can generate electrical change sufficient to damage ES devices. 6. Do not remove a replacement ES device from its protective package until immediately before you are ready to install it. (Most replacement ES devices are packaged with leads electrically shorted together by conductive foam, aluminum foil or comparable conductive material.) 7. Immediately before removing the protective material from the leads of a replacement ES device, touch the protective material to the chassis or circuit assembly into which the device will be installed. Be sure no power is applied to the chassis or circuit, and observe all other safety precautions. 8. Minimize bodily motions when handling unpackaged replacement ES devices. (Otherwise harmless motion such as the brushing together or your clothes fabric or the lifting of your foot from a carpeted floor can generate static electricity sufficient to damage an ES devices. CAUTION : harman/kardonAVR 355/230 Service Manual Page 2 of 125 RadioFans.CN 2 Technical Specifications Audio Section Stereo Mode Continuous Average Power (FTC): 70 Watts per channel, 20Hz - 20 kHz < 0.07% THD, both channels driven into 8 ohms 7 Channel Surround Modes Power Per Individual Channel, with all channels driven Front L MM 200V DESCRIPTION The 74LCX32 is a low voltage CMOS QUAD 2-INPUT OR GATE fabricated with sub-micron silicon gate and double-layer metal wiring C2MOS technology. It is ideal for low power and high speed 3.3V applications; it can be interfaced to 5V signal environment for inputs. It has same speed performance at 3.3V than 5V AC/ACT family, combined with a lower power consumption. All inputs and outputs are equipped with protection circuits against static discharge, giving them 2KV ESD immunity and transient excess voltage. 74LCX32 LOW VOLTAGE CMOS QUAD 2-INPUT OR GATE WITH 5V TOLERANT INPUTS Figure 1: Pin Connection And IEC Logic Symbols Table 1: Order Codes PACKAGET CDIN is the input data line for the control port interface in SPI mode. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 1718 1920 212223242526272829303132 64636261 605958575655545352515049 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 CX_SDIN1 SAI_SCLK SAI_LRCK VD DGND VLC SCL/CCLK SDA/CDOUT AD1/CDIN AD0/CS INT RST AINR- AINR+ AINL+ AINL- VQ FILT+ REFGND AOUTB4- AOUTB4+ AOUTA4+ AOUTA4- VA AGND AOUTB3- AOUTB3+ AOUTA3+ AOUTA3- AOUTB2- AOUTB2+ AOUTA2+ AOUTA2- AOUTB1- AOUTB1+ AOUTA1+ AOUTA1- MUTEC AGND VARX RXP7/GPO7 RXP6/GPO6 RXP5/GPO5 RXP4/GPO4 RXP3/GPO3 RXP2/GPO2 RXP1/GPO1 LPFLT RXP0 TXP VD DGND VLS SAI_SDOUT RMCK CX_SDOUT ADCIN2 ADCIN1 OMCK CX_LRCK CX_SCLK CX_SDIN4 CX_SDIN3 CX_SDIN2 CS42528 harman/kardonAVR 355/230 Service Manual Page 63 of 125 RadioFans.CN harman/kardonAVR 355/230 Service Manual Page 64 of 125 RadioFans.CN ESIESIESIESI 5 Rev. 0A May 25, 2006 ES29LV320E Excel Semiconductor inc. CONNECTION DIAGRAM A15 A14 A13 A12 A11 A10 A9 A8 A19 A20 WE# RESET# NC WP#/ACC RY/BY# A18 A17 A7 A6 A5 A4 A3 A2 A1 A16 BYTE# Vss DQ15/A-1 DQ7 DQ14 DQ6 DQ13 DQ5 DQ12 DQ4 Vcc DQ11 DQ3 DQ10 DQ2 DQ9 DQ1 DQ8 DQ0 OE# Vss CE# A0 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 48-Pin Standard TSOP ES29LV320E 48-Ball FBGA 6 x 8 mm) (Top View, Balls Facing Down) A13A12A14 A15A16 DQ15/ Vss A9 WE# OE#CE# A0A1A2A4 WP#/ A11DQ7DQ14 DQ13DQ6 NCA19 A18 DQ5 A20 A5 DQ2 DQ0DQ8DQ9DQ1 DQ10DQ11DQ3 DQ12 VccDQ4 A3 A10 C D E F G H J K 7 6 5 4 3 2 BYTE# A-1 A8 RESET# RY/ A7A17A6 Vss ACCBY# harman/kardonAVR 355/230 Service Manual Page 65 of 125 RadioFans.CN harman/kardonAVR 355/230 Service Manual Page 66 of 125 RadioFans.CN harman/kardonAVR 355/230 Service Manual Page 67 of 125 RadioFans.CN harman/kardonAVR 355/230 Service Manual Page 68 of 125 RadioFans.CN harman/kardonAVR 355/230 Service Manual Page 69 of 125 RadioFans.CN 2001. 