Teac-DV-H550-Service-Manual电路原理图.pdf
D DV V- -H H5 55 50 0 SERVICE MANUAL DVD Player Effective : June, 2002S-0067B NOTES The parts with no reference number or no parts number in the exploded views are not supplied. As regards the resistors and capacitors, refer to the circuit diagrams contained in this manual. Parts marked with this sign are safety critical components. They must be replaced with identical components - refer to the appropriate parts list and ensure exact replacement. Parts of mark can be used only with the version designated. J:JAPAN US:U.S.A. C:CANADA E:EUROPE UK:U.K. 注意 分解図部番部品品番部品供給 。 標準抵抗、省略。 回路図参照。 印安全重要部品。 交換時必指定部品使用。 仕向先 J:JAPAN US:U.S.A. C:CANADA E:EUROPE UK:U.K. CONTENTS 1 SAFETY INFORMATION 2 2 SPECIFICATIONS 3 3 EXPLODED VIEWS AND PARTS LIST 4 4 ELECTRICAL PARTS LIST 8 5 INCLUDED ACCESSORIES 9 目 次 1 SAFETY INFORMATION 2 2 仕 様 3 3 分解図 4 4 電気 8 5 付属品 9 RadioFans.CN 收音机爱 好者资料库 1 SAFETY INFORMATION 2 This product has been designed and manufactured according to FDA regulations title 21, CFR, chapter 1, subchapter J, based on the Radiation Control for Health and Safety Act of 1968, and is classified as a class 1 laser product. There is no hazardous invisible laser radiation during operation because invisible laser radiation emitted inside of this product is completely confined in the protective housings. The label required in this regulation is shown 1. OCAUTION USE OF CONTROLS OR ADJUSTMENT OR PERFORMANCE OF PROCEDURES OTHER THAN THOSE SPECIFIED HEREIN MAY RESULT IN HAZARDOUS RADIATION EXPOSURE. Optical pickup: TYPE: DVD-1000J22B MANUFACTURER : Hitachi Media Electronics Co. Ltd LASER OUTPUT: Less than 0.5 mW on the objective lens WAVE LENGTH: 635 - 665 nm (DVD) : 790 20 nm (CD) 1For U.S.A. RadioFans.CN 收音机爱 好者资料库 2 SPECIFICATIONS 3 仕様 本体 電源 . 100V AC 50-60Hz 消費電力. 18W 外形寸法(W x H x D) . 285mmx101mmx288mm 質量. 3.3kg 許容動作温度. 535 許容動作湿度. 590(結露) 許容保管温度 . 2055 DVD部 . 信号方式. NTSC/PAL 周波数特性() . 2Hz22kHz SN比() . 105dB 全高調波歪率. 0.008以下 (). 92dB . 測定限界以下(0.001% W.PEAK) 出力 映像出力. 1.0Vp-p, 75 S映像出力 Y出力 . 1Vp-p, 75 C出力(NTSC) . 0.286Vp-p, 75 出力(Y, CB, CR) Y出力 . 1.0Vp-p, 75 CB出力 . 0.7Vp-p, 75 CR出力 . 0.7Vp-p, 75 音声出力(). 2Vrms(1k, 0.8dB) 付属品 用乾電池(単4)x 2本 光1本 1本 映像1本 1本 取扱説明書 保証書 仕様及外観改善予告変更。 DVD Player Signal system: NTSC / PAL Laser: Semiconductor laser Frequency range (digital audio): 2 Hz to 22 kHz Signal-to-noise rating (digital audio): More than 105 dB Audio dynamic range (digital audio): More than 92 dB Harmonic distortion (digital audio): 0.008% Wow and flutter: Below measurable level (less than 0.001% (W.PEAK) Operating conditions: Temperature: 5C to 35C Operation status: Horizontal Outputs Video output: RCA jack x 1 1.0 Vp-p, 75 , negative sync. S-video output: Mini DIN 4-pin x 1 (Y) 1.0 Vp-p, 75 , negative sync. (C) 0.286 Vp-p, 75 Component Video output (U.S.A./Canada Model): RCA jack x 1 (Y) 1.0 Vp-p, 75 (CB, CR) 0.7 Vp-p, 75 Audio output (digital audio): RCA jack x 1, 0.5 Vp-p, 75 Audio output (analog audio): RCA jack x1, 2.0 Vrms (1 kHz, 0.8 dB) AV connector output (Europe/U.K. Model): SCART jack x1 General Power supply: AC 120V, 60Hz (U.S.A./Canada Model) AC 230V, 50Hz (Europe/U.K. Model) Power consumption: 18 W Weight: 3.3 kg (7-1/4 lbs) External dimensions (W x H x D): 285 x 101 x 288 mm (11-1/4 x 4 x 11-5/16) Accessories Remote Control Unit x 1 Owners manual x 1 Audio Signal Cable x 1 Video Signal Cable x 1 Optical Cable x 1 Remote Control Cord x 1 Design and specifications are subject to change without notice. Weight and dimensions are approximate. 4 1 3 2 4 5 6 8 9 11 12 13 14 15 16 16 17 18 19 20 21 22 23 24 24 24 25 26 27 28 29 30 7 10 3 EXPLODED VIEWS AND PARTS LIST 分解図 EXPLODED VIEW-1 5 EXPLODED VIEW-1 REF.NO.PARTS NO.DESCRIPTIONREMARKS 1- 1 9A06240500WINDOW KGU1A154Y 1- 2 9A09261600ORNAMENT,DOOR KGX1A310ZC11 1- 3 9A09261300ORNAMENT,DOOR KGR1A246K92 1- 4 9A06677900BADGE KGB1A047 1- 5 9A09261900FRONT PANEL KKM1A112ZC11 1- 6 9A06251600BAR,SIDE KKM1A051C11 1- 7 9A06229000SCREW,SPECIAL KHD1A016 1- 8 9A08792000WINDOW,SENSOR KGU1A245A10 1- 9 9A09261500PANEL,SUB KGW1A323M9K64 1-10 9A06316000KNOB,TACT KBT1A386WK64 1-11 9A06239700KNOB,TACT KBT1A410C13 1-12 9A06314300KNOB,TACT(OPEN/CLOSE) KBT1A385YK64 1-13 9A07301200KNOB,POWER KBT2A387ZK64 1-14 9A07301300INDICATOR,POWER KGL2A120 1-15 9A09255300FIP DISPLAY KFLHNV07SM08T 1-16 9A07290000BRACKET,FLT KMD1A374 1-17 9A09262100FRONT PCB ASSY KOP11464B 1-18 9A09256800SUPPORT,MECHA KMH1A141 1-19 9A092296001 DVD MECH(P/U),MGD-F6003ABJDMGD-F6003A 1-20 9A092522001 DVD MAIN PCB ASSY J KOP11445D 9A092522101 DVD MAIN PCB ASSY US,CKOP11445C 9A092522201 DVD MAIN PCB ASSY E,UKKOP11445B 1-21 9A06315500FOOT KKL1A047ZK63 1-22 9A06229300CUSHION,FOOT KHG1A039Z 1-23 9A09262600CHASSIS,BOTTOM KUA1A207 1-24 9A01375500PCB HOLDER KHE170 1-25 9A09252400POWER PCB SMPS ASSY J,US,CKOP11489BSMPS 9A09252420POWER PCB SMPS ASSY E,UKKOP11489CSMPS 1-26 9A09262000AV PCB ASSY J,US,C KOP11458D 9A09262020AV PCB ASSY E,UK KOP11458E 1-27 9A06251100CABINET,TOP KKC1B076S21 1-28 9A09261800REAR PANEL KKF1A229XK59 1-29 9A06754900BUSHING,AC CORD KHR1A028 1-30 9A08144000POWER CORD J BJA2J049Z 9A08043100POWER CORD UC,C BJA523FBY 9A08152100POWER CORD E BJA2B043Z 9A09267600POWER CORD UK BJA2E045Z 9A08038100RING,FERRITE KLZ9W001Z EXPLODED VIEW-2 6 7 EXPLODED VIEW-2 (MGD-F6003A) REF.NO.PARTS NO.DESCRIPTIONREMARKS 2- 19A09462400CLAMPER BKT F6C 1001 2- 29A09462500YORK(CLAMPER-T) 