Philips-ACT500-pcd-sm 维修电路原理图.pdf

Technical specification .1-1Features .1-1Accessories .1-1Instruction For Use.1-2.1-6Safety & Warnings.1-7Service hintsRepair positions .2-1Dismantling CD-door.2-1Handling chip components.2-2Service tools.2-2Pin description of ICs .3-1.3-8Start-up procedure.3-9Service Test Program.3-10Service Test Program-flow chart .3-10Blockdiagram.3-12Circuit diagramsControl/Supply part.4-1Drive/EPS part.4-2Audio part .4-3Layout diagarmsCopper side view.4-4Component side view .4-5Exploded view diagram .5-1Mechanical partslist.5-1Electrical partslist .6-1.6-2 3140 785 32620Published by LX 0334 Service Audio Printed in The Netherlands Subject to modificationPortable CD PlayerCLASS 1LASER PRODUCTTABLE OF CONTENTSCopyright 2003 Philips Consumer Electronics B.V. Eindhoven, The NetherlandsAll rights reserved. No part of this publication may be reproduced, stored in a retrievalsystem or transmitted, in any form or by any means, electronic, mechanical, photocopying,or otherwise without the prior permission of Philips.ACT500all versionspsacdRadioFans.CN 收音机爱 好者资料库1-1TECHNICAL SPECIFICATIONGeneralDimensions (Dia x H): 146 x 24 mmWeight without batteries: 220gShock resistance+X/-X direction: 2.5g+Y/-Y direction: 2.5g+Z/-Z direction: 2.0gPower supply modes Battery lifetimeBattery level detection Measurement setup CDUse Audio Signal disc SBC429 4822 397 30184Current consumptionHeadphone out (measured with 16 load, DBB/ESP off)Output power (THD=10%)/17 version only: 8mW (+1/-3dB)all other versions: 4mW (+2/-2dB)Frequency response (1mW): 100Hz-20kHz within 6dBS/N ratio (unw.): 80dB (82dB typ.)S/N ratio (A-wght): 82dB (84dB typ.)THD+N CD (1kHz, 1mW): 1% (0.2% typ.)Crosstalk (1kHz, w/o load): -24dB (-44dB typ.)Channel unbalance (-40dB): 5dBVolume attenuation (1kHz): 60dBDynamic Bass Boost DBBEDOMNOITAREPO)V5.4(YLPPUSNI -CD)V52.2(YLPPUS.TTABPowersaveNOP=SENOP=SEPowersavePLAYCHARGEJUMP 80mA typ.150mA 400mA typ.400mA typ.Stand- by (excl.recharge)90mA typ.1mA 150mA n/an/a120mA typ.80mA typ.120mA typ.LEVELNOITCETEDsei ret tabyrami rP Battery empty Difference btw.battery level 1 and battery empty Difference btw.battery level 2 and battery empty Difference btw.battery level 3 and battery empty1.8V+100/-50mVbattery empty level +0.3V 100mVbattery empty level +0.45V 150mVbattery empty level +0.75V 100mVEPYTYRETTABat PSM inlimat PSM intypse i ret tabyrami rPRechargable batteriesAY3363AAAx2at ESP=on in at ESP=on in 10 h12h 8 h10h 3.5 h4h 5 h6h limtypEDOMYLPPUSegnaregat loVtekcosNI -CDV0.6-5.2se i ret tabyrami rPse i ret tabRechargableV6.3-8.1V6.3-8.1Feature OverviewLow pass filterDUTS/N and distortion meterLRi.e. Sennheiser UPM550with FF-filterLevel meteri.e. Sound Technology ST1700Bi.e. 4822 395 3020422kHz13th orderACCESSORIESEGATSBBDesnopserycneuqerFzH36zHk1zHk010dB 0dB 2dB 2dB0dB 0dB 2dB 2dB+8+8dB dB 2dB 2dBDBB 1PORTABLE CD PLAYERFOSERUTAEF005TA)sno i srevl l a(WM/MFRENUTYTILIBITAPMOCELBATIRWER-DCN CDDA / MP3OITCETORPPIKSCINORTCELEs / 90EZISMARDPSEt i bM32NOITCNUFEMUSER/DLOH / SEGATSBBD1KCABDEEFCITSUOCAYROMEMMARGORPHMiN/dCiNNOITCNUFEGRAHCERDERAPERPLORTNOCETOMERDROC-/-/-CE CD PLAYER LBATROPROFSEIROSSECCAT500CAC00/10/50/11/71/00/0713YArotpadACD/CAX20/0713YArotpadACD/CAXXXXXX7E7/SBC HJ050enohpdaeHoeretSXBattery ALK 1.5V LR03PLXXXXXXXXXXXX3140 118 336303140 118 320209082 100 021799082 100 90013AY3781 Remote controlXXXXX3140 118 51511Waist BeltXXXXXXXX3140 113 10581Butterfly-NIKE3140 118 72161GR1-AX Mains Plug Adaptor3139 128 73011AY3293 Carry Pack3140 113 10641 AY3363 Battery-NIMH-AAA3103 308 84721 RadioFans.CN 收音机爱 好者资料库1-213452;6!off/resume/holdoff/resume/hold2123456789101112131QUICK STARTMISE EN SERVICE RAPIDEenglishcontrolssupplied accessories 1 x headphones, HJ050 1 x remote control, AY3781 1 x