Philips-DFR-9000-Service-Manual电路原理图.pdf
DFR9000all versions' 3103 785 25290Published by PW 0510 Service Audio Printed in The Netherlands Subject to modificationVersion 1.0Digital Surround ReceiverTABLE OF CONTENTS©Copyright 2005 Philips Consumer Electronics B.V. Eindhoven, The NetherlandsAll rights reserved. No part of this publication may be reproduced, stored in a retrievalsystem or transmitted, in any form or by any means, electronic, mechanical, photocopying,or otherwise without the prior permission of Philips.Technical Specification.1-1Connections & Controls.1-2Accessories .1-4Safety & Warnings.2-1Firmware Upgrade.2-2Service Test Program.2-3Standby-LED Blinking State .2-9Location of Printed Boards .3-1Dismantling.3-1Block & Wiring Diagram.3-2Circuit Diagrams & Printed BoardsStandby Power Supply.4-1Power Supply AC6750 .5-1Front Control .6-1Digital I/O .7-1Video Processing Board.8-1Video I/O .9-1Front Left.10-1Front I/O .11-1Front Keys.12-1Front Right .13-1Audio Signal Processing Board.14-1UCD Amplifier .15-1Speaker Terminal.16-1DAB Interface.17-1Exploded View.18-1Partslist.18-2Revision list .18-21-1TECHNICAL SPECIFICATIONGeneralDimensions : 435 x 100 x 370mmNet weight : 7.0kgPower Supply /22S : 230V ±10%, 50HzPower consumption Standby : 0.5WDAB TunerTuning range : 174-240MHz (Band III)1452-1492MHz (L)AM TunerTuning range /22S : 531-1602kHz, 9kHz gridTuning range /37 : 530-1700kHz, 10kHz gridIF : 450kHzSensitivity (26dB S/N) : 3250µV/m (2000µV/m)Distortion (rf=1mV, m=80%) : 5% (4% typ.)FM TunerTuning range /22S : 87.5-108MHz, 50kHz gridTuning range /37 : 87.5-108MHz, 100kHz gridIF : 10.7MHzSensitivity (26dB S/N) : 22dBf (15dBf typ.)-3dB limiting point : 23.5dBf (10dBf typ.)Distortion (rf=1mV, m=80%) : 3% (0.23% typ.)Crosstalk (rf=1mV, D f=75kHz) : -26dB (-48dB typ.)Video performance Composite VideoSignal level : 1Vpp (75)Frequency response : 0-6MHzS/N ratio : >50dBVideo performance S-VideoSignal level Y : 1Vpp (75)Signal level C : 0.286Vpp (75)Frequency response : 0-6.5MHzS/N ratio : >65dBVideo performance Component Video / RGBSignal level Y : 1Vpp (75)Signal level PB/CB, PR/CR : 0,7Vpp (75)Signal level R/G/B : 0,7Vpp (75)Frequency response : 0-7MHzFrequency resp. progressive : 0-16MHzS/N ratio : >70dBVideo input resolutions/formatsPAL 576i (720 x 576i)PAL progressive 576p (720 x 576p, downscaled to 576i)NTSC 480i (720 x 480i)NTSC progressive 480p (720 x 480p, downscaled to 480i)Video output resolutions/formatsPAL input 50Hz (TV) : 576i (720 x 576i)576p (720 x 576p)720p (1280 x 720p)1080i (1920 x 1080i)NTSC input 60Hz (TV) : 480i (720 x 480i)480p (720 x 480p)720p (1280 x 720p)1080i (1920 x 1080i)Digital video input/outputPAL input 50Hz (TV) : 576i (720 x 576i)576p (720 x 576p)720p (1280 x 720p)1080i (1920 x 1080i)NTSC input 60Hz (TV) : 480i (720 x 480i)480p (720 x 480p)720p (1280 x 720p)1080i (1920 x 1080i)PC input 60Hz : VGA (640 x 480p)SVGA (800 x 600p)XGA (1024 x 768p)SXGA (1280 x 1024p)Audio Line-inInput sensitivity : 0.2-2.8VrmsInput impedance : 22kAudio Line/Rec OutOutput voltage : 1.6VrmsOutut impedance : 1kFrequency response : 5Hz-100kHzS/N ratio : 110dBA typ.THD (1kHz, 1W) : 0.0016%Power amplifierOutput power (1kHz, THD=1%) : 2 x 110W RMS into 46 x 65W RMS into 4Frequency response (1W) : 5Hz-45kHzS/N ratio : 105dBA typ.THD (1kHz, 1W) : 0.065%ADC/DACResolution : 