30D 1002 2- 39A09462600CHASSIS F6A 3001 2- 49A09462700PULLEY(MOTOR) F6D 3007 2- 59A09462800CLAMPER F6C 3008 2- 69A09462900GEAR(LOAD) F6D 3006 2- 79A09463000HOLDER(TU) F6C 3003 2- 89A09463100SLIDER(CAM) F6C 3004 2- 99A09463200TRAY F6A 3002 2-109A09463300PULLEY(GEAR) F6D 3005 2-119A09463400INSULATOR F6D 4003 2-129A09463500DRIVE BELT F6D 4002 2-139A09463600SCREW(TU) F5D 8010 2-149A09442300SCREW(A2) E1D 8012 2-159A09463700SCREW,SEMS 1.7X3.5 N530047 2-169A09463800SCREW,BIND TAPPING M2.6X8N230001 2-179A09463900SHEET(FFC-H) F6D 8012 2-199A09464100PCB(MECH) F6A 9002 2-209A09464200CUSHION(TU-R) F6D 8022 2-219A09464300FFC WIRE(24P) F6D 9003 2-229A09464400MOTOR,MDN3BT3DSA 91433174 2-239A09464500LEVER SW,SSS-28-3 94402124 2-249A09464600TRAVERSE UNIT,DVD1000J22B90999033 2-279A09464900PCB ASSY P34-0020 1 DVD MAIN PCB ASSY REF.NO.PARTS NO.DESCRIPTION 9A092522001 DVD MAIN PCB ASSY J 9A092522101 DVD MAIN PCB ASSY US,C 9A092522201 DVD MAIN PCB ASSY E,UK 9A09259900DVD MAIN PCB CN10 9A09256300WAFER,CARD CABLE CN12 9A0925640040P HEADER IC01 9A09254200IC,ES4318F IC03 9A09260300IC,FLASH MEMORY(4M) IC07 9A09254500IC,74VHC04MX IC08,IC09 9A09254300IC,RC1117ST IC10,IC11 9A08149700IC,16M SDRAM IC13 9A09260200IC,EEPROM(16K) IC14 9A09254100IC,CS4955 L101,L102 9A05968600COIL,BEAD X101 9A09257100CRYSTAL,CHIP(27MHZ SMD) AV PCB ASSY REF.NO.PARTS NO.DESCRIPTION 9A09262000AV PCB ASSY J,US,C 9A09262020AV PCB ASSY E,UK 9A09260000AV PCB CN10 9A09256300WAFER,CARD CABLE CN91 9A08870000WAFER,CARD CABLE 15P D501 9A01390600DIODE,1N4148T IC51 9A09260500IC,KA79L08AZT IC52 9A09260400IC,KA78L08AZT IC53 9A07343300IC,NJM2068MD-TE1 IC54 9A09254400IC,XWM8706EDS IC55 9A07871100IC,NJM7805FA JK51 9A09256200JACK,S-VIDEO (1P/H) JK52 9A09256100JACK,IN/OUT J,US,C JK53 9A08152300SCART CONNECTOR E,UK JK54 9A06239100MODULE,OPTICAL JK55 9A09256000PIN JACK BOARD(6P) L501,L502 9A08158400COIL,1.8UH K L503-L505 9A08148000COIL,2.7UH K L506,L507 9A08158400COIL,1.8UH K L508,L509 9A05356900COIL,10UH K Q501 9A08791000TR,KRA107M Q502,Q503 9A05895900TR,KTA1266YT Q504 9A08791100TR,KRC107M Q505,Q506 9A05197500TR,KTD1302T SW51 9A06675300SWITCH,SLIDE FRONT PCB ASSY REF.NO.PARTS NO.DESCRIPTION 9A09262100FRONT PCB ASSY 9A09262700FRONT PCB CN91 9A08867800WAFER,CARD CABLE 15P D901 9A08147300LED,SLR342VCTB7(RED) D906,D911 9A01390500DIODE,1N4148MT F901 9A09255300FIP DISPLAY IC91 9A09254000IC,MICOM IC92 9A08563600SENSOR,REMOCON L901,L902 9A05356900COIL,10UH K PB91,PB92 9A07290000BRACKET,FLT Q901 9A08791000TR,KRA107M Q902,Q903 9A08791100TR,KRC107M Q904 9A08791000TR,KRA107M S901-S908 9A04882500SW,TACT SKHV10910A X901 9A09253900RESONATOR,CERAMIC 8 4 ELECTRICAL PARTS LIST 電気 5 INCLUDED ACCESSORIES 9 付属品 INCLUDED