Sparton-4900TV-Sams-64-11电路原理图.pdf

PHOTO FACT* Folder SPARTON MODELS 49OOTV, 4939TV, 494OTV, 4941TV VOLUME CONTROL CONTRAST CONTROL CHANNEL SELECTOR SPARTON MODEL 4940TV TRADE NAME Sparton Models 4900TV, 4939TV, 4940TV, 4941TV, (Chassis 24TV9, 24TV9C, 3TV9, 3TV9C, 9L8A.) MANUFACTURER Sparks-Withlngton Co., JacKeon, Michigan TYPE SET Television-Receiver (TV-AMFM- Phono Combination Model 4900TV only). TUBES Twenty-eight (Thirty-seven, Model *SOCTV) POWER SUPPLY 117 Volts, 60 cycle AC RATING 1.96 Amps on TV, .55 Amps on Radio 117 Volts TUNING RANGE Channels 2 through 15. 540-1620KC FKEQ. MOD. 88-108MC Alignment Instructions(AM-FM) Alignment Instructions (TV) Block Diagram Cable Connections-Model 4900TV Dial Stringing Disassembly Instructions High Voltage RF Osc. Adjustment Parts List and Description Photographs Cabinet-Rear View Capacitor Identification Chassis-Bottom View (AM-FM) 19 14 21 21 21 22,23,24,25,26 INDEX 11 Photographs (continued) 8,9,10 Chassis-Top View (AM-FM) Chassis-Top View (TV) High Voltage Supply Power Supply (TV) RF Tuner (TV) Resistor Identification 20 17,28 at low frequency end of dial. Use Insulated alignment screwdriver for adjusting. Dummy antenna consists of a 200MMFD cap. in series with a 20mllllhenry choke, the choke being shunted by a 400MMFD cap in series with a 100S2 carbon resistor Loop should be maintained in same relative position to chassis as when receiver is in cabinet. Volume control should be at maximum position. Output of signal generator should be no higher than necessary to obtain an output reading. Use an Insulated alignment screwdriver for adlustlna DUMMY ANTENNA .02MFD Dummy Ant. Dummy Ant. Dummy Ant. SIGNAL GENERATOR COUPLING High side to pin 7 (Grid) of 6BE6 (V29). Low side to chassis. High side to green antenna lead. Low side to chassis. SIGNAL GENERATOR FREQUENCY 456KC 1500KC 600KC BAND SWITCH POS. AM (center posi- tion) RADIO DIAL SETTING Tuning cap fully open 1500KC Tune for max Imum output OUTPUT METER Across voice coil ADJUST A49, A50, A51, A52 ASS A54, A55 AS6 REMARKS Adjust for maximum out- put. Rock tuning cap and ad- Just for maximum output. Repeat steps 71, 73, AC Voltage m ohms. 2. 3. Pin numbers ar lion on bottom Measured valu mon negative e counted in a of socket. es ore from so unless otherw are at 20,000 osured at 1,000 clockwise direc- ckelpintocom- se stated. 4. Line voltage ma age readings. 5. Front panels con 6. Where readings setting of the se and maximum ntainedat 117 volts for volt- trols set at minimum. may vary according to the vice controls, both minimum adings ore given. 1 Measured from pin 2 of V36 * Taken in KM position t Iteaured from pin 3 of V19 * tfeasured from pin 2 of V27 RadioFans.CN 1st SOUND I.F. VI3 2nd SOUND I.F. VI4 R.F.AMP. MIXER OSC VI V2 V3 A.F. AMP. V16 AUDIO OUTPUT VI7 RATIO DET. VI5 1st VIDEO I.F. V* 2nd VIDEO I.F. V5 3rd VIDEO I.F. V6 4th VIDEO I.F. V7 1st VIDEO AMP. V 9 2nd VIDEO AMP. VI0 D.C.RESTORER 1/2 Vll VIDEO DET. 1/2 V8 AUX. VIDEO VI2 AGC RECT 1/2 V 8 SYNC. SEP. 1/2 Vll SYNC. AMP. V18 SYNC. AMP. 1/2 V19 VERT. OSC. 1/2 V19VERT. OUTPUT V20 HOR. OUTPUT V23 DAMPER V24 L.V.RECT. H.V.OSC. H.V.RECT. HOR. OSC. V22 A.F.C.RECT. V21 BLOCK DIAGRAM A16C617 A1OO617 S13QOW NOlHVdS RadioFans.CN HIGH VOLTAGE SUPPLY-BOTTOM VIEW SPEAKER PLUGS - CHASSIS MOUNTING BOLTS POWER PLUG SPEAKER MOUNTING BOLTS POWER SUPPLY MOUNTING SCREWS CABINET-REAR VIEW PAGE 20 RadioFans.CN 1. 