24bits/96kHzDigital In/OutCoaxial input : 0.2Vpp, 75Coaxial output : 0.5Vpp, 75Supported multichannel formatsDolby ProLogic IIx, Dolby Digital, Dolby Digital EX, DTS,DTS 96/24, DTS ES Matrix, DTS ES Discret, DTS NEO:61-2CONNECTIONS & CONTROLSFront ViewsoP noitcnuF skrameR1NO-YBDNATSderpusthgil)nottubybdnats/rewoPehtnirotacidni(DELnO/ybdnatS.ybdnatsotdnanotesehtsehctiwS.ffodehctiwssitesehtnehw2NWOD/PU.edomreifilpmanisecruosdetcennocsuoiravehtstceleS.unemehtninoitceridnwoddnapunisetagivaN-.edomBADdnarenuTninoitatsgnitsacdaorbtxendnasuoiverpstceleS-3THGIR/TFEL.unemehtninoitceridthgirdnatfelnisetagivaN-.edomBADdnarenuTninoitatsteserptxendnasuoiverpstceleS-4KO.unemehtninoitcasmrifnoC-.edomBADnisecivresoiduayradnocesstceleS-5UNEMMETSYS.unemmetsysehtsesolcdnasnepO6yalpsidtfeL.tesehtfosutatstneserpehtsetacidnI-.edomBADnihtgnertslangissetacidnI-.ecruostneserpehtsetacidnI-7yalpsidertneCbus,unemmetsysehtsyalpsiddnasedomdnuorrusdetceles,tesehtfosutatstneserpehtnosmrofnI.sgnittesunemdnas'unem8yalpsidthgiR.evitcaerasrekaepstahwswohS-.levelemulovsetacidnI-9DNUORRUSdnaputesrekaepsnosdnepedsedomdnuorrusfoytilibaliavA.sedomdnuorruselbaliavasuoiravehtstceleS.langistupnifoepyt01ELBERT/SSAB .slennahcllarofesnopserycneuqerf)elberT(hgihdna)ssaB(wolehttsujdaotlortnocEMULOVehtselbanE11RI.lortnocetomerehtmorfslangisehtsevieceR21EMULOV.slennahcoiduallafoleveltuptuoehtslortnoC31SENOHP .senohpdaehhtiwgninetsilnehwslangisoiduastuptuO41palF .tesehtfotnorfehtnostekcostupnioedivdnaoiduaehtsrevoC51MAC .aremacoediva.g.e,ecruoslanretxeelbatropamorfslangisoedivdnaoiduastupnI$ %1 2 534 6 7 8 0 ! #9 Rear ViewsoP noitcnuF skrameR61SNIAM.tekcostelnisniaM71SREKAEPS)LANIMONMHO4(:gnitcennocroflenapnoitcennocrekaepSR/L srekaepstnorf)R(thgirdna)L(tfeL-RS/LS srekaeps)RS(thgirdnuorrusdna)LS(tfeldnuorruS-C rekaepsertneC-BUS1.5/BS1.6 .noitarugifnocrekaeps1.6anidetcennocebotrekaepskcabdnuorruS-ebnacstekcoseseht,)noitarugifnocrekaepssselro1.5(detcennocsirekaepskcabdnuorrusonesacnI.refoowbusevissapagnitcennocrofdesu81ANNETNA.srotcennocannetnaBADdna-MA,-MF91NI1OEDIV)S,B,G,R(6ehtgnisu,redrocer/reyalpDVDaforotcennocTRACSehtotnoitcennocrofstekcostupnioedivSBGR.tnempiuqeoedivrehtootnoitcennocrofdengissaerebnacstekcosesehT.deilppuselbactracSothcnic02NI2OEDIV)S,B,G,R(othcnic6ehtgnisu,revieceretilletasaforotcennocTRACSehtotnoitcennocrofstekcostupnioedivSBGR.tnempiuqeoedivrehtootnoitcennocrofdengissaerebnacstekcosesehT.deilppuselbactracS12OEDIVNIDVD/NIEMAG/NIVToediV-SroSBVCehtotgnitcennocrofstekcostupnioediv)worrewol(oediV-Sdna)nwodreppu(SBVCrofdengissaerebnacstekcosesehT.redrocer/reyalpDVDroelosnocemag,VTafostekcostuptuo.tnempiuqeoedivrehtootnoitcennocTUOCER-SroSBVCehtotgnitcennocrofstekcostuptuooediv)tekcosrewol(oediV-Sdna)tekcosreppu(SBVC.RCVroredrocerDVDafostekcostupnioediVTUOSBVC.tekcostupniSBVCahtiwVTaotnoitcennocroftekcostuptuoSBVC22TUOOEDIVTUOENILVTOT+hcnic6ehtgnisu,VTehtforotcennoctracSehtottesehtgnitcennocrofdesuerastekcostuptuoesehT.elbactracSotlortnoctracSLORTNOCTRACSehtotVTehthctiwsyllacitamotualliwlortnoctracS,detavitcasitesehtnehW.kcajmm5.2ehtgnitresniroFeblliwecruosevitcaehT.)edamneebsahnoitcennoctracStahtdedivorp(ecruostupni)evitca(tcerroc.neercsVTehtnonwohsTUOOEDIVehtotdetcennoceboslanacstekcosesehT.srotcennochcnicoediv4ehtgnitresnirofstekcostuptuoSBGR.VTafostekcostupniBGRTUOENIL.srotcennochcnicoidua2ehtgnitresnirofstekcostuptuooiduA32