Kenwood-KRFA-4030-E-Service-Manual电路原理图.pdf

SPEAKERS+-+R+-+LLRB AFM75GNDAMANTENNAREC OUTPLAY INAUXMD / TAPE1TAPE2/MONITORPLAY INREC OUTPLAY INPLAY INPHONOCDLRPhono jack(E63-0068-15)Miniature phone jack(E11-0293-05)Power cord bushing(J42-0083-05)AC power cord *(E30-)Lock terminal board(E70-0052-05)Phono jack(E63-0047-15)Phono jack *(E63-)Lock terminal board(E70-0047-05)AC outlet *(E03-)* Refer to parts list on page 21 .70%AUDIO RECEIVERAR-404/KRF-A4030/A4030E/A4030-SSERVICE MANUAL©2000-1/B51-5595-00 (K/K) 3174ASPEAKERSBSTANDBYPOWERMULTI CONTROLSOUNDSOURCE DIRECTAUTOBANDMEMORYINPUT SELECTORVOLUME CONTROLUPDOWNBALANCEPTYTA/NEWSDISPLAYPHONESON/STANDBYONOFFTAPE 2/MONITORIndicator(B12-0385-04)Knob *(K29-)Front glass *(B10-)Panel *(A60-)Knob *(K29-)Knob *(K29-)Knob *(K29-)Knob *(K29-)Knob *(K29-)Phone jack(E11-0127-05)Knob *(K27-)FM (T90-0836-05)(A70-1266-05): RC-R0709.KPMX(A70-1267-05): RC-R0708.E1E2E3indoor antenna AC plug adaptor (1)(E03-0115-05)(1)AM (T90-0852-05)loop antenna (1) Batteries (R06/AA) (2)*Use to adapt the plug on the powercord to the shape of the wall outlet.(Accessory only for regions where useis necessary.)Remote control unit (1)AR-404/KRF-A4030/A4030E/A4030-S2CONTENTS / ACCESSORIES / CAUTIONSCONTENTS / ACCESSORIES / CAUTIONS.2CIRCUIT DESCRIPTION.3ADJUSTMENT.6PC BOARD.7SCHEMATIC DIAGRAM.11EXPLODED VIEW.20PARTS LIST.21SPECIFICATIONS.27ContentsAccessoriesResetting the MicrocomputerIf the microcomputer may malfunction (unit cannot beoperated, or shows an erroneous display) if the power cordis unplugged while the power is ON, or due to some otherexternal factor. If this happens, execute the following pro-cedure to reset the microcomputer and return the unit to itsnormal operating condition.For U.S.A. and CanadaUnplug the power cord from the wall outlet, thenplug it back in while holding down the POWER key.Except for U.S.A. and CanadaWith the power cord plugged in, turn the POWER keyOFF. Then, while holding down the ON/STANDBYkey, press the POWER key.Please note that resetting the microcomputer will clearthe contents of the memory and returns the unit to thestate it was in when it left the factory.CautionsAR-404/KRF-A4030/A4030E/A4030-S3CIRCUIT DESCRIPTION1. BACK UP DATAAND INITIAL STATE 1-1 BACK UP(1)AMP POWER.STANDBY INPUT SELECTOR.TUNER BALANCE.CENTER SPEAKER A RELAY.ON SPEAKER B RELAY.OFF VOLUME LEVEL.-66dB BASS LEVEL.0dB TREBLE LEVEL.0dB INPUT LEVEL.0dB SOURCE DIRECT.OFF TAPE2/MONITOR.OFF(2)TUNER BAND.FM PRESET CHANNEL.“-“ FREQUENCY.LOWER LIMIT VALUE K1.FM:87.50MHzAM:530kHzE1/E3.FM:87.50MHzAM:531kHz AUTO/MANUAL.AUTO DISPLAY MODE.FREQUENCY E ON THRUST RECEIVING.OFFMODE T1 VOLUME.OFF(-66dB)1-2 INITIAL SETTINGThe initial setting is performed when the AC power cordis plugged into the AC power wall out let while pressing the power (STANDBY) key.3. TEST MODE3-1 SETTINGTurn the power ON while pressing the BAND key.3-2 CANCELLATIONUnplug the AC power cord from an AC power wall outlet.3-3 STARTING ACTIVE CONTENTS The power on state is entered whenever the power istrued on while pressing the BAND key. All functions are initialized and activated in the all light-ing mode. All lighting mode is canceled when any main unit'skeys are pressed. The normal display obtained whenthe selector is set to TUNER then appears. E2PROM check(Etype only).Check the reading data and the writing data of theE2PROM after setting the test mode.Display shows blank if the reading data and writingdata are the same. Display shows “LW“ if the differentdata will be written to