Yamaha-RXV-563-Service-Manual-Part-1电路原理图.pdf
SERVICE MANUAL 101086 IMPORTANT NOTICE This manual has been provided for the use of authorized YAMAHA Retailers and their service personnel. It has been assumed that basic service procedures inherent to the industry, and more specifically YAMAHA Products, are already known and understood by the users, and have therefore not been restated. WARNING:Failure to follow appropriate service and safety procedures when servicing this product may result in personal injury, destruction of expensive components, and failure of the product to perform as specified. For these reasons, we advise all YAMAHA product owners that any service required should be performed by an authorized YAMAHA Retailer or the appointed service representative. IMPORTANT:The presentation or sale of this manual to any individual or firm does not constitute authorization, certification or recognition of any applicable technical capabilities, or establish a principle-agent relationship of any form. The data provided is believed to be accurate and applicable to the unit(s) indicated on the cover. The research, engineering, and service departments of YAMAHA are continually striving to improve YAMAHA products. Modifications are, therefore, inevitable and specifications are subject to change without notice or obligation to retrofit. Should any discrepancy appear to exist, please contact the distributors Service Division. WARNING:Static discharges can destroy expensive components. Discharge any static electricity your body may have accumulated by grounding yourself to the ground buss in the unit (heavy gauge black wires connect to this buss). IMPORTANT:Turn the unit OFF during disassembly and part replacement. Recheck all work before you apply power to the unit. P.O.Box 1, Hamamatsu, Japan 2008 All rights reserved. This manual is copyrighted by YAMAHA and may not be copied or redistributed either in print or electronically without permission. 08.03 I CONTENTS TO SERVICE PERSONNEL . 2 FRONT PANELS. 34 REAR PANELS . 58 REMOTE CONTROL PANEL . 9 SPECIFICATIONS. 1012 INTERNAL VIEW . 13 DISASSEMBLY PROCEDURES . 1416 UPDATING FIRMWARE . 1721 SELF DIAGNOSIS FUNCTION (DIAG) . 2244 DISPLAY DATA . 45 IC DATA . 4659 BLOCK DIAGRAMS . 6165 PRINTED CIRCUIT BOARDS. 6679 PIN CONNECTION DIAGRAMS. 8081 SCHEMATIC DIAGRAMS. 8396 REPLACEMENT PARTS LIST . 97109 REMOTE CONTROL. 110112 Advanced setup . 113 AV RECEIVER/AV AMPLIFIER RX-V563/HTR-6150/ DSP-AX563 RX-V563/HTR-6150/ DSP-AX563 2 RX-V563/HTR-6150/DSP-AX563 RX-V563/HTR-6150/ DSP-AX563 WALL OUTLET EQUIPMENT UNDER TEST AC LEAKAGE TESTER OR EQUIVALENT INSULATING TABLE I TO SERVICE PERSONNEL 1. Critical Components Information Components having special characteristics are marked s and must be replaced with parts having specifications equal to those originally installed. 2. Leakage Current Measurement (For 120V Models Only) When service has been completed, it is imperative to verify that all exposed conductive surfaces are properly insulated from supply circuits. GMeter impedance should be equivalent to 1500 ohms shunted by 0.15F. GLeakage current must not exceed 0.5mA. GBe sure to test for leakage with the AC plug in both polarities. For U model “CAUTION” “F3401, F3402: FOR CONTINUED PROTECTION AGAINST RISK OF FIRE, REPLACE ONLY WITH SAME TYPE 6A, 125V FUSE.” For C model CAUTION F3401, F3402: REPLACE WITH SAME TYPE 6A, 125V FUSE. ATTENTION F3401, F3402: UTILISER UN FUSIBLE DE RECHANGE DE MME TYPE DE 6A, 125V. All of the P.C.B.s installed in this unit and solder joints are soldered using the lead free solder. Among some types of lead free solder currently available, it is recommended to use one of