2. 4. 5. 6. 7. 8. 9. 10 11 DIAL CORD STRINGING AM FM CHASSIS 2 TURNS FINE TUNING CHANNEL SELECTOR 4 TURNS DISASSEMBLY INSTRUCTIONS MODEL 4900TV 1. Remove five push-on type control knobs. 2. Remove back cover from center compartment. 3. Remove speaker wires from transformer. 4. Remove HV lead from picture tube. 5. Remove power plug from TV chassis. 6. Disconnect AC plug toswltch on door. 7. Remove radio AC plug from power supply. 8. Remove pilot light from mounting bracket. 9. Disconnect antenna lead at cabinet. 10. Remove four hex head screws holding power supply chassis. Remove power supply. 11. Lay cabinet front down on floor. CAUTION: The radio panel and phono unit must either be fastened or held while tipping cabinet. 12. Remove two hex head screws from bottom of chassis. 13. Slide chassis far enough back to unhook holding lugs then lift chassis straight up out of cabinet. o o V) * -D NO CJ JO O -I MODELS 4939TV. 4940TV, 4941 TV. Remove five push-on type control knobs. Remove twelve phllllps head wood screws and two 1/4 hex head self tapping screws holding back cover. Remove cover. Disconnect power switch plug. And remove power plug from TV chassis, HV plug from picture tube, and remove cabinet light. Remove four 3/8; hex head metal screws holding power supply chassis. Remove power switch lever. Remove hex head nut holding power switch Remove Isolation lead from door hinge. Remove speaker wIres from output transformer. Remove four 3/8 hex nuts holding speaker. Remove speaker. Lay cabinet down on front. Remove two phllllps head wood screws holding antenna mounting strip. Remove powersupply chassis. Remove power swl tch. Remove two 3/8 hex head metal bolts 1rom bottom of chassis, lugs then remove by lifting straight up. Remove strip. Slide chassis back to unhook holding HIGH VOLTAGE RF OSCILLATOR ADJUSTMENT The high voltage output may be varied by adjustment of trimmer Bl which is located In the high volt- age compartment. This trimmer is adjusted for approximately 10KV on the high capacity side of the high voltage peak. This setting gives maximum efficiency and regulation. PAGE 21 RadioFans.CN PARTS LIST A TUBES (SYLVANIA or Equivalent) ITEM No. VI V2 V3 V4 V5 V6 V7 V8 V9 V10 Vll V13 V13 V14 V15 V16 V17 VIS V19 V30 V21 V22 V33 V24 V25 V26 V27 V38 V29 V30 V31 V32 V33 V34 V35 V36 V37 iiee UoE RF Amp. Mixer RF Oso. 1st Video IF 2nd Video IF 3rd Video IF 4th Video IF Video DET-AGC Rect. 1st Video Amp. 3nd Video Amp. DC Restorer- Sync . Sep . Aux. Video 1st Sound IF 2nd Sound IF Ratio Detector AF Amp. Audio Output Sync . Amp . Sync . Amp . -Vert Osc. Vert. Output AFC Rectifier Horiz. Osc. Horlz. Output Damper HV Osc. HV Rectifier LV Rectifier RF Amp. Converter 1st IF Amp. FM 2nd IF Amp. FM 3rd IF Amp. Ratio Det. DET.