E2PROM.3-4 ACTIVE CONTENTS The mute control is not activated when the mode isswitched. The test mode will be terminated by plugging it off thepower source or by initializing it when all the settingswill be initialized. During the test mode, it can be operated in a specialmanner that is deferent from an ordinary operation byusing the keys on the remote control or the main body,specifically as shown in the following table (3-5 CON-TENTS). Channel space will be no changed in the test mode.3-5 CONTENTS 3-5-1 TUNER FUNCTIONWITH THE SELECTOR ON TUNER (E TYPE ONLY)DESTINA-TIONTUNERTYPEBANDRECEIVINGCHANNELSPACEIFPLLREFERENCEFREQUENCYRANGEFREQUENCYDSW3(D507)DSW2(D505)DSW1(D504)DSW0(D510)K,PK1(1700)FMAM87.5MHz108.0MHz530kHz1700kHz100kHz10kHz+10.7MHz+450kHz25kHz10kHz0000M,XE1FMAM87.5MHz108.0MHz531kHz1602kHz50kHz9kHz+10.7MHz+450kHz25kHz9kHz0011MK2(1600)FMAM87.5MHz108.0MHz530kHz1610kHz100kHz10kHz+10.7MHz+450kHz25kHz10kHz0001EE3RDSFMAM87.5MHz108.0MHz531kHz1602kHz50kHz9kHz+10.7MHz+450kHz25kHz9kHz0101DSW0DSW3(DIODE SW)* 0: NONE DIODE,1:ADD DIODE2. DESTINATION LIST OF TUNERBass and treble are selected while the sound key ispressed.3-5-2 AMP FUNCTIONWITH THE SELECTOR ON SOMETHING OTHER THANTUNER One touch max,min setting for Audio level.SOUND KEYKEYMASTER VR.BASSTREBLEBAND-89dB0dB+10dBAUTO0dB0dB+10dBMEMORY-10dB0dB+10dBOPERATIONFUNCTIONFL DISPLAYREMARKSKEY(EX.)PTYS LEVEL(1)(SLEVEL), (RF ATT)OFFRF ATT(2)(SLEVEL), (RF ATT)ON(3)(NORMAL), (RF)ATT OFFDISPLAYP.CALL UPP.CALL FREQUENCY-TA/NEWSPI CODEPI 0000PI CODE ON/OFF(1)(2) (3)CYCLEAR-404/KRF-A4030/A4030E/A4030-S4CIRCUIT DESCRIPTION4. Microprocessor CXP82840-163Q, CXP82832-162Q (X09, IC51)4-1 Microprocessor periphery block diagram diagramFL DISPLAY ED5110GRID16SEGMENTX8X3X2X2X2X2X09, S516SERIAL COMMUNICATIONDATA BUSYVOLUMEENCODERX09, S518MULTIENCODERX09, S517SELECTORENCODERX2X38.0MHzCERESETX3X2TUNER MUTEAUDIO MUTEX09, IC52EEPROM-10dB ATTSDSTEREOKS0KS7KR0KR2X110-BT-216GKLED(STANDBY)POWER RELAYSPEAKER A RELAYSPEAKER B RELAYX09, IC51X09, IC3SELECTOR ICTC9164ANREMOCONCXP82840-163Q(E TYPE ONLY)CXP82832-162Q(OTHERS)Receiver u-COMX09, IC54RDS ICX05, IC2TUNERSAA6579/RE TYPE ONLYE TYPE ONLYLC72131X09, IC2VOLUME ICM62492FPBR24C02KEYMATRIXKR0(12)KR1(13)KR2(14)KS0(81)-S.DIRECTBANDKS1(80)SPEAKER B*DIMMER/PTY*P.CALL UP/DISPLAYKS2(79)SPEAKER APOWER*P.CALL DOWN/TA NEWSKS3(78)-KS4(77)-DSW3(507)KS5(76)DSW2(D505)DSW1(D504)DSW0(D510)KS6(75)TAPE2/MONITORSOUNDAUTOKS7(74)-BALANCEMEMORYPTY,DISPLAY and TA/NEWS keys are only RDS version(E type).Pin No.Pin name I/ODescriptionActive1,2G9,G10OFL grid control (9,10).3NC-u-Com +5V power supply.4RDS,CKIRDS IC clock input control. (E type only)5RDS,DTIRDS IC data input control. (E type only)6NCIu-Com +5V power supply.7VOL.ENC.AIVolume encoder A (CW) signal.8REMOCONIRemote control signal input.9VOL.ENC.BIVolume encoder B (CCW) signal.10,11NC-Unused.1214KR0KR2IKey return (02).15PROTECTIProtection detection signal input.H: Protection ON16S.DATAI/OSerial communication data.17S.BUSYI/OSerial communication busy.18E2.DATAI/OE2 PROM data.19E2.CLKOE2 PROM clock.20SEL.ENC2 CWISelector encoder A(CW) input.21SEL.ENC2 CCW2ISelector encoder B(CCW) input.22MLT. ENC3 CW3IMulti control encoder A(CW).23MLT. ENC3 CCW3IMulti control encoder B(CCW).248/16ISerial communication 8bit/16bit changeover.2527NC-Unused.28AV REF-Analog reference voltage (+5V).29S.LEVELISignal level A/D input. (E type only)3032NC-Unused.33PLL.DOIPLL IC DO signal input. (E type only)34PLL.STEREOITUNER stereo signal input.L: STEREO35PLL.SDITUNER SD signal