AC/DC adapter, AY3170 2 x rechargeable batteries, AY3363 1 x hand strap / waist pack, AY3293controls( see figure 1 )1 mode.selects the different playing possibilities: shuffle,shuffle repeat, repeat and2 eq.switches the bass enhancement on and off. this button also switches acoustic feedback (the beep)on/off when it is pressed for more than 2 seconds3 esp .toggle to select between the battery powersave modeand electronic skip protection (esp). esp ensures continuous cd playback regardless of vibrations andshocks4 p.3.5 mm headphone socket, socket to connect theplayer to another audio input of an additional appliance, remote control socket 5 +/+/ . adjusts the volume6 5 .skips and searches cd tracks backwards7 indicator.lights up : red (battery low / power down) ,green (power up), orange (pause mode)8 2;.switches the player on, starts or pauses cd play9 9.stops cd play, switches the player off0 6 .skips and searches cd tracks forwards! DC.socket for external power supply21 12 23 34 45 55 54 46 6INSTRUCTION FOR UES1-3controls / accessoriescontrols( see figure 1 ) off.switches resume and hold offresume.stores the last position of a cd track playedhold .locks all buttons#.opens the cd lidsremote controlAY3781 ( see figure 2 )1 p.3.5 mm headphone plug to connect to headphonessocket2 hold .locks all buttons3 stop.stops playback and switches the set off45 / 6.skips and searches forward / backward tracks5 +/ +/ .adjusts the volume6 2;.switches the set on, starts playback and interruptsplaybackconnecting the remote controluse only the AY 3781 remote control.1press 9 on the set twice to switch off theset.2firmly connect the remote control to p onthe set.3firmly connect the headphones to the plugon the remote control.4on the remote control keep 2; pressed for1 second to switch on the set and to start playback.5adjust the volume and sound on the psa and your remote control.clip magnetswear your remote control and secure your headphone cord with these wearable magnets.1 check the polarity of the 2 button magnets. insert the big button magnetunderneath your garment.2 clip the small button magnet on your outergarment. clip the remote control on top.3 secure your headphone cord with the butterfly magnet clip.WARNING:KEEP OUT OF REACH OF SMALL CHILDREN TO AVOID CHOKING HAZARD.KEEP THE MAGNETS AWAY FROM CREDIT CARDS, TAPES ANDANY ITEMS, WHICH MAY BE SENSITIVE TO THE MAGNETS.USERS OF PACEMAKERS OR OTHER IMPLANTED DEVICES SHOULD CONSULT THEIR PHYSICIAN BEFORE USING MAGNETS OR DEVICES THAT MAY GENERATE ELECTRO-MAGNETIC INTERFERENCE.accessories / power supplyhand strap / waist pack AY3293wear your cd player during sport activity by securing it to the supplied hand strap / waist pack. 1 open the strap enclosure on the back of thehand strap / waist pack and slide the cdplayer inside. make sure the headphone /remote socket is aligned to the socket hole.2 thread the strap.3 position your hand and adjust the strap untilthe fit is snug and comfortable.batteries (supplied or optionally available)you can use the following batteries with this cd-player:alkaline batteries type AAA (LR03, UM4) or rechargeable ECO-PLUSNiMH battery.notes:old and new or different types of batteries should not be combined. remove batteries if they are empty or if the player is not going to beused for a long time.inserting batteries1push to open the cd door2open the cd compartment and insert 2 xAAA batteries.battery indicationthe approximate power level of your batteriesis shown in the display.