the following types for the repair work. Sn + Ag + Cu (tin + silver + copper) Sn + Cu (tin + copper) Sn + Zn + Bi (tin + zinc + bismuth) Caution: As the melting point temperature of the lead free solder is about 30C to 40C (50F to 70F) higher than that of the lead solder, be sure to use a soldering iron suitable to each solder. About lead free solder WARNING: CHEMICAL CONTENT NOTICE! This product contains chemicals known to the State of California to cause cancer, or birth defects or other reproductive harm. DO NOT PLACE SOLDER, ELECTRICAL/ELECTRONIC OR PLASTIC COMPONENTS IN YOUR MOUTH FOR ANY REASON WHAT SO EVER! Avoid prolonged, unprotected contact between solder and your skin! When soldering, do not inhale solder fumes or expose eyes to solder/flux vapor! If you come in contact with solder or components located inside the enclosure of this product, wash your hands before handling food. 10 RX-V563/HTR-6150/DSP-AX563 RX-V563/HTR-6150/ DSP-AX563 I SPECIFICATIONS I Audio Section Minimum RMS Output Power (Power Amp. Section) (1 kHz, 0.9 % THD) FRONT L/R, CENTER, SURROUND L/R, SURROUND BACK L/R U, C models (8 ohms). 90 W/ch R, T, K, A, B, G, E, F, L models (6 ohms). 90 W/ch Maximum Power (JEITA) (1 kHz, 0.9 % THD, 6 ohms) FRONT L/R, CENTER, SURROUND L/R, SURROUND BACK L/R R, T, K, L models . 115 W/ch Dynamic Power Per Channel (IHF) (FRONT L/R drive) U, C models (8/6/4/2 ohms). 90/110/130/150 W R, T, K, A, B, G, E, F, L models (6/4/2 ohms). 100/110/125 W Dynamic Headroom U, C models (8 ohms) . 0.18 dB Input Sensitivity/Input Impedance (1 kHz, 100 W / 8 ohms) CD, etc. . 200 mV / 47 k-ohms MULTI CH INPUT FRONT L/R, CENTER, SURROUND L/R, SUBWOOFER . 200 mV / 47 k-ohms Maximum Input Signal (1 kHz, 0.5 % THD, Effect on) CD, etc. .2.0 V or more Output Level/Output Impedance REC OUT . 200 mV / 1.2 k-ohms SUBWOOFER (2ch STEREO and FRONT SP: Small) . 4 V / 1.2 k-ohms Headphone Jack Rated Output/Impedance CD, etc. (1 kHz, 200 mV, 8 ohms) . 400 mV / 470 ohms Frequency Response (10 Hz to 100 kHz) CD, etc. to FRONT L/R . 0 / -3 dB Total Harmonic Distortion (1 kHz, 50 W) Direct to FRONT L/R SP OUT U, C models (8 ohms).0.06 % or less R, T, K, A, B, G, E, F, L models (6 ohms).0.06 % or less Signal to Noise Ratio (IHF-A Network) Direct STEREO to Input shorted SP OUT 200 mV.98 dB or more 250 mV.100 dB or more Residual Noise (IHF-A Network) FRONT L/R SP OUT . 150 V or less Channel Separation CD, etc. (Input 5.1 k-ohms shorted, 1 kHz / 10 kHz) . 60 dB or more / 45 dB or more Tone Control Characteristics BASS Boost/Cut . 10 dB (100 Hz) TREBLE Boost/Cut . 10 dB (20 kHz) Filter Characteristics FRONT, CENTER, SURROUND, SURROUND BACK small (H.P.F.) . fc=40/60/80/90/100/110/120/160/200 Hz, 12 dB/oct. SUBWOOFER (L.P.F.) . fc=40/60/80/90/100/110/120/160/200 Hz, 24 dB/oct. I Video Section Video Signal Type Gray back U, C, R, K models . NTSC T, A, B, G, E, F, L models . PAL Video conversion . NTSC/PAL Composite Video Signal Level . 1 Vp-p / 75 ohms S-Video Signal Level Y . 1 Vp-p / 75 ohms C . 0.286 Vp-p / 75 ohms Component Signal Level Y . 1 Vp-p / 75 ohms Pb/Pr. 0.7 Vp-p / 75 ohms Video Maximum Input Level . 1.5 Vp-p or more Signal to Noise Ratio .50 dB or more Monitor Out Frequency Response Component video signal . 5 Hz to 60 MHz, -3 dB HDMI. Ver. 1.2a I FM Section U, C, R, T, K, A, G, E, F, L models Tuning Range U, C models. 87.5 to 107.9 MHz R, L models . 87.5 to 108.0 / 87.50 to 108.00 MHz T, K, A, G, E, F models . 87.50 to 108.00 MHz 50dB Quieting Sensitivity (IHF) (1 kHz, 100 % Mod.) Mono. 2.8 V (20.2 dBf) Signal to Noise Ratio (IHF) Mono / Stereo.73 dB / 70 dB Harmonic Distortion (1 kHz) Mono / Stereo. 0.5 % / 0.5 % Antenna Input . 