-AVC-AF Power Output Rectifier Picture Tube REPLACEMENT DATA SPAR1 ON PART No. 6BH6 6AG5 6C4 6BH6 6BH6 6BH6 6BH6 6AL5 6AU6 6AK6 6AL5 6AU6 6AU6 6AU6 6AL5 6AT6 6V6GT 6J6 6SN7GT 6V6GT 6AL5 12AU7 6L6G 5V4G 6SN7GT 1B3GT 5U4G 6BA6 6BE6 7A7 7AG7 7AG7 6AL5 7B6 TBS 5Y3GT 10BP4 STANDARD REPLACEMENT 6BH6 6AG5 604 6BH6 6BH6 6BH6 6BH6 6AL5 6AU6 6AK6 6AL5 6AU6 6AU6 6AU6 6AL5 6AT6 6V6GT 6J6 6SN7GT 6V6GT 6AL5 12AU7 6L6G 5V4G 6SN7GT 1B3GT 5U4G 6BA6 6BE6 7A7 7AG7 7AG7 6AL5 7B6 7B5 5Y3GT 10BP4 RMA BASE TYPE 7CM 7BD 6BG 7CM 7CM 7CM 7CM 6BT 7BK 7BK 6BT 7BK 7BK 7BK 68T 7BT 7AC 7BF 8BD 7AO 6BT 9A 7AC 5L 8BD 30 5T 7BK 7CH av 8V 8V 6BT 8W 6AE 5T NOTES CAPACITORS Capacity values given in the rating column are in mfd. for Electrolytic and Paper Capacitors, and in mmfd. for Mica and Ceramic Capacitors. ITEM No. CIA B 02 03 C4A B C D C5A B 0 C6A B C D 07 C8A B C 09 010 Cll 012 013 014 C15 016 C17 018 C19 020 C21 C22 C23 034 C35 C36 C37 038 039 C30 03 A B C 032 033 C34 C35A E C C36 037 038 CSSA E C RATING CAP. 40 40 80 80 15 15 15 50 10 10 20 15 15 15 50 5 40 40 30 3 15 15 15 15 15 47 470 470 470 47 1.5 470 100 10 10 470 470 370 1000 4700 1000 1000 1000 1000 100 370 1000 1000 1000 1000 270 5000 470 1000 1000 1000 VOLT 450 450 300 300 350 350 350 50 450 450 25 350 350 350 50 50 400 400 35 50 450 500 500 REPLACEMENT DATA SPARTON PART No. PA4304-3 PA4309-1 PA4309-1 PA4307-6 PA4300-10 PA4307-6 PA4303-13 PA4307-3 PA4308-1 PA4309-3 HK36M-271 HK36H-103 M061F-473 HK36H-103 PA4339-2 CC30A-101F HK36M-271 HK36H-102 PA4339-8 HK36M-371 PA4334-1 MC60E-471 PA4339-3 AEROVOX PART No. AFH88J AF88J AF88J AF444J PRS150/50 AF32J4A AF444J PRS 150/50 PRS 150/4 AF88J4A PRS150/4 1468-00025 1468-001 1467-005 1468-001 1468-001 1468-001 1468-001 146S-0001 1468-00025 1468-001 1468-001 1468-001 1468-001 1468-00025 1467-005 1468-001 1468-001 1468-001 CORNELL- DUBILIER PART No. UP4445 UP7AJ 1060 UP7AJ 1060 UP7DJ 1044 UP1145 C UP7DJ 1044 BR550 UP4445 C BR415 5W5T25 1W5D1 1D5D5 1D5D1 1D5D1 1D5D1 1D5D1 5R5T1 5W5T35 1W5D1 1W5D1 1W5D1 1W5D1 5W5T25 1D5D5 1W5D1 1W5D1 1W5D1 ERIE PART No. GP1K-15 GP1K-15 GP1K-15 GP1K-15 OP1K-50 GP3K-500 GP3K-500 GP3K-500 GP1K-50 NPOK-1.5 GP3K-500 GP1K-10 OP1K-10 GP3K-500 GP2K-500 GP2K-250 GP2L-001 GP2M-005 GP2L-001 GP2L-001 GP2L-001 GP2L-001 NPOM-100 GP2K-250 OP2L-001 GP2L-001 GP2L-001 GP2L-001 GP2K-250 GP2M-005 GP2K-500 GP2L-001 GP2L-001 GP2L-001 SOLAR PART No. M-TV-4- 50 DY-314 M-4-150 MO. 5-325 Mki. 5-21 W.5-25 MW.5-31 MW.5-21 MW.5-21 MW.5-21 MOS.5-31 MO. 5-325 MW.5-21 MW.5-21 MW.5-31 MW.5-21 MO. 5-325 MW.5-25 MW.5-21 MW.5-21 W.5-21 SPRAGUE PART No. TVL-64 TVL-5 TVL-5 TVL-52 TVA-13 TVL-54 TVA-13 1FM-325 1FM-21 1FM-25 1FM-21 1FM-21 1FM-21 1FM-21 1FM-31 1FM-325 1FM-21 1FM-21 1FM-21 1FM-21 1FM-325 1FM-25 1FM-21 1FM-21 1FM-21 IDENTIFICATION CODES AND INSTALLATION NOTES Filter A Filter Filter Filter Decoupling Sync. Amp. Plate