NILACITPOtekcossihT.revieceretilletasafotekcostuptuooidua)lacitpo(latigidehtotnoitcennocroftekcostupnioiduA.)redrocerDCroreyalpDVD,reyalpDCa.g.e(tnempiuqeoedivrehtootnoitcennocrofdengissaerebnac42NIHC-MesehT.tnempiuqelennahcitlumfostekcostuptuooidualennahcitlumehtotnoitcennocrofstekcostupnioiduA,R/LehtelbaliavasitnempiuqelennahcitlumonfI.reyalpDCASaotnoitcennocrofdengissaerastekcosdnaNIR-DC,NIDC(tnempiuqeoiduagolanaotnoitcennocrofdengissaerebnacstekcosBUS/CdnaRS/LS.detcennocsitnempiuqelennahcitlumonnehwnoitcnufonsahstekcosRBS/LBSehT.)NIXUA &* § ( ) ¡ £1-3ACCESSORIESelcitrA rebmunedoC 10/0009RFD)RUE(00/droCsniaM500000702242X)KU(50/droCsniaM70000070224AS009PVDlortnoCetomeR131278429313XannetnABAD14955803301annetnApooLMA683549452242XLAPelbaCgnitcennoC220520413013XdloG,m5.1,2x2oiduAelbaC-hcniC17949803301dloG,m5.1,2x4oiduAelbaC-hcni 89498033013)x2(XdloG,m1,R57,tuO-latigiDelbaC-hcni 69498033013Xm5.1,lortnoCx1+hcniCx6rotpadATRACS536006702242Xm5.1,hcniCx6rotpadATRACS63600670224tesehthtiwdeilppus.xsoP noitcnuF skrameR52OIDUANIDVD/NIEMAG/NIVT.reyalpDVDroelosnocemag,VTafostekcostuptuooiduaehtotnoitcennocrofstekcostupnioiduaoeretSehtnidetcelesebotsdeentekcossiht,ecivedgnidroceraotdetcennocsistekcosesehtfoenoesacnI.)oiduaceRunembus(unemnoitarugifnoCTUOCER-OIDUA.RCVroredrocerDVDafostekcostupnioiduaehtotgnitcennocrofstekcostuptuooiduaoeretS62TUOBUS .refoowbusevitcanaotgnitcennocroftekcostuptuO72IMDHTUO-IMDH.tekcostupniIMDHahtiwVTaotnoitcennocroftekcostuptuO1NI-IMDH.reyalpDCASafotekcostuptuoehtotnoitcennocrofstekcostupnI2NI-IMDH.ecivedecruosIMDHafotekcostuptuoehtotnoitcennocrofstekcostupnIaroreyalpDVDIMDHa.g.e(tnempiuqeIMDHrehtootnoitcennocrofdengissaerebnacstekcosesehT.)revieceretilletas82LATIGID3NI/2NI/1NILATIGIDgnidrocer/kcabyalplatigidfotekcostuptuo)laixaoc(latigidehtotnoitcennocrofstekcostupnioiduA.tnempiuqeredrocer/reyalpDVD:1NIredrocer/reyalpDC:2NIecived)laixaoc(latigidynA:3NIDCa.g.e(tnempiuqegnidrocer/kcabyalplatigidrehtootnoitcennocrofdengissaerebnacstekcosesehT.)redrocer/reyalpDVD,redrocer/reyalpTUOLATIGID1.redrocerDCafotekcostupnilatigidehtotnoitcennocroftekcostuptuO1-4SAFETY & WARNINGSESD PROTECTION EQUIPMENTESD3 KIT 4822 310 10671 Anti-static table mat (600x650x1.25mm) Anti-static wristband Connection box (3 press stud connections, 1M) Extendible cable (2m, 2M, to connect wristband to connection box) Connecting cable (3m, 2M, to connect table mat to connection box) Earch cable (1M, to connect any product to table mat or to connection box)' WARNINGAll ICs and many other semiconductors are susceptible toelectrostatic discharges (ESD). Careless handling duringrepair can reduce life drastically.When repairing, make sure that you are connected with thesame potential as the mass of the set via a wristband withresistance. Keep components and tools at this potential.f ATTENTIONTous les IC et beaucoup d´autres semi-conducteurs sontsensibles aux décharges statiques (ESD). Leur longévitepourrait être considérablement écourtée par le fait qu´aucuneprécaution nést prise à leur manipulation.Lors de réparations, s´assurer de bien être relié au mêmepotentiel que la masse de l´appareil et enfileer le braceletserti d´une résistance de sécurité.Veiller à ce que les composants ainsi que les outils que l´onutilise soient également à ce potentiel.d WARNUNGAlle ICs und viele andere Halbleiter sind