(on remote control)battery fullbattery two-thirds fullbattery one-third fullbattery dead or empty. when the batteriesare dead or empty, the symbol flashes,is displayed, and the beep tonesounds repeatedly.indicator lights up orange and beeps briefly. indicator then turns red before player switches off.average playing time of batteries under normal conditionsbattery typeesp + power savenormal AAA3 hoursalkaline AAA12 hoursrechargeable ECO-PLUS NiMH battery10 hoursbatteries contain chemical substances, so they should be disposed of properly.cautionuse of controls or adjustments or performance of procedures other than herein may result in hazardousradiation exposure or other unsafe operation.this set complies with the radio interference requirements of the European Community.the model and serial numbers are located inside the cd door.INSTRUCTION FOR USE1-4power supply / general informationECO-PLUS NiMH battery information (for versions supplied with the rechargeable ECO-PLUS NiMH battery AY 3363)recharging works only on players supplied with the rechargeable ECO-PLUS NiMH battery AY 3363.recharging the ECO-PLUS NiMH battery on board1insert the rechargeable ECO-PLUS NiMH battery AY 3363.2connect the mains adapter to the DC socket of the player and then tothe wall socket.yis pulsing. recharging stops after a maximum of7 hours, or when you start playback.3when the battery is fully recharged, appears in the display.notes: it is normal for the batteries to become warm during recharging. if the batteries become too warm, recharging will be interrupted forapproximately 30 minutes andis displayed. to ensure proper recharging on board, take care that contacts are clean. use only the ECO-PLUS NiMH battery AY 3363.handling instructions recharging already charged or half-charged batteries will shorten theirlifetime. we therefore recommend that you let the rechargeable ECO-PLUS NiMH battery run till it is completely empty before yourecharge it. to avoid a short circuit, do not let the battery touch any metal object. if the battery becomes empty soon after recharging, then either itscontacts are dirty or it has reached the end of its lifetime.mains adapter (supplied or optionally available)use only the AY 3170 power adapter suppliedwith your product (4.5 V / 300 mA direct current, positive pole to the centre pin). anyother product may damage the player.1make sure the local voltage corresponds tothe adapters voltage.2connect the adapter to the DC socket of theplayer and to the wall socket.note: always disconnect the adapter when you are not using it.environmental informationall redundant packing material has been omitted. we have done ourutmost to make the packaging easily separable into two mono materials: cardboard and polyethylene.your set consists of materials which can be recycled if disassembledby a specialized company. please observe the local regulations regarding the disposal of packing materials, exhausted batteries andold equipment.headphones HJ050 connect the supplied headphones to the psocket of the player.note:pcan also be used for connecting this setto your hifii system to adjust the sound and volume, use the controls on the connected audioequipment and on the cd player.take care when using headphoneshearing safety: listen at a moderate volume.using headphones at high volume can impair your hearing.traffic safety: do not use headphones while driving or cycling as youmay cause an accident.general information / cd playcd player and cd handlingdo not touch the lens A of the cd player.do not expose the unit, batteries or cds tohumidity, rain, sand or excessive heat (causedby heating equipment or direct sunlight).you can clean the cd player with a soft, slightly dampened, lint-free cloth. do not useany cleaning agents as they may have a corrosive effect.to clean the cd, wipe it in a straight line from the center toward theedge using a soft, lint-free cloth. a cleaning agent may damage thedisc! never write on a cd or attach a sticker to it.the lens