Decoup. Decoupling Vert. Output Cath. Byp. 1st Video A;r,p. Screen Byp 2nd Video Amo. Screen Byp 2nd Video Amp. Cath. Byp. Sync. Amp. Decoup. Sound Output Decoup. Brightness Cont. Bypass Sound Output Oath. Bypass Stabilizing Cap. - Filter Filter A Output Oath. Bypass Stabilizing Cap. Decoupling RF Coupling n n n n n n AGC Filter RF Screen Bypass RF Bypass RF Coupling Osc. Coupling Mixer Screen Bypass Fixed Trimmer Osc. Feedback Osc. Grid Cap. Mixer Fil. Bypass Osc. Fll. Bypass IF Coupling Mixer Decoupling RF Bypass AGC Filter 1st IF Screen Bypass 1st IF Fll. Bypass 1st IF Decoupling Fixed Trimmer IF Coupling AGC Filter 2nd IF Screen Bypass 2nd IF Fll. Bypass 3nd IF Decoupling IF Coupling 3rd IF Cath. Bypass Fixed Trimmer 3rd IF Screen Bypass 3rd IF Fil. Bypass 3rd IF Decoupling ITEM No. 040 C41 042 C43J? E C 044 045 046 047 C48 049 050 051 052 053 55 056 C57 058 C59 060 061 062 063 064 365 C66 C67 C68 069 070 071 072 C73 074 075 076 077 078 079 080 C81A B C 083 C83 084 085 086 087 088 089 090 091 092 093 C94 C95 C96 097 098 099 C10C 010 010 cioe C104 cio: cioe cio1; C10E C1C9 cue Cll cm en; 0114 CUE cue Cll Cllf SUE C12C CIS C122 C13Z 124A E C12E 0126 012 C12 C12E CISC CIS C13 CISC 0134 C13E C13 CIS C13 013E RATING CAP. 370 5000 470 1000 1000 1000 22 4700 4.7 4.7 4700 10 .1 .1 .1 100 .25 100 1000 4700 100 1000 4700 .05 47 47 2000 .02 .02 .03 1000 .02 5100 .006 4700 4700 1000 1000 4700 4700 .01 .35 .01 3300 4700 4700 4700 5000 .25 .1 .1 470 470 6800 .1 330 680 4700 .5 .35 68 .04 .06 .05 .05 .05 1500 5600 470 .006 .02 .01 .05 .01 .01 .05 150 20000 20000 2000 330 2000 20000 20000 20000 100 30000 1000 100 100 20000 20000 30000 20000 20000 1000 51 85 10 5 46 51 20000 1000 10000 VOLT 500 500 400 400 200 200 500 500 200 400 400 200 400 500 600 500 500 500 500 600 400 400 500 400 400 300 500 50O 500 200 500 500 500 200 400 500 200 400 400 400 400 500 500 1000( 1000 400 200 400 400 400 200 500 500 500 500 500 500 REPLAC SPARTON No. HK36M-271 PA4334 1 MC60E-471 PA4339-2 CC30A-230K M361F-472 PA4328-11 PA4328-11 MC61F-472 CC30A-100F CC32A-101A OC32A-101A HK36H-102 MC61F-473 CC32A-101A HK36H-102 MC61F-472 CC30A-470F CCSOA-470F PA4334-3 HK36H-102 MC61G-512 MC61F-472 MC61F-472 HK36H-102 HK36H-103 MC61F-473 MC61F-473 PA4339-1 MC61F-473 PA4334-1 MC60E-471 MC60E-471 MC61F-682 MC60E-331 MC60F-681 MC61F-473 M061E-153 MC61F-562 PA4338 PC40GN-602 PC40GL-203 PC40GK-103 PC40GL-503 PC40GK-103 P040FL-103 PC40GK-503 MC60F-151 HK35G-203 HK35G-203 HK35G-202 HK35F-331 See Note 1 HK35G-203 HK35G-203 See Note 8 C60G-101 See Note 2 See Note 3 See Note 4 See Note 4 HK35G-203 See Note 5 See Note 6 See Note 7 HK35G-203 PA4325-2 MC60G-510 PA4328-6 CC31H-100K PA4328-5 PA4328-2 CC31H-510K HK35G-203 PA4325-2 PA4325-1 AEROVOX PART No. 1468-00025 1467-005 1468-001 1468-001 1468-001 1467-005 1468- 000005 1468- 000005 1467-005 1468-00001 P488-1 P488-1 P288-1 1468-0001 P488-25 1468-0001 1468-001 1467-005 1468-0001 1468-001 1467-005 P288-05 1468-00005 1468-00005 1467-002 P488-02 P488-02 P488-03 