empfindlichgegenüber elektrostatischen Entladungen (ESD).Unsorgfältige Behandlung im Reparaturfall kann dieLebensdauer drastisch reduzieren.Sorgen Sie dafür, daß Sie im Reparaturfall über ein Puls-armband mit Widerstand mit dem Massepotential desGerätes verbunden sind.Halten Sie Bauteile und Hilfsmittel ebenfalls auf diesemPotential.WAARSCHUWINGAlle IC´s en vele andere halfgeleiders zijn gevoelig voorelectrostatische ontladingen (ESD).Onzorgvuldig behandelen tijdens reparatie kan de levensduurdrastisch doen vermindern. Zorg ervoor dat u tijdens reparatievia een polsband met weerstand verbonden bent met hetzelfdepotentiaal als de massa van het apparaat.Houd componenten en hulpmiddelen ook op ditzelfde potentiaal.i AVVERTIMENTOTutti IC e parecchi semi-conduttori sono sensibili alle scarichestatiche (ESD).La loro longevità potrebbe essere fortemente ridatta in caso dinon osservazione della più grande cauzione alla loromanipolazione. Durante le riparationi occorre quindi esserecollegato allo stesso potenziale che quello della massadelápparecchio tramite un braccialetto a resistenza.Assicurarsi che i componenti e anche gli utensili con quali silavora siano anche a questo potenziale.'Safety regulations require that the set be restored to itsoriginal condition and that parts which are identical withthose specified be used.Safety components are marked by the symboliLe norme di sicurezza estigono che l´apparecchio vengarimesso nelle condizioni originali e che siano utilizzati ipezzi di ricambiago identici a quelli specificati.Componenty di sicurezza sono marcati conVeiligheidsbepalingen vereisen, dat het apparaat in zijnoorspronkeliijke toestand wordt teruggebracht en datonderdelen, identiek aan de gespecificeerde, worden toegepast.De Veiligheidsonderdelen zijn aangeduid met het symboolf“Pour votre sécurite, ces documents doivent être utiliséspar des spécialistes agréés, seuls habilités à réparervotre appareil en panne“.ESDSAFETYdBei jeder Reparatur sind die geltenden Sicherheitsvor-schriften zu beachten. Der Originalzustand des Gerätesdarf nicht verändert werden. Für Reparaturen sind Original-ersatzteile zu verwenden.Sicherheitsbauteile sind durch das Symbol markiert.fLes normes de sécurité exigent que lappareil soit remisà létat dorigine et que soient utilisées les pièces derechange identiques à celles spécifiées.Les composants de sécurité sont marqués'After servicing and before returning the set to customerperform a leakage current measurement test from all exposed metal parts to earth ground, to assure noshock hazard exists.The leakage current must not exceed 0.5mA.2-1FIRMWARE UPGRADEOccasionally, Philips will release new firmware for themicrocontroller and Audio-DSP on the Video ProcessingBoard. The binary firmware upgrade file(s) will be madeavailable via the official service channels (i.e. symptom/curesystem and/or customer care website).To upgrade the firmware proceed as follows:1. Download and install the communication application“Telix for DOS” (http:/www.telix.com/).2. Download the binary upgrade file and copy it to the“SEND” folder within the Telix-directory. Upgrade fileshave the extension “.001”, e.g. “Vp50.001”.3. Connect the VPB board (connector 1009) with the powersupply (power not switched on yet).Connect the VPB board via connector 1012 (whiteconnector with 7 pins) with the Interfac