75 ohms unbalanced I AM Section U, C, R, T, K, A, G, E, F, L models Tuning Range U, C models. 530 to 1,710 kHz R, L models .530 to 1,710 / 531 to 1,611 kHz T, K, A, G, E, F models . 531 to 1,611 kHz Antenna Input .Loop antenna I General Power Supply U, C models.AC 120 V, 60 Hz R model .AC 110, 120/220, 230-240 V, 50/60 Hz T model .AC 220 V, 50 Hz K model .AC 220 V, 60 Hz A model .AC 240 V, 50 Hz B, G, E, F models.AC 230 V, 50 Hz L model. AC 220, 230-240 V, 50/60 Hz Power Consumption U, C models. 240 W / 320 VA R model . 260 W T, K, A, B, G, E, F, L models . 240 W 11 RX-V563/HTR-6150/DSP-AX563 Dolby Digital DTS Dolby Pro Logic Dolby Pro Logic IIx, II Music Dolby Pro Logic IIx, II Movie Dolby Pro Logic IIx, II Game Neo:6 Cinema Neo:6 Music Neural Surround (U, C models) O OOO Program STRAIGHT MOVIE MUSIC MOVIE DIRECT STEREO STEREO STEREO DIRECT STEREO STEREO STEREO MUSIC ENHANCER MUSIC ENHANCER MUSIC ENHANCER MUSIC ENHANCER MUSIC ENHANCER STRAIGHT ENTERTAINMENT ENTERTAINMENT Movie Dramatic Pop/Rock Movie Dramatic 2ch Stereo 7ch Stereo 7ch Stereo 2ch Stereo 7ch Enhancer 7ch Enhancer 7ch Enhancer 7ch Enhancer 7ch Enhancer TV Sports Game ModeSub-mode Movie Music Live Music Disc Music Disc FM/AM XM SIRIUS iPod Bluetooth USB 151 (5-15/16) 130 (5-1/8) 21 (13/16) 308.9 (12-1/8) 255 (10-1/16) 21 (13/16) 21.7 (7/8) 351.6 (13-13/16) 435 (17-1/8) 395 (15-9/16) DIMENSIONS Unit: mm (inch) Manufactured under license from Dolby Laboratories. “Dolby”, “Pro Logic”, and the double-D symbol are trademarks of Dolby Laboratories. Bluetooth is a registered trademark of the Bluetooth SIG and is used by Yamaha in accordance with a license agreement. “SILENT CINEMA” is a trademark of YAMAHA CORPORATION. “iPod” is a trademark of Apple, Inc., registered in the U.S. and other countries. DVD DVD DVD DVR DVD DVD DVD CD CD CD FM/AM (TUNER) XM SIRIUS DOCK (V-AUX) USB DTV/CBL DTV/CBL V-AUX DVD Viewing DVD Movie Viewing DVD Live Viewing DVR Viewing Disc Hi-fi Listening Music Disc Listening Disc Listening CD Hi-fi Listening CD Listening CD Music Listening Radio Listening XM Listening SIRIUS Listening Dock Listening USB Audio Listening TV Viewing TV Sports Viewing Game Playing SCENE TEMPLATE SOUND/SURROUND SELECT MENU Sound Field Parameters Surround Decoders Standby Power Consumption (reference data) U, C, T, K, A, B, G, E, F models . 0.8 W Maximum Power Consumption (5ch drive, 10 % THD) R, L models . 490 W AC Outlets 2 switched outlets U, C models . 100 W max. total R, T, G, E, F, L models. 50 W max. total 1 switched outlet A, B models. 100 W max. Dimensions (W x H x D) . 435 x 151 x 351.6 mm (17-1/8 x 5-15/16 x 13-13/16) Weight .9.0 kg (19 lbs. 13 oz.) Finish RX-V563 Gold color. R, T models Black color . U, C, R, A, G, E, F models Titanium color . K, G, E, F, L models Silver color .A, L models HTR-6150 Black color . U, C, F models Silver color .F model DSP-AX563 Black color . B model Titanium color . B model Accessories. Remote control x 1 Batteries (R03, AAA, UM-4) x 2 Indoor FM antenna x 1 (U, C, R, T, K, A, G, E, F, L models) AM loop antenna x 1 (U, C, R, T, K, A, G, E, F, L models) Optimizer microphone x 1 *Specifications are subject to change without notice due to product improvements. 参考仕様外観予告変更 。 U . U.S.A. model C . Canadian model R . General model T . Chinese model K . Korean model A . Australian model B . British model G . European model E . South European model F . Russian model L . Singapore model “HDMI”, the “HDMI” logo and “High-Definition Multimedia Interface” are trademarks or registered trademarks of HDMI Licensing LLC. DTS-ES | NEO:6 | 96/24. Product “DTS” and “DTS-ES | NEO:6” are registered trademarks of DTS, Inc. “96/24” is a trademark of DTS, Inc. T