input.L: TUNED36RCV.CEIReceiver chip enable signal input.L: ENABLE37AVSS-Analog ground.38RESETIu-Com reset.39EXTALIMain clock(8MHZ).40XTAL-Main clock(8MHZ).41VSS-u-Com ground.42TX-Unused.43TEXIGround.44VDD-Analog power supply (+5V).45VFDP-FL power supply(-33V).46SEL.STBOTC9164AF strobe.H: LATCH47SEL/PLL.DTOSelector/PLL IC data signal output.48SEL/PLL.CKOSelector/PLL IC clock signal output.49PLL.CEOPLL IC CE signal output.50T.MUTEOTuner mute control.L: MUTE ON51A.MUTEOAudio mute control.L: MUTE ON52NC-Unused.5310dB.ATTOVolume 10dB attenuator control.L: ATT ON54VOL.DTOVolume IC(M62492FP) data control.55VOL.CKOVolume IC(M62492FP) clock control.56VOL.STBOVolume IC(M62492FP) strobe control.5759NC-Unused.60RELAY.AOSP. relay A control.H: RELAY ON61RELAY.BOSP. relay B control.H: RELAY ON62,63NC-Unused.64POWER.RLYOPower relay control.H: RELAY ON65STANDBY.LEDOSTANDBY LED control.H: LED ON6671NC-Unused.72LIMITEROOutput power control at SP. (A+B). K/M/X only.73S.W MUTE-Unused.74,75KS6/KS7OKey scan 6,7.7681P1/KS5P6/KS0OFL segment 16/key scan 50.8288P7P13OFL segment 713.89VDDOu-Com +5V power supply.9092P14P16OFL segment 1416.93100G1G8OFL GRID 18.4.2Microprocessor pin descriptions: X09,IC515CIRCUIT DESCRIPTIONAR-404/KRF-A4030/A4030E/A4030-S636464548863104102637864644163104102646472631016379505488631026464102396462644963102646410286396482396310264641026386396310364641041036464104103646464547563104101646463735264547510464641016373396454881036464102863964491036464102638652641036464104103646410410364641041036464104103646410410364641041036464104103646410410364641041036464548810410278646441104102636464721041026351647610163795054886310263866441757950646464416310264751016379506464646448776310451646464644877636464104102865248771026464104102516476631041017864496310163795054886310163646463795064646464416310163647563101637950646464646448771046351646464646448776363646463104101638652487763102636464631041016351647610410163786449104101646410410164641041016464104101646410410164641041016379505488631046364756363795064646441631046351646464487763646472631046386524877631016464104101646410410163746453104101635564721041016364646310410163646463104101636464631017950548810264751027950646464646464646464491025164646464644877104736410286524877636464548863102637864644163102646472631026374645310363556472103746453631036364547510255647263103733954886374645310463863941633840891048639646410410164644188104873840633941886310363873840896378644188103873840891016351644910363873840896310163865264103873840891041036387384089631041037938488979504877636448776454756363733954886386394188637864491041016364102646410410174531026387387210263555363102746472631026387385310387384089103638738408963103793840891048750644089631046379386448891041016379506440771041026475637950646448896310410264646464644877631041035164644877638643776363646454886310410263786464416310410264647263104102646410410364641041036464104103646410410364641041036464645475631041016464637352645475104646410163733964548810364641028639644910364641026386526410364641041036464104103646410410364641041036464104103646410410364641041036464104103646410410363795064645488631026464646464644188102637440771017339644910263468963101637864641026464102646410263746453102635564721027464536310255408963102637440891038746896310363874689104873889631027946101638738646464646464644089101633864646464646464488963101873810363873864103873864641034689646410364641036464103646410364641036464103646410364641036464103646410364641036464103646464646464102636363636363636364636364636363745363636355726