6. 281/7 SEMICONDUCTOR TECHNICAL DATA KIA278R05PIKIA278R15PI BIPOLAR LINEAR INTEGRATED CIRCUIT Revision No : 3 4 TERMINAL 2A OUTPUT LOW DROP VOLTAGE REGULATOR The KIA278R? Series are Low Drop Voltage Regulator suitable for various electronic equipments. It provides constant voltage power source with TO-220 4 terminal lead full molded PKG. The Regulator has multi function such as over current protection, overheat protection and ON/OFF control. FEATURES ?2.0A Output Low Drop Voltage Regulator. ?Built in ON/OFF Control Terminal. ?Built in Over Current Protection, Over Heat Protection Function. LINE UP A F J L D M 1234 1 2 3 4 DC INPUT (V ) DC OUTPUT (V ) GND ON/OFF CONTROL IN O DIMMILLIMETERS TO-220IS-4 10.00 0.20 15.00 0.20 2.70 0.20 0.60 0.10 3.20 0.20 3.50 0.10 A B C D E F G15.70 0.20 0.40 0.10H 14.3+0.2/-0.1 1.45 0.10 1.00 0.10 2.54 4.50 0.20 7.5 0.1 1.50 0.10 J K L M N O P S R 8 5 B C E G H L VV U T K N O RS P +_ +_ +_ 1.30 0.1 3-1.00 0.1 1.30 0.1 T U V +_ +_ +_ +_ +_ +_ +_ +_ +_ +_ +_ +_ +_ MAXIMUM RATING (Ta=25?) ITEMOUTPUT VOLTAGE (Typ.)UNIT KIA278R05PI5 V KIA278R06PI6 KIA278R08PI8 KIA278R09PI9 KIA278R10PI10 KIA278R12PI12 * KIA278R15PI15 CHARACTERISTICSYMBOLRATINGUNITRemark Input VoltageVIN35V- ON/OFF Control VoltageVC35V- Output CurrentIO2A- Power Dissipation 1Pd11.5WNo heatsink Power Dissipation 2Pd215Wwith heatsink Junction TemperatureTj125?- Operating TemperatureTopr-20?80?- Storage TemperatureTstg-30?125?- Soldering Temperature (10sec)Tsol260?- * Note) * : Under Development. harman/kardonAVR 355/230 Service Manual Page 70 of 125 RadioFans.CN 2005. 2. 11/7 SEMICONDUCTOR TECHNICAL DATA KIA378R05PIKIA378R15PI BIPOLAR LINEAR INTEGRATED CIRCUIT Revision No : 3 4 TERMINAL 3A OUTPUT LOW DROP VOLTAGE REGULATOR The KIA378RSeries are Low Drop Voltage Regulator suitable for various electronic equipments. It provides constant voltage power source with TO-220IS-4 terminal lead full molded PKG. The Regulator has multi-function such as over current protection, overheat protection and ON/OFF control. FEATURES 3.0A Output Low Drop Voltage Regulator. Built in ON/OFF Control Terminal. Built in Over Current Protection, Over Heat Protection Function. LINE UP A F J L D M 1234 1 2 3 4 DC INPUT (V ) DC OUTPUT (V ) GND ON/OFF CONTROL IN O DIMMILLIMETERS TO- 220IS- 4 10.00 0.20 15.00 0.20 2.70 0.20 0.60 0.10 3.20 0.20 3.50 0.10 A B C D E F G15.70 0.20 0.40 0.10H 14.3+0.2/- 0.1 1.45 0.10 1.00 0.10 2.54 4.50 0.20 7.5 0.1 1.50 0.10 J K L M N O P S R 8 5 B C E G H L VV U T K N O RS P +_ +_ +_ 1.30 0.1 3- 1.00 0.1 1.30 0.1 T U V +_ +_ +_ +_ +_ +_ +_ +_ +_ +_ +_ +_ +_ MAXIMUM RATINGS (Ta=25) ITEMOUTPUT VOLTAGE (Typ.)UNIT KIA378R05PI5 V KIA378R06PI6 KIA378R08PI8 KIA378R09PI9 KIA378R10PI10 KIA378R12PI12 KIA378R15PI15 CHARACTERISTICSYMBOLRATINGUNITRemark Input VoltageVIN35V- ON/OFF Control VoltageVC35V- Output CurrentIO3A- Power Dissipation 1Pd11.5W No heatsink Power Dissipation 2Pd215W with heatsink Junction TemperatureTj-40150- Operating TemperatureTopr-3085- Storage TemperatureTstg-40150- Soldering Temperature (10sec)Tsol260- harman/kardonAVR 355/230 Service Manual Page 71 of 125 RadioFans.CN harman/kardonAVR 355/230 Service Manual Page 72 of 125 RadioFans.CN harman/kardonAVR 355/230 Service Manual Page 73 of 125 RadioFans.CN harman/kardonAVR 355/230 Service Manual Page 74 of 125 RadioFans.CN harman/kardonAVR 355/230 Service