ACCESSORIES REF.NO.PARTS NO.DESCRIPTIONREMARKS 9A08902300OWNERS MNL,J J KQX1A715Y 9A08902100OWNERS MNL,E/F US,C KQX1A731Z 9A08902200OWNERS MNL,E/F/G/I/S E,UKKQX1A730Z 9A09252100REMOCON ASSY KARTDVH350 9A08127600BATTERY J KABAAAM1.5V 9A05935900CORD,PIN KJS4M014Y 9A05936000CORD,PIN KJS4N001Y 9A08130000OPTICAL FIBER CABLE KJS8H002Z 9A08143300CORD,PHONE KJS4M011Y 45231 C B A SCHEMATIC DIAGRAMDV-H550/DV-H350POWER SUPPLY (DM, TCA) 1 st Issue; November 2001 DVD Player D DV V- -H H5 55 50 0/ /D DV V- -H H3 35 50 0 45231 C B A SCHEMATIC DIAGRAMDV-H550/DV-H350POWER SUPPLY (EUR, UK) 1 st Issue; November 2001 DVD Player D DV V- -H H5 55 50 0/ /D DV V- -H H3 35 50 0 86745231 E D C B A BLOCK DIAGRAMDV-H550 DVD Player D DV V- -H H5 55 50 0 1 st Issue; September 2001 86745231 E D C B A WIRING DIAGRAMDV-H550 DVD Player D DV V- -H H5 55 50 0 1 st Issue; September 2001 86745231 E D C B A SCHEMATIC DIAGRAMDV-H550MAIN PCB DVD Player D DV V- -H H5 55 50 0 1 st Issue; September 2001 NOTES: 1. Resistor values are in ohms (k=kilo-ohms, M=megohms). 2. Capacitor values are in microfarads (p=picofarads). 3. Parts marked with this sign are safety critical components. They must always be replaced with identical components-refer to the appropriate parts list and ensure exact replacement. 注 意 1. 抵抗単位 （，） 。 2. 単位 （） 。 3. 部品安全規格重要部品。 交換必指定部品使用。 86745231 E D C B A SCHEMATIC DIAGRAMDV-H550AV PCB DVD Player D DV V- -H H5 55 50 0 1 st Issue; September 2001 INSTRUCTIONS FOR SERVICE PERSONNEL BEFORE RETURNING APPLIANCE TO THE CUSTOMER, MAKE LEAKAGE- CURRENT OR RESISTANCE MEASUREMENTS TO DETERMINE THAT EXPOSED PARTS ARE ACCEPTABLY INSULATED FROM THE SUPPLY CIRCUIT. NOTES: 1. Resistor values are in ohms (k=kilo-ohms, M=megohms). 2. Capacitor values are in microfarads (p=picofarads). 3. Parts marked with this sign are safety critical components. They must always be replaced with identical components-refer to the appropriate parts list and ensure exact replacement. 注 意 1. 抵抗単位 （，） 。 2. 単位 （） 。 3. 部品安全規格重要部品。 交換必指定部品使用。 86745231 E D C B A SCHEMATIC DIAGRAMDV-H550FRONT PCB DVD Player D DV V- -H H5 55 50 0 1 st Issue; September 2001 INSTRUCTIONS FOR SERVICE PERSONNEL BEFORE RETURNING APPLIANCE TO THE CUSTOMER, MAKE LEAKAGE- CURRENT OR RESISTANCE MEASUREMENTS TO DETERMINE THAT EXPOSED PARTS ARE ACCEPTABLY INSULATED FROM THE SUPPLY CIRCUIT. NOTES: 1. Resistor values are in ohms (k=kilo-ohms, M=megohms). 2. Capacitor values are in microfarads (p=picofarads). 3. Parts marked with this sign are safety critical components. They must always be replaced with identical components-refer to the appropriate parts list and ensure exact replacement. 注 意 1. 抵抗単位 （，） 。 2. 単位 （） 。 3. 部品安全規格重要部品。 交換必指定部品使用。