363636410163636410163745310163557210163646310163637453631016363557263101636364102637453102635572102636463102636463102636363636363636387381036387386410387386464103468964641036464103646410364641036464103646410364641036464103646410364641036464103646410364646464646410287506464548810263873840777339418863101635564721017864496310174645363101635164761015564726310163786449101646410364641016464103646410164641036464101646410364641016464103646410164641036464101516476631016374645310178644963101635564721016351647610174645363101638639417579384089631018652646448891026363636363636363646363646363637453636363557263636364101636364101637453101635572101636463101636374536310163635572631016363641026374531026355721026364631026364631026363636363636363 87506464548810263873840777339418863101635564721017864496310174645363101635164761015564726310163786449101646410364641016464103646410164641036464101646410364641016464103646410164641036464101516476631016374645310178644963101635564721016351647610174645363101638639417579384089631018652646448891028750646454881026387384077733941886310163556472101786449631017464536310163516476101556472631016378644910164641036464101646410364641016464103646410164641036464101646410364641016464103646410151647663101637464531017864496310163556472101635164761017464536310163863941757938408963101865264644889102873810363873864103873864641034689646410364641036464103646410364641036464103646410364641036464103646410364641036464103646464646464102875064645488102638738407773394188631016355647210178644963101746453631016351647610155647263101637864491016464103646410164641036464101646410364641016464103646410164641036464101646410364641015164766310163746453101786449631016355647210163516476101746453631016386394175793840896310186526464488910263636363636363636363636363636464631016363646463101636363636363636363646463101636364646310163636363636363638750646464646440101556464646464488910163746463104635553631047464896310464646464645475631027352646464641027339646476631016386396449631017864646310163646463101636453631017464726310163645488101638738531026351644175637938488910263865264646448771038738102638738641028738646410263873864646410287384089646410263873840896364641028738408910164641026387384089631016464102635564891026464102636464646464646464646464101636464646464646464646464101646410264641026464102646410264641026363636363636363636410463636476631036374644963103635564647610363637440896449103636355726351647663102637453101786449631026355721016351647610263637453631016378644910263635589631026464766310163746464646464646464644963101635560103636464631016363745363103635164761016363557263103637864491016363641041016464101636364646464641026364646464646464636363636363636363636363636363636464646410410164646464646363646476631036374646464631016364644963103635589646463101636464647610363646364646310163646364491037453636464631016364635164766310255726364646310163646378644963102646363646463101636463635164761016374536363646463101636463637864491016355726363646463101636463101516476636364101636464631016364631017864496374531016364646310163646310163516487387210163646463101636463101637864646463101636464631016364631025164536310163646463101636463102786472631016364646310163646464646463101636410163646464646464636363636363636363875054881025560664910251616753102875064645488102865248891026387384077733941886310410187384089101863941881041016387384089631016386394188631048738408910386394188104646338647263103638639418863103516464531041018639418810386524889104101638639417563102863964548863101638639644188101863964491016386526