Manual Page 75 of 125 RadioFans.CN harman/kardonAVR 355/230 Service Manual Page 76 of 125 RadioFans.CN harman/kardonAVR 355/230 Service Manual Page 77 of 125 RadioFans.CN Pin Assignment (DIP16/MFP16) No. 6037-2/8 LC72723, LC72723M Block Diagram harman/kardonAVR 355/230 Service Manual Page 78 of 125 RadioFans.CN ESMTESMT M12L16161A Elite Semiconductor Memory Technology Inc. Publication Date : May. 2005 Revision : 2.4 2/30 SDRAM 512K x 16Bit x 2Banks Synchronous DRAM FEATURES ? JEDEC standard 3.3V power supply ? LVTTL compatible with multiplexed address ? Dual banks operation ? MRS cycle with address key programs - CAS Latency (2 C o n n e c t t o C N66( S L) , C N61( C EN) , C N64( S R ) , C N63( FL) , C N65( S BL NO. 1 2 3 S u r r o u n d Le f t S u r r o u n d R i g h t 4 5 C h a n n e l Fr o n t Le f t Fr o n t R i g h t C e n t e r A d j u s t f o rA d j u s t me n t 2 5. 9 2 mV ( 5%) C N65 C N64 2 5. 9 2 mV ( 5%) 2 5. 9 2 mV ( 5%) 2 5. 9 2 mV ( 5%) 2 5. 9 2 mV ( 5%) C N63 C N62 C N61 C N66 C N67 6S u r r o u n d Ba c k Le f t2 5. 9 2 mV ( 5%) 2 5. 9 2 mV ( 5%) S u r r o u n d Ba c k R i g h t7 A MP L I F I E R S E C T I O N B I A S A D J U S T ME N T M e a s u r e me n t c o n d i t i o n . No i n p u t s i g n a l o r v o l u me p o s i t i o n i s mi n i mu m. S t a n d a r d v a l u e . I d e a l c u r r e n t = 48 mA ( 5%) . I d e a l DC Vo l t a g e = 2 5. 9 2 mV ( 5%) DC VOLTM ETER ; C o n n e c t t o C N66( S L) , C N61( C EN) , C N64( S R ) , C N63( FL) , C N65( S BL NO. 1 2 3 S u r r o u n d Le f t S u r r o u n d R i g h t 4 5 C h a n n e l Fr o n t Le f t Fr o n t R i g h t C e n t e r A d j u s t f o rA d j u s t me n t 2 5. 9 2 mV ( 5%) C N65 C N64 2 5. 9 2 mV ( 5%) 2 5. 9 2 mV ( 5%) 2 5. 9 2 mV ( 5%) 2 5. 9 2 mV ( 5%) C N63 C N62 C N61 C N66 C N67 6S u r r o u n d Ba c k Le f t2 5. 9 2 mV ( 5%) 2 5. 9 2 mV ( 5%) S u r r o u n d Ba c k R i g h t7 CC N 66N 66CC N 61N 61C N 64C N 64CC N 63N 63CC N 65N 65CC N 67N 67CC N 62N 62 + +- - D C E V M CUP12026* (MAIN PCB) (AVR254,255,354,355),CN62(FR),CN67(SBR) VR81 VR82 VR83 VR84 VR85 VR87VR86 harman/kardonAVR 355/230 Service Manual Page 111 of 125 RadioFans.CN harman/kardonAVR 355/230 Service Manual Page 112 of 125 RadioFans.CN harman/kardonAVR 355/230 Service Manual Page 113 of 125 RadioFans.CN harman/kardonAVR 355/230 Service Manual Page 114 of 125 RadioFans.CN harman/kardonAVR 355/230 Service Manual Page 115 of 125 RadioFans.CN harman/kardonAVR 355/230 Service Manual Page 116 of 125 RadioFans.CN A V R 3 5 5 i n p u t _ 0 2 0 8 . s c h - 1 - F r i F e b 0 8 1 5 : 5 4 : 2 6 2 0 0 8 harman/kardonAVR 355/230 Service Manual Page 117 of 125 RadioFans.CN A V R 3 5 5 i n p u t _ 0 2 0 8 . s c h - 2 - F r i F e b 0 8 1 5 : 5 4 : 5 2 2 0 0 8 harman/kardonAVR 355/230 Service Manual Page 118 of 125 RadioFans.CN A V R 3 5 5 i n p u t _ 0 2 0 8 . s c h - 3 - F r i F e b 0 8 1 5 : 5 5 : 2 9 2 0 0 8 harman/kardonAVR 355/230 Service Manual Page 119 of 125 RadioFans.CN 080121 AVR355 VIDEO sample.sch-1 - Sat Feb 02 16:43:21 2008 harman/kardonAVR 355/230 Service Manual Page 120 of 125 RadioFans.CN 080121 AVR355 VIDEO sample.sch-2 - Sat Feb 02 16:43:48 2008 harman/kardonAVR 355/230 Service Manual Page 121 of 125 RadioFans.CN harman/kardon AVR 355/230 Service Manual Page 122 of 125 RadioFans.CN harman/kardonAVR 355/230 Service Manual Page 123 of 125 RadioFans.CN harman/kardonAVR 355/230 Service Manual Page 124 of 125 RadioFans.CN 080119 AVR255_355 FRONT_LPP.sch-1 - Sat Feb 02 16:52:21 2008 harman/kardonAVR 355/230 Service Manual Page 125 of 125 RadioFans.CN