1468-001 P488-02 1468-005 P688-006 1467-005 1467-005 1468-001 1468-001 1467-005 1467-005 P688-01 P488-25 P488-01 1467-005 P488-25 P488-1 P338-1 1468-0005 1468-0005 P288-1 1468-0002 1467-005 P288-5 P488-25 P288-04 P488-05 P488-05 P488-05 P488-05 1464-0015 P1088-006 P488-02 P488-01 P488-05 P488-01 P488-01 P288-05 1468-00015 P488-02 P488-02 P688-002 1468-0003 1467-002 P488-02 P488-02 P488-02 1468-0001 P438-02 1468-001 1468-0001 1468-0001 P488-02 P488-02 P488-02 P488-02 P488-02 1468-001 1468-00005 1468_00001 1468- 000005 1469-00005 P488-02 1468-001 1467-01 CORN DUBIL PART 5WS1 1D5I 1W5I 1W5I 1W5I 5W5C 1D5I 5W5; 1D5E 5W5Q GT4F GT4F GT2P 5W5T GT2P 5W5T 1W5D 1D5D 5W5T 1W5D 1D5D GT2S 5W5Q 5W5Q 1W5D GT4S GT4S GT6S 1W5D GT4S 1D5D GT6D 1D5D 1D5D 1W5D 1W5D 1D5D 1D5D GT6S GT4P GT4S 1D5D GT4P GT4P GT2P 5W5T. 5W5T: 1D3D1 GT2P 5W5T: 1W5T 1D5D GT2P GT4P GT6S GT4S GT4S GT4S GT4S 1R5D GT16 GT4S GT2S GT4S GT4S GT4S GT2S 5W5T GT4S GT4S GT6D 5W5T 1W5D GT4S GT4S GT4S 5W5T GT4S 1W5D 5W5T 5W5T GT4S GT4S GT4S GT4S GT4S 1W5D 5W5Q 5W5Q 5W5V 5R5Q GT4S 1W5D 1D3S PAGE: 22 RadioFans.CN PARTS LIST AND DESCRIPTIONS ent) NOTES for Electrolytic nic Capacitors. SPRAGUE PART No. TVL-64 TVL-5 TVL-5 TVL-52 TVA-13 TVL-54 TVA-13 IFM-325 LFM-31 1FM-35 LFM-31 IFM-21 IFM-21 LFM-21 IFM-31 IFM-325 LFM-21 LFM-21 LFM-21 LFM-21 IFM-325 LFM-25 LFM-21 LFM-21 LFM-21 IDENTIFICATION CODES AND INSTALLATION NOTES - Filter * Filter Filter Filter Decoupling Sync. Amp. Plate Decoup. Decoupling Vert. Output Cath. Byp. 1st Video Air.p. Screen Byp 2nd Video Amp. Screen Byp 2nd Video Amp. Cath. Byp. Sync. Amp. Decoup. Sound Output Decoup . Brightness Oont. Bypass Sound Output Cath. Bypass Stabilizing Cap. Filter Filter A Output Cath . Bypass Stabilizing Cap. Decoupling RF Coupling n n n n n ii AGC Filter RF Screen Bypass RF Bypass RF Coupling Mixer Screen Bypass Fixed Trimmer Ssc. Feedback sc. Grid Cap. Mixer Fil. Bypass Osc. Fil. Bypass IF Coupling Mixer Decoupling RF Bypass AGC Filter 1st IF Screen Bypass 1st IF Fil. Bypass 1st IF Decoupling Fixed Trimmer IF Coupling AGC Filter 2nd IF Screen Bypass 2nd IF Fil. Bypass 2nd IF Decoupling IF Coupling 3rd IF Oath. Bypass Fixed Trimmer 3rd IF Screen Bypass 3rd IF Fil. Bypass 3rd IF Decoupling ITEM No. C40 C41 C42 C43A E C 044 C45 046 C47 048 C49 C50 C51 053 053 C54 055 C56 C57 C58 059 060 061 063 C63 064 C65 C66 C67 068 C69 C70 C71 C72 C73 C75 C76 077 C78 C79 C80 081A B C C82 C83 C84 C85 C86 C87 088 C89 C90 091 092 093 C94 C95 C96 C97 C98 099 0101 010: C10< C10E CIO 010E cioe cio1; ClOf C1C9 cue Oil C11S en; Oil/ Oil! OIK en1; Cllf 011 C12 C12 0122 013 0134A C12 C12 C12 C13 012 CIS C13 CIS CIS CIS CIS 013 CIS CIS RATING CAP. 370 5000 470 1000 1000 1000 22 4700 4.7 4.7 4700 10 .1 .1 .1 100 .25 100 1000 4700 100 1000 4700 .05 47 47 2000 .03 .02 .03 1000 .02 5100 .006 4700 4700 1000 1000 4700 4700 .01 .25 .01 3300 4700 4700 4700 5000 .25 .1 .1 470 470 6800 .1 220 680 4700 .5 .25 68 .04 .06 .05 .05 .05 1500 5600 470 .006 .03 .01 .05 .01 .01 .05 150 20000 30000 2000 330