may cloud over when the unit is moved suddenly from coldto warm surroundings. playing a cd is not possible then. leave thecd player in a warm environment until the moisture has evaporated.active mobile phones in the vicinity of the cd player may cause malfunctions.avoid dropping the unit as this may cause damage.in-car use (connections supplied or optionally available)only use the AY 3545 or AY 3548 car voltage converter (4.5 V DC, positive pole to the centre pin) and the AY 3501 car cassette adapter.any other product may damage the set.1put the set on a horizontal, vibration-free andstable surface. make sure it is in a safe place,where the set is neither a danger nor an obstacle to the driver and the passengers.2plug the voltage converter into the cigarettelighter socket (only for 12 V car battery, negative grounding), then connect the wiredend with 4.5V DC input socket on the set.3if necessary, clean the cigarette lighter socketto obtain a good electrical contact.4turn down the volume and connect the cassette adapter plug to p onthe set.5carefully insert the cassette adapter into the car radios cassette compartment.6make sure the cord does not hinder your driving.7decrease the volume on the set if necessary. start playback on theset and adjust the sound with the car radio controls.always remove the voltage converter from the cigarette lighter socketwhen the set is not in use.notes: if your car radio has a LINE IN socket, it is better to use it forthe car radio connection instead of the cassette adapter. connect thesignal lead to this LINE IN socket and to p on the set.4,5 V DC12 V DCINSTRUCTION FOR USE1-5cd play / featuresplaying a cdthis cd-player can play all kinds of audio discssuch as cd-recordables and cd-rewritables. donot try to play a cd-rom, CDi, VCD, DVD orcomputer cd.1push the slider to open the player.2insert an audio cd, printed side up, bypressing the cd onto the hub. 3close the player by pressing the lid down.4press 2; to switch the player on and start playback.ythe current track number and elapsed playing time are displayed. indicator lightsup green. you can pause playback by pressing 2;.ythe time at which playback was pausedstarts flashing. indicator turns orange andflashes. you can continue playback by pressing 2;again.5press 9 to stop playback.ythe total number of tracks and the totalplaying time of the cd are displayed.6press 9 again to switch the player off. indicatorlights up red and gradually turns off. to remove the cd, hold it by its edge and pressthe hub gently while lifting the cd.note: if there is no activity, the set will automatically switch off after a while to saveenergy.playback information if a cd-recordable (CD-R) or a cd-rewritable(CD-RW) is not recorded properly,isdisplayed, indicating that the cd has not beenfinalized. in that case, use FINALIZE on yourcd recorder to complete the recording.when playing a cd-rewritable (CD-RW), pleasenote that it takes 315 seconds after pressing2; for sound reproduction to start.playback will stop if you open the cd lid.while the cd is read, 1 -:- flashes in the display.volume and bassvolume adjustment adjust the volume by using +/ (+/ (vol).bass adjustmentpress eq (on the set only) to switch the bassenhancement on or offydbb is shown if the bass enhancement isactivated.featuresselecting a track and searchingselecting a track during playback briefly press 5 or 6 once or several times toskip to the current, previous or next track.yplayback continues with the selected track,and the tracks number is displayed.selecting a track when playback is stopped1briefly press 5 or 6 once or several times toselect the desired track. the track number is displayed.2press 2; to start cd